Effect of upward velocity and sulphide concentration on volatile fatty acid degradation in a sulphidogenic granular sludge reactor

During anaerobic treatment of sulphate-containing wastewaters, sulphate-reducing bacteria (SRB) compete with methane-producing bacteria (MPB) for the available electron-donors. In this work, the anaerobic treatment of a synthetic wastewater, consisting of a mixture of acetate, propionate and butyrate and high concentrations of sulphate (COD: sulphate ratio 0·5) was studied in an upflow anaerobic granular sludge bed reactor. The influence of the superficial upward liquid velocity (vup), the influent composition and reactor pH on the competition between SRB and MPB was investigated. At a vup of 2 m h−1 and pH 8, 93–97% of the COD was degraded by SRB. With increasing vup-values, COD removal efficiencies decreased, while at a vup of 6 m h−1 the fraction of COD removed by MPB rose to 23%. Elevation of the influent acetate concentrations, by decreasing the vup (lower recirculation) or by the use of an influent volatile fatty acid mixture with a higher acetate content, resulted in an increase of methanogenesis up to 41% of the total COD removal. In contrast, elevated levels of propionate and butyrate in the influent favoured the sulphate reducing process. A decrease of pH from 8 to 7 resulted in free hydrogen sulphide concentrations higher than 200 mg litre−1. This strongly inhibited methanogenesis while SRB were hardly affected, with a subsequent decrease of the COD removed by MPB from 41 to 7% as a result.

[1]  M. Bruschi,et al.  Microbiology and Biochemistry of Strict Anaerobes Involved in Interspecies Hydrogen Transfer , 1990, Federation of European Microbiological Societies Symposium Series.

[2]  A. Mulder.  The effects of high sulphate concentrations on the methane fermentation of wastewater , 1984 .

[3]  G Lettinga,et al.  Biological sulphate reduction using gas‐lift reactors fed with hydrogen and carbon dioxide as energy and carbon source , 1994, Biotechnology and bioengineering.

[4]  Derek R. Lovley,et al.  Kinetic Analysis of Competition Between Sulfate Reducers and Methanogens for Hydrogen in Sediments , 1982, Applied and environmental microbiology.

[5]  A. Rinzema,et al.  Sulfide inhibition of the methanogenic activity of granular sludge at various pH-levels , 1986 .

[6]  G Lettinga,et al.  Development of thermophilic methanogenic sludge in compartmentalized upflow reactors , 1996, Biotechnology and bioengineering.

[7]  David C. Stuckey,et al.  Hydrodynamic characteristics of the anaerobic baffled reactor , 1992 .

[8]  R. Speece,et al.  Attached versus Suspended Growth Anaerobic Reactors: Response to Toxic Substances , 1983 .

[9]  Alfons J. M. Stams,et al.  Sulfate reduction in methanogenic bioreactors , 1994 .

[10]  G. Lettinga,et al.  Effects of pH on methanogenesis and sulphate reduction in thermophilic (55°C) UASB reactors , 1993 .

[11]  Willy Verstraete,et al.  Sulfate Reduction Relative to Methane Production in High-Rate Anaerobic Digestion: Microbiological Aspects , 1986, Applied and environmental microbiology.

[12]  K. Hanselmann,et al.  Biological sulfuric acid transformation: Reactor design and process optimization , 1993, Biotechnology and bioengineering.

[13]  Gatze Lettinga,et al.  The effect of liquid upward velocity and hydraulic retention time on granulation in UASB reactors treating wastewater with a high sulphate content , 1993 .

[14]  J. Lema,et al.  A pulsing device for packed-bed bioreactors: I. Hydrodynamic behaviour , 1994 .

[15]  O. Levenspiel.  Chemical Reaction Engineering , 1972 .

[16]  Gatze Lettinga,et al.  Biotechnological sulphide removal from effluents. , 1991 .

[17]  G Lettinga,et al.  Feasibility of expanded granular sludge bed reactors for the anaerobic treatment of low‐strength soluble wastewaters , 1994, Biotechnology and bioengineering.

[18]  B. Ahring,et al.  Methanogenesis from Propionate in Sludge and Enrichment Systems , 1990 .

[19]  W. Gujer,et al.  Conversion processes in anaerobic digestion , 1983 .

[20]  H. J. G. ten Hoopen,et al.  Anaerobic treatment of 'acid water' (methane production in a sulfate-rich environment) , 1984 .

[21]  Y. Li,et al.  PERFORMANCE AND SLUDGE CHARACTERISTICS OF UASB PROCESS TREATING PROPIONATE-RICH WASTEWATER , 1995 .

[22]  A. W. Lawrence,et al.  Kinetics of microbial sulfate reduction , 1977 .

[23]  Gatze Lettinga,et al.  High rate thermophilic anaerobic wastewater treatment in compartmentalized upflow reactors , 1994 .