Comparison of PD and Breakdown Characteristics Induced by Metal Particles and Bubbles in Flowing Transformer Oil

Metal particles and bubbles are two typical impurities in transformer oil that can cause partial discharge (PD) and even electric breakdown. The PD characteristics are closely related to the motions of these impurities in flowing transformer oil. In this paper, the motions of impurities were obtained by a camera and a simulation model at first. Then, we employed three methods, namely, antennas, a non-inductive resistor, and the method recommended by IEC 60270, to measure the PD signals simultaneously. The breakdown experiments of transformer oil containing the metal particles and bubbles were also performed. In terms of these, single PD waveforms, statistical characteristics, and breakdown voltage were obtained. The results showed that the metal particles could excite ultrahigh frequency (300 MHz–3 GHz) PD signals, whereas bubbles only excited signals in the very high-frequency band (30–300 MHz). Moreover, the PDs induced by the metal particles had a higher repetition rate and a smaller amplitude than the PDs induced by bubbles. In addition, the metal particles easily caused PD, whereas bubbles easily led to the breakdown. Possible reasons for different discharge characteristics between the two impurities were discussed on the basis of the motions of impurities and the distortions of electric field.

[1]  Energy Estimation of Partial Discharge Pulse Signals Based on Noise Parameters , 2016, IEEE Access.

[2]  Ute Ebert,et al.  Positive and negative streamers in ambient air: measuring diameter, velocity and dissipated energy , 2008, 0805.1376.

[3]  R. Sarathi,et al.  Investigation of partial discharge activity of conducting particles in liquid nitrogen under DC voltages using uhf technique , 2008, IEEE Transactions on Dielectrics and Electrical Insulation.

[4]  V. Armenio,et al.  The importance of the forces acting on particles in turbulent flows , 2001 .

[5]  M. Darveniza,et al.  Microdischarges from Particles in Transformer Oil , 1976, IEEE Transactions on Electrical Insulation.

[6]  Z. Liu,et al.  Effect of electric field configuration on streamer and partial discharge phenomena in a hydrocarbon insulating liquid under AC stress , 2016 .

[7]  Masahiro Kozako,et al.  Modeling of early stage partial discharge and overheating degradation of paper-oil insulation , 2014, IEEE Transactions on Dielectrics and Electrical Insulation.

[8]  Ju Tang,et al.  Impact of velocity on partial discharge characteristics of moving metal particles in transformer oil using UHF technique , 2016, IEEE Transactions on Dielectrics and Electrical Insulation.

[9]  X. Wang,et al.  Motion of conductive particles and the effect on AC breakdown strengths of esters , 2011, 2011 IEEE International Conference on Dielectric Liquids.

[10]  H. Yamashita,et al.  Prebreakdown density change, current and light emission in transformer oil under non-uniform field , 1982 .

[11]  H. Muto,et al.  Diagnosis for oil-immersed insulation using partial discharge due to bubbles in oil , 2003, Proceedings of the 7th International Conference on Properties and Applications of Dielectric Materials (Cat. No.03CH37417).

[13]  Massimo Pompili,et al.  Partial discharge distributions in liquid dielectrics , 1992 .

[14]  N. Bonifaci,et al.  Thermally and electrically induced bubbles in liquid argon and nitrogen , 2002 .

[15]  A. Komiya,et al.  Initiation process and propagation mechanism of positive streamer discharge in water , 2014 .

[16]  Lucian Dascalescu,et al.  Modeling of Conductive Particle Behavior in Insulating Fluids Affected by , 1998 .

[17]  Gehao Sheng,et al.  Partial Discharge Detection and Recognition in Random Matrix Theory Paradigm , 2017, IEEE Access.

[18]  Hitoshi Okubo,et al.  The relationship between partial discharge current pulse waveforms and physical mechanisms , 2002 .

[19]  Xiu Yao,et al.  Partial-Discharge Characteristics of Free Spherical Conducting Particles Under AC Condition in Transformer Oils , 2011, IEEE Transactions on Power Delivery.

[20]  E. Husain,et al.  Analysis of Paschen Curves for air, N2 and SF6 Using the Townsend Breakdown Equation , 1982, IEEE Transactions on Electrical Insulation.

[21]  M.D. Judd,et al.  Partial discharge monitoring of power transformers using UHF sensors. Part I: sensors and signal interpretation , 2005, IEEE Electrical Insulation Magazine.

[22]  S. Jayaram.  Effects of thermal and viscous drag forces on AC breakdown characteristics of transformer oil , 1993, Proceedings of IEEE Conference on Electrical Insulation and Dielectric Phenomena - (CEIDP '93).

[23]  Z.D. Wang,et al.  Particle Effect on Breakdown Voltage of Mineral and Ester Based Transformer Oils , 2008, 2008 Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[24]  S. Birlasekaran.  The measurement of charge on single particles in transformer oil , 1991 .

[25]  A. Pedersen,et al.  The theory and measurement of partial discharge transients , 1991 .

[26]  Martin D. Judd,et al.  Partial discharge study in transformer oil due to particle movement under DC voltage using the UHF technique , 2008 .

[27]  G. Chen,et al.  Partial discharge characterization of streamers in liquid nitrogen under applied AC voltages , 2008, IEEE Transactions on Dielectrics and Electrical Insulation.

[28]  Mehdi Bagheri,et al.  Transformer Fault Condition Prognosis Using Vibration Signals Over Cloud Environment , 2018, IEEE Access.

[29]  Shuaibing Li,et al.  Influences of oil flow speed and temperature on partial discharge properties in transformer oil , 2016, 2016 Australasian Universities Power Engineering Conference (AUPEC).

[30]  M. M. Góngora-Nieto,et al.  Impact of air bubbles in a dielectric liquid when subjected to high field strengths , 2003 .

[31]  William R. Bell,et al.  Factors affecting the breakdown strength of transformer oil , 1982, 1982 IEEE International Conference on Electrical Insulation.

[32]  Ju Tang,et al.  Impact of oil velocity on partial discharge characteristics induced by bubbles in transformer oil , 2018, IEEE Transactions on Dielectrics and Electrical Insulation.

[33]  Cheng Pan,et al.  Variation of Discharge Characteristics With Temperature in Moving Transformer Oil Contaminated by Metallic Particles , 2018, IEEE Access.