Onboard monitoring of fatigue damage rates in the hull girder

Abstract Most new advanced ships have extensive data collection systems to be used for continuous monitoring of engine and hull performance, for voyage performance evaluation etc. Such systems could be expanded to include also procedures for stress monitoring and for decision support, where the most critical wave-induced ship extreme responses and fatigue damage accumulation can be estimated for hypothetical changes in ship course and speed in the automatically estimated wave environment. The aim of this paper is to outline a calculation procedure for fatigue damage rate prediction in hull girders taking into account whipping stresses. It is conceptually shown how such a method, which integrates onboard estimation of sea states, can be used to deduce decision support with respect to the accumulated fatigue damage in the hull girder. The paper firstly presents a set of measured full-scale wave-induced stress ranges in a container ship, where the associated fatigue damage rates calculated from a combination of the rain-flow counting method and the Palmgren-Miner damage rule are compared with damage predictions obtained from a computationally much faster frequency fatigue analysis using a spectral method. This analysis verifies the applied multi-modal spectral analysis procedure for fatigue estimation for cases where hull girder flexibility plays a role. To obtain an automated prediction method for the fatigue damage rates it is in the second part of the paper shown how a combination of the full-scale onboard acceleration and stress measurements can be used to calculate sea state parameters. These calculated environmental data are verified by a comparison to hindcast data. In the third part of the paper the full-scale fatigue stress ranges are compared to results from an analytical design oriented calculation procedure for flexible ship hulls in short-term estimated sea states. Altogether, it is conceptually shown that by a combination of the onboard estimated sea state parameters with the described analytical fatigue damage prediction procedure a method can be established for real-time onboard decision support which includes estimates of fatigue damage rates.

[1]  Ulrik Dam Nielsen.  Introducing two hyperparameters in Bayesian estimation of wave spectra , 2008 .

[2]  Ulrik Dam Nielsen.  The wave buoy analogy — estimating high-frequency wave excitations , 2008 .

[3]  T. Moan,et al.  Structural response of a ship in severe seas considering global hydroelastic vibrations , 2008 .

[4]  Ulrik Dam Nielsen,et al.  FAULT DETECTION FOR SHIPBOARD MONITORING AND DECISION SUPPORT SYSTEMS , 2009 .

[5]  Ulrik Dam Nielsen,et al.  SeaSense - Real-time Onboard Decision Support , 2006 .

[6]  C. Guedes Soares,et al.  Kalman filtering of vessel motions for ocean wave directional spectrum estimation , 2009 .

[7]  Ulrik Dam Nielsen,et al.  Estimations of on-site directional wave spectra from measured ship responses , 2006 .

[8]  Yoshiyuki Nakajima,et al.  Full-Scale Measurements on Hull Response of a Large-Container Ship in Service , 2006 .

[9]  Alaa E. Mansour,et al.  Estimation of Ship Long-term Wave-induced Bending Moment using Closed-Form Expressions , 2002 .

[10]  Igor Rychlik,et al.  NOTE ON CYCLE COUNTS IN IRREGULAR LOADS , 1993 .

[11]  Alexandre N. Simos,et al.  Estimating directional wave spectrum based on stationary ship motion measurements , 2003 .

[12]  Torgeir Moan,et al.  Numerical and experimental investigations into the application of response conditioned waves for long-term nonlinear analyses , 2009 .

[13]  Torgeir Moan,et al.  Probabilistic analysis of fatigue due to Gaussian load processes , 1990 .

[14]  Ulrik Dam Nielsen,et al.  Fault Isolation for Shipboard Decision Support , 2010 .

[15]  C. Guedes Soares,et al.  Non-parametric wave spectral estimation using vessel motions , 2008 .

[16]  Toshio Iseki,et al.  BAYESIAN ESTIMATION OF DIRECTIONAL WAVE SPECTRA BASED ON SHIP MOTIONS (2ND REPORT) , 1994 .

[17]  Toshio Iseki,et al.  Bayesian estimation of directional wave spectra based on ship motions , 1998 .

[18]  Asgeir J. Sørensen,et al.  Ocean Wave Spectral Estimation Using Vessel Wave Frequency Motions , 2007 .

[19]  Torgeir Moan,et al.  The Effect of Bow Shape on the Springing/Whipping Response of a Large Ocean-Going Vessel: Investigated by an Experimental Method , 2007 .

[20]  Alexandre N. Simos,et al.  Directional Wave Spectrum Estimation Based On Vessel¿s 1st-order Motions: Field Results , 2009 .

[21]  Jørgen Juncher Jensen,et al.  Stochastic procedures for extreme wave load predictions – Wave bending moment in ships , 2009 .

[22]  Ulrik Dam Nielsen,et al.  Fault Isolation and Quality Assessment for Shipboard Monitoring , 2010 .

[23]  Tetsuo Okada,et al.  On board measurement of stresses and deflections of a Post-Panamax containership and its feedback to rational design , 2006 .

[24]  Nils Salvesen,et al.  SHIP MOTIONS AND SEA LOADS , 1970 .

[25]  Preben Terndrup Pedersen,et al.  Estimation of hull girder vertical bending moments including non-linear and flexibility effects using closed form expressions , 2009 .

[26]  Alaa E. Mansour,et al.  Estimation of ship motions using closed-form expressions , 2004 .

[27]  Gaute Storhaug,et al.  Experimental investigation of wave induced vibrations and their effect on the fatigue loading of ships , 2007 .

[28]  Jørgen Juncher Jensen.  Load and Global Response of Ships , 2011 .