Optical Fiber Sensing for Sub-Millimeter Liquid-Level Monitoring: A Review

Fiber optic-based liquid-level sensors (FOLLSs) can work in harsh environments with inherent advantageous features that only optical fiber offers, such as intrinsic safety, resistance to chemical corrosion, immunity to electromagnetic interference, electric isolation, small size, lightweight sensing heads, high accuracy and resolution, easy multiplexing, and capability for extremely remote monitoring without the need of electrical power at the measuring point. In this context, this paper presents three specific optical fiber sensor technologies that show considerable potential for liquid-level monitoring: the Mach–Zehnder and Fabry–Perot interferometers and the fiber Bragg gratings (FBGs). Mathematical models and operation principle are presented for each sensor technology, and parameters, such as level range, level sensitivity, and temperature cross sensitivity, are analyzed. Finally, a critical and comparative analysis among the sensors is performed, where it is reported a tradeoff between sensitivity and level range.

[1]  Asrul Izam Azmi,et al.  Graphene diaphragm integrated FBG sensors for simultaneous measurement of water level and temperature , 2016 .

[2]  R. Shorthill,et al.  Fiber ring interferometer. , 1976, Applied optics.

[3]  C. P. Nemarich.  Time domain reflectometry liquid level sensors , 2001 .

[4]  Dongcao Song,et al.  Liquid-level sensor using a fiber Bragg grating and carbon fiber composite diaphragm , 2011 .

[5]  Zhengjia Li,et al.  Asymmetric Fabry-Pérot fiber-optic pressure sensor for liquid-level measurement. , 2009, The Review of scientific instruments.

[6]  Ruohui Wang,et al.  In-fiber quasi-Michelson interferometer for liquid level measurement with a core-cladding-modes fiber end-face mirror , 2014 .

[7]  Xinlei Zhou,et al.  Pressure sensor based on the fiber-optic extrinsic Fabry-Perot interferometer , 2011 .

[8]  Maria José Pontes,et al.  A cost-effective edge-filter based FBG interrogator using catastrophic fuse effect micro-cavity interferometers , 2018, Measurement.

[9]  Lecheng Li,et al.  All-fiber Mach-Zehnder interferometers for sensing applications. , 2012, Optics express.

[10]  Tao Wei,et al.  Fiber Inline Core–Cladding-Mode Mach–Zehnder Interferometer Fabricated by Two-Point CO$_{2}$ Laser Irradiations , 2009, IEEE Photonics Technology Letters.

[11]  Dipankar Sengupta,et al.  Continuous liquid level monitoring sensor system using fiber Bragg grating , 2014 .

[12]  Zhaobing Tian,et al.  Single-Mode Fiber Refractive Index Sensor Based on Core-Offset Attenuators , 2008, IEEE Photonics Technology Letters.

[13]  Wenhua Wang,et al.  Diaphragm-based extrinsic Fabry-Perot interferometric optical fiber pressure sensor , 2010, International Symposium on Advanced Optical Manufacturing and Testing Technologies (AOMATT).

[14]  Sumei Wang,et al.  Highly Sensitive Refractive Index Optical Fiber Sensors Fabricated by a Femtosecond Laser , 2011, IEEE Photonics Journal.

[15]  Jian-Neng Wang,et al.  Long-Period Fiber Grating Sensors for the Measurement of Liquid Level and Fluid-Flow Velocity , 2012, Sensors.

[16]  Li Pei,et al.  Fiber-Optic Laser Sensor Based on All-Fiber Multipath Mach–Zehnder Interferometer , 2016, IEEE Photonics Technology Letters.

[17]  R. Ferreira,et al.  Low-Cost and High-Performance Optical Fiber-Based Sensor for Liquid Level Monitoring , 2019, IEEE Sensors Journal.

[18]  K. Hill,et al.  Fiber Bragg grating technology fundamentals and overview , 1997 .

[19]  Arnaldo G. Leal-Junior,et al.  Multi-interface level in oil tanks and applications of optical fiber sensors , 2018 .

[20]  Gang-Ding Peng,et al.  Highly sensitive liquid level monitoring system utilizing polymer fiber Bragg gratings. , 2015, Optics express.

[21]  Yiping Cui,et al.  Highly Sensitive Liquid-Level Sensor Based on Etched Fiber Bragg Grating , 2007, IEEE Photonics Technology Letters.

[22]  Li Pei,et al.  All-fiber multipath Mach⬜Zehnder interferometer based on a four-core fiber for sensing applications , 2016 .

[23]  Carlos A. F. Marques,et al.  Low-Cost Interrogation Technique for Dynamic Measurements with FBG-Based Devices , 2017, Sensors.

[24]  Arnaldo G. Leal-Junior,et al.  Liquid Level Measurement Based on FBG-Embedded Diaphragms With Temperature Compensation , 2018, IEEE Sensors Journal.

[25]  G. Hernandez,et al.  Fabry-Perot Interferometers , 1986 .

[26]  Kyriacos Kalli,et al.  Fiber Bragg Gratings: Fundamentals and Applications in Telecommunications and Sensing , 2000 .

[27]  R. Nogueira,et al.  Monitorization of sea sand transport in coastal areas using optical fiber sensors , 2009, 2009 IEEE Sensors.

[28]  Qing Bai,et al.  Design and Implementation of an Intrinsically Safe Liquid-Level Sensor Using Coaxial Cable , 2015, Sensors.

[29]  Mahmoud Meribout,et al.  Interface Layers Detection in Oil Field Tanks: A Critical Review , 2011 .

[30]  Shuisheng Jian,et al.  Liquid level and temperature sensing by using dual-wavelength fiber laser based on multimode interferometer and FBG in parallel , 2018 .

[31]  Deming Liu,et al.  All-solid multi-core fiber-based multipath Mach–Zehnder interferometer for temperature sensing , 2013 .

[32]  Tao Lü,et al.  Extrinsic Fabry-Perot cavity optical fiber liquid-level sensor. , 2007, Applied optics.

[33]  H. Haus.  Waves and fields in optoelectronics , 1983 .

[34]  Kaiming Zhou,et al.  Liquid level sensor based on an excessively tilted fibre grating , 2013 .

[35]  Moisés R. N. Ribeiro,et al.  Envelope-based technique for liquid level sensors using an in-line fiber Mach-Zehnder interferometer. , 2016, Applied optics.

[36]  P. Yeh,et al.  Photonics : optical electronics in modern communications , 2006 .

[37]  I. Bennion,et al.  Implementation and Characterization of Liquid-Level Sensor Based on a Long-Period Fiber Grating Mach–Zehnder Interferometer , 2011, IEEE Sensors Journal.

[38]  P. André,et al.  Cost-effective optical fiber pressure sensor based on intrinsic Fabry-Perot interferometric micro-cavities , 2018 .

[39]  Peter Jackson,et al.  Recent developments in hydrocarbon separator interface imaging , 2001, SPIE Optics East.

[40]  Moisés R. N. Ribeiro,et al.  Corrosion Resistant FBG-Based Quasi-Distributed Sensor for Crude Oil Tank Dynamic Temperature Profile Monitoring , 2015, Sensors.

[41]  Xinyong Dong,et al.  All-Fiber Mach–Zehnder Interferometer for Liquid Level Measurement , 2015, IEEE Sensors Journal.

[42]  Yu-Lung Lo,et al.  Application of Fiber Bragg Grating Level Sensor and Fabry-Pérot Pressure Sensor to Simultaneous Measurement of Liquid Level and Specific Gravity , 2012, IEEE Sensors Journal.

[43]  Ben Xu,et al.  A Thin-Core Fiber Modal Interferometer for Liquid-Level Sensing , 2012 .

[44]  Maria José Pontes,et al.  IoToF: A Long-Reach Fully Passive Low-Rate Upstream PHY for IoT over Fiber , 2019 .

[45]  Byeong Ha Lee,et al.  Interferometric Fiber Optic Sensors , 2012, Sensors.

[46]  Yunshan Zhang,et al.  High sensitivity optical fiber liquid level sensor based on a compact MMF-HCF-FBG structure , 2018 .

[47]  Jian Wang,et al.  Temperature-Independent Ultrasensitive Fabry–Perot All-Fiber Strain Sensor Based on a Bubble-Expanded Microcavity , 2014, IEEE Photonics Journal.

[48]  J. H. Cole,et al.  Fiber‐optic detection of sound , 1977 .

[50]  Yu-Lung Lo,et al.  Application of Fabry–Pérot and fiber Bragg grating pressure sensors to simultaneous measurement of liquid level and specific gravity , 2012 .

[51]  Tao Zhu,et al.  In-fiber Mach–Zehnder interferometer formed by large lateral offset fusion splicing for gases refractive index measurement with high sensitivity , 2011 .

[52]  Kai Ni,et al.  An optical liquid level sensor based on polarization-maintaining fiber modal interferometer , 2014 .

[54]  Min Liu,et al.  In-Line Fiber Optic Interferometric Sensors in Single-Mode Fibers , 2012, Sensors.

[55]  Raman Kashyap,et al.  An Ultra-Sensitive Liquid-Level Indicator Based on an Etched Chirped-Fiber Bragg Grating , 2016, IEEE Photonics Technology Letters.

[56]  Moisés R. N. Ribeiro,et al.  Simultaneous measurement of pressure and temperature with a single FBG embedded in a polymer diaphragm , 2019, Optics & Laser Technology.

[57]  Moisés R. N. Ribeiro,et al.  Combined Bending and Torsion Sensing by Induced Birefringence in Distributed Bragg Reflector Laser , 2019, Journal of Lightwave Technology.

[58]  Cheng-Ling Lee,et al.  Highly Sensitive Tapered Fiber Mach–Zehnder Interferometer for Liquid Level Sensing , 2013, IEEE Photonics Technology Letters.

[59]  Zhaobing Tian,et al.  In-Line Single-Mode Optical Fiber Interferometric Refractive Index Sensors , 2009, Journal of Lightwave Technology.

[60]  Brian Culshaw,et al.  Optical Fibre Sensors: a Current Perspective , 2013 .

[61]  Wei Jian,et al.  Liquid level measurement by applying the Mach-Zehnder interferometer based on up-tapers. , 2014, Applied optics.

[62]  J. Gates,et al.  Miniaturization of Bragg-multiplexed membrane transducers , 2012 .

[63]  K. Sooley,et al.  Tapered fiber Mach–Zehnder interferometer for simultaneous measurement of refractive index and temperature , 2009 .

[64]  Ping Lu,et al.  Extreme Environment Sensing Using Femtosecond Laser-Inscribed Fiber Bragg Gratings , 2017, Sensors.

[65]  Liquid-Level Sensor Based on Reflective Mechanically Induced Long-Period Grating Using Double-Cladding Fiber , 2018, IEEE Sensors Journal.

[66]  Hao Zhang,et al.  Tilted fiber Bragg gratings: Principle and sensing applications , 2011 .

[67]  Gerard C. M. Meijer,et al.  Liquid-level measurement system based on a remote grounded capacitive sensor , 2007 .

[68]  Kevin P. Chen,et al.  Tapered fibre Mach-Zehnder interferometer for simultaneous measurement of liquid level and temperature , 2011 .

[69]  Y. Rao.  Recent progress in fiber-optic extrinsic Fabry–Perot interferometric sensors , 2006 .

[70]  Zhenfeng Gong,et al.  Fiber Optic Liquid Level Sensor Based on Integration of Lever Principle and Optical Interferometry , 2014, IEEE Photonics Journal.

[71]  H. Choi,et al.  All-fiber Mach-Zehnder type interferometers formed in photonic crystal fiber. , 2007, Optics express.

[72]  Moisés R. N. Ribeiro,et al.  Multi-Parameter Interferometric Sensor Based on a Reduced Diameter Core Axial Offseted Fiber , 2017, IEEE Photonics Technology Letters.

[73]  A. Zhang,et al.  Fiber-optic refractive-index sensors based on transmissive and reflective thin-core fiber modal interferometers , 2010 .

[74]  E. Vorathin,et al.  A Novel Temperature-Insensitive Hydrostatic Liquid-Level Sensor Using Chirped FBG , 2019, IEEE Sensors Journal.

[75]  Gerald Hefferman,et al.  Multiplexed Oil Level Meter Using a Thin Core Fiber Cladding Mode Exciter , 2015, IEEE Photonics Technology Letters.

[76]  Kok-Sing Lim,et al.  Chronology of Fabry-Perot Interferometer Fiber-Optic Sensors and Their Applications: A Review , 2014, Sensors.

[77]  Salvador Sales,et al.  Continuous Liquid-Level Sensor Based on a Long-Period Grating and Microwave Photonics Filtering Techniques , 2016, IEEE Sensors Journal.

[78]  Jian Liang,et al.  Online fabrication scheme of helical long-period fiber grating for liquid-level sensing. , 2016, Applied optics.

[79]  Govind P. Agrawal,et al.  Fiber-optic communication system , 2002 .

[80]  Paulo F. C. Antunes,et al.  Optical Fiber Microcavity Strain Sensors Produced by the Catastrophic Fuse Effect , 2014, IEEE Photonics Technology Letters.

[81]  S. James,et al.  Fiber-optic liquid-level sensor using a long-period grating. , 2001, Optics letters.

[82]  Yin Zhang,et al.  A Highly Sensitive Fiber-Optic Fabry–Perot Interferometer Based on Internal Reflection Mirrors for Refractive Index Measurement , 2016, Sensors.

[83]  Jing Li,et al.  Liquid level and temperature sensor based on an asymmetrical fiber Mach-Zehnder interferometer combined with a fiber Bragg grating , 2016 .

[84]  Christopher Holmes,et al.  Integrated optical differential pressure transducers achieved using thin buckled silica membranes and direct UV written planar Bragg gratings , 2011 .

[85]  Humberto Varum,et al.  Liquid Hydrostatic Pressure Optical Sensor Based on Micro-Cavity Produced by the Catastrophic Fuse Effect , 2015, IEEE Sensors Journal.

[86]  Wenhua Wang,et al.  Large-range liquid level sensor based on an optical fibre extrinsic Fabry–Perot interferometer , 2014 .

[87]  Sumei Wang,et al.  A High-Quality Mach-Zehnder Interferometer Fiber Sensor by Femtosecond Laser One-Step Processing , 2010, Sensors.

[88]  C. Liao,et al.  Simultaneous measurement of strain and temperature by employing fiber Mach-Zehnder interferometer. , 2014, Optics express.

[89]  Michael A. Davis,et al.  Fiber grating sensors , 1997 .

[90]  Xiu Min Ang,et al.  Label-free fiber-optic interferometric immunosensors based on waist-enlarged fusion taper , 2013 .

[91]  J S Sirkis,et al.  In-line fiber étalon for strain measurement. , 1993, Optics letters.

[92]  Bryant D. Taylor,et al.  A Wireless Fluid-Level Measurement Technique , 2007 .

[93]  D. J. Webb,et al.  Aviation Fuel Gauging Sensor Utilizing Multiple Diaphragm Sensors Incorporating Polymer Optical Fiber Bragg Gratings , 2016, IEEE Sensors Journal.