Experimental apparatus for solar energy storage via methane production

Renewable energy production from intermittent sources has seen a large expansion the last decade and has introduced new challenges in the energy system. Problems are related to the non-programmable electric power generated and the production peaks that especially characterize photovoltaic energy. In addition to these issues, the extensive and long-term task of reducing CO2 emissions should be considered. The utilization of CO2 as a feedstock for producing fuels not only contributes to alleviating global climate changes but also provides a new research field for energy development. An innovative process for solar energy storage via methane production seems to be a viable technology to tackle the above- mentioned issues. In this paper an experimental apparatus, formed by PV panels, a pressurized electrolyser and a Sabatier reactor is presented. The Sabatier reaction exothermically combines hydrogen and carbon dioxide to produce methane and water. The produced methane is a carbon neutral gas that fits in with the existing natural gas and allows to overcame issues related to the intermittence and non-programmability of solar power. The paper focuses on the description of the experimental apparatus and the results of a preliminary investigation. An economic evaluation was also carried out on the integration of methanation process with a traditional PV system.

[1]  J. Ivy,et al.  Summary of Electrolytic Hydrogen Production: Milestone Completion Report , 2004 .

[2]  Yoshiki Yamagata,et al.  Supplementary Methods and Good Practice Guidance Arising from the Kyoto Protocol , 2004 .

[3]  Filip Johnsson,et al.  Fossil Fuels: Climate Change and Security of Supply , 2012 .

[4]  S. Watson,et al.  Comparison of electrical energy efficiency of atmospheric and high-pressure electrolysers , 2006 .

[5]  H. Moayedi,et al.  Electrical Efficiency of Electrolytic Hydrogen Production , 2012, International Journal of Electrochemical Science.

[6]  Per Alvfors,et al.  Biogas from renewable electricity : Increasing a climate neutral fuel supply , 2012 .

[7]  M. Mann,et al.  Life Cycle Assessment of Renewable Hydrogen Production via Wind/Electrolysis , 2004 .

[8]  Beatrice Castellani,et al.  A Cylindrical Molten Carbonate Fuel Cell Supplied with Landfill Biogas , 2013 .

[9]  Prediction of production power for high-pressure hydrogen by high-pressure water electrolysis , 2004 .

[10]  Jacob A. Moulijn,et al.  Mitigation of CO2 by Chemical Conversion: Plausible Chemical Reactions and Promising Products , 1996 .

[11]  Andrea Nicolini,et al.  Evaluation and Optimization of an Innovative Low-Cost Photovoltaic Solar Concentrator , 2011 .

[12]  S. Kent Hoekman,et al.  CO2 recycling by reaction with renewably-generated hydrogen , 2010 .

[13]  Jennifer L. Zilka,et al.  Carbon Dioxide Conversions in Microreactors , 2000 .

[14]  Andrea Nicolini,et al.  Experimental Investigation on a Novel Electrolyte Configuration for Cylindrical Molten Carbonate Fuel Cells , 2011 .

[16]  F. Cotana,et al.  Carbon Dioxide Capture Using Gas Hydrate Technology , 2013 .

[17]  T. Nejat Veziroglu,et al.  Modeling and simulation of the production of hydrogen using hydroelectricity in Venezuela , 2007 .

[18]  L. Pfefferle,et al.  Methanation of carbon dioxide on Ni-incorporated MCM-41 catalysts: The influence of catalyst pretreatment and study of steady-state reaction , 2007 .

[19]  C. A Schug,et al.  Operational characteristics of high-pressure, high-efficiency water-hydrogen-electrolysis , 1998 .

[20]  Robert J. Kee,et al.  Methanation of carbon dioxide by hydrogen reduction using the Sabatier process in microchannel reactors , 2007 .

[21]  F. Barbir.  PEM electrolysis for production of hydrogen from renewable energy sources , 2005 .

[22]  Andrea Nicolini,et al.  A Cylindrical Small Size Molten Carbonate Fuel Cell: Experimental Investigation on Materials and Improving Performance Solutions , 2009 .

[23]  J. Levene,et al.  Electrolysis of Water , 2008 .

[24]  Mikkel Jørgensen,et al.  The teraton challenge. A review of fixation and transformation of carbon dioxide , 2010 .

[25]  C. H. Bartholomew,et al.  Hydrogenation of CO2 on group VIII metals: IV. Specific activities and selectivities of silica-supported Co, Fe, and Ru , 1984 .

[26]  M. Mann,et al.  Life Cycle Assessment of Renewable Hydrogen Production via Wind/Electrolysis: Milestone Completion Report , 2004 .

[27]  R. B. Slimane,et al.  Progress in carbon dioxide separation and capture: a review. , 2008, Journal of environmental sciences.