Optical and structural properties of Ge–Sb–Se thin films fabricated by sputtering and thermal evaporation

Abstract We deposited Ge28Sb12Se60 chalcogenide films using either thermal evaporation or radio-frequency magnetron sputtering techniques, and then measured their structural and optical properties using various diagnosis tools. The refractive indices of the films were obtained from the transmission spectra based on Swanepoel method, and the optical band gaps were derived from optical absorption spectra using the Tauc plot. Raman and X-ray photoelectron spectra (XPS) were measured and decomposed into several peaks that correspond to the different structural units, and then the evolution of the relative concentrations of the structural units was investigated in order to build up the correlation between the structure and optical properties of the films. It was found that, the films generally possess a large number of Ge2Se6/2, Sb2Se4/2 units and Se–Se bonds, and therefore are relatively higher defective compared with their bulk counterpart. This together with the modification of the chemical compositions results in a higher refractive index as well as a smaller optical band gap in the films. Thermal annealing of the deposited films could convert the optical and structure properties of the films close to those of bulk glass.

[1]  Steve Madden,et al.  Rebonding of Se to As and Ge in Ge33As12Se55 films upon thermal annealing: Evidence from x-ray photoelectron spectra investigations , 2007 .

[2]  B. Luther-Davies,et al.  On the properties and stability of thermally evaporated Ge–As–Se thin films , 2009 .

[3]  Anant Agarwal,et al.  Compositional dependence of the nonlinear refractive index of new germanium-based chalcogenide glasses , 2009 .

[4]  Min Gu,et al.  Generation of λ/12 nanowires in chalcogenide glasses. , 2011, Nano letters.

[5]  T Gebel,et al.  Arsenic and antimony: comparative approach on mechanistic toxicology. , 1997, Chemico-biological interactions.

[6]  M. Osman,et al.  Effect of heat treatment on the optical and electrical transport properties of Ge15Sb10Se75 and Ge25Sb10Se65 thin films , 2008 .

[7]  S Spälter,et al.  Large Kerr effect in bulk Se-based chalcogenide glasses. , 2000, Optics letters.

[8]  M D Pelusi,et al.  Long, low loss etched As(2)S(3) chalcogenide waveguides for all-optical signal regeneration. , 2007, Optics express.

[9]  B. Luther-Davies,et al.  Annealing induced phase transformations in amorphous As2S3 films , 2006 .

[10]  C. Madsen,et al.  Optical characterization of a-As2S3 thin films prepared by magnetron sputtering , 2010 .

[11]  M. Mitkova,et al.  In Situ Measurements of X-Ray-Induced Silver Diffusion into a Ge30Se70 Thin Film , 2008 .

[12]  M. Kincl,et al.  Thermally and optically induced irreversible changes in some Ge–As–S amorphous thin films , 2008 .

[13]  Abdolnasser Zakery,et al.  Optical properties and applications of chalcogenide glasses: a review , 2003 .

[14]  M. Vlcek,et al.  On the structural phase transformations in GexSb40−xSe60 glasses , 2001 .

[15]  D. R. Goyal,et al.  Far-infrared absorption in amorphous Sb15GexSe85 - x glasses , 1995 .

[16]  Steve Madden,et al.  Fabrication of low loss Ge33As12Se55 (AMTIR-1) planar waveguides , 2007 .

[17]  Barry Luther-Davies,et al.  Thin film deposition of Ge33As12Se55 by pulsed laser deposition and thermal evaporation: Comparison of properties , 2007 .

[18]  Annie Pradel,et al.  CHALCOGENIDE THIN FILMS DEPOSITED BY RADIO-FREQUENCY SPUTTERING , 2004 .

[19]  T. Wágner,et al.  The comparison of Ag–As33S67 films prepared by thermal evaporation (TE), spin-coating (SC) and a pulsed laser deposition (PLD) , 2007 .

[20]  R. Swanepoel.  Determination of the thickness and optical constants of amorphous silicon , 1983 .

[21]  Angela B. Seddon,et al.  Chalcogenide glasses : a review of their preparation, properties and applications , 1995 .

[22]  R. Golovchak,et al.  Structure of SbxGe40-xSe60 glasses around 2.67 average coordination number , 2012 .

[23]  M. Kaid,et al.  Effect of compositional variations on the optical properties of Sb–Ge–Se thin films , 2008 .

[24]  M. Pederson,et al.  Raman-active modes ofa−GeSe2anda−GeS2:A first-principles study , 1999 .

[25]  Steve Madden,et al.  Properties of GexAsySe1-x-y glasses for all-optical signal processing. , 2008, Optics express.

[26]  Steve Madden,et al.  Thermal annealing of arsenic tri-sulphide thin film and its influence on device performance , 2010 .

[27]  Steve Madden,et al.  Progress in optical waveguides fabricated from chalcogenide glasses. , 2010, Optics express.

[28]  Virginie Nazabal,et al.  Sputtering and Pulsed Laser Deposition for Near‐ and Mid‐Infrared Applications: A Comparative Study of Ge25Sb10S65 and Ge25Sb10Se65 Amorphous Thin Films , 2011 .

[29]  D. Hewak,et al.  Deposition and characterization of germanium sulphide glass planar waveguides. , 2004, Optics express.

[30]  Xiujian Zhao,et al.  Structure and optical properties of amorphous GeSx films prepared by PLD , 2011 .

[31]  P. Němec,et al.  Structure, optical properties and their photo-induced changes in AsxSe100 − x (x = 50, 57.1, 60) amorphous thin films prepared by pulsed laser deposition , 2005 .

[32]  Tae Hyeon Kim,et al.  Phase Transformation through Metastable Structures in Atomically Controlled Se/Sb MultiLayers , 2011 .