Nanophotonic waveguides in silicon-on-insulator fabricated with CMOS technology

High-index-contrast, wavelength-scale structures are key to ultracompact integration of photonic integrated circuits. The fabrication of these nanophotonic structures in silicon-on-insulator using complementary metal-oxide-semiconductor processing techniques, including deep ultraviolet lithography, was studied. It is concluded that this technology is capable of commercially manufacturing nanophotonic integrated circuits. The possibilities of photonic wires and photonic-crystal waveguides for photonic integration are compared. It is shown that, with similar fabrication techniques, photonic wires perform at least an order of magnitude better than photonic-crystal waveguides with respect to propagation losses. Measurements indicate propagation losses as low as 0.24 dB/mm for photonic wires but 7.5 dB/mm for photonic-crystal waveguides.

[1]  E. Yablonovitch,et al.  Inhibited spontaneous emission in solid-state physics and electronics. , 1987, Physical review letters.

[2]  M. C. Hutley,et al.  The Fabry Perot interferometer: by J.M. Vaughan , 1990 .

[3]  Steven G. Johnson,et al.  Photonic Crystals: Molding the Flow of Light , 1995 .

[4]  E. R. Thoen,et al.  Ultra-compact Si-SiO2 microring resonator optical channel dropping filters , 1998, IEEE Photonics Technology Letters.

[5]  Thomas F. Krauss,et al.  Optical and confinement properties of two-dimensional photonic crystals , 1999 .

[6]  R. M. Stevenson,et al.  Heavy photon dispersions in photonic crystal waveguides , 2000 .

[7]  Wim Bogaerts,et al.  Out-of-plane scattering in photonic crystal slabs , 2000 .

[8]  T. Krauss,et al.  An out-of-plane grating coupler for efficient butt-coupling between compact planar waveguides and single-mode fibers , 2002 .

[9]  Wim Bogaerts,et al.  Out-of-plane scattering in 1-D photonic crystal slabs , 2001, IEEE Photonics Technology Letters.

[10]  L C Kimerling,et al.  Fabrication of ultralow-loss Si/SiO(2) waveguides by roughness reduction. , 2001, Optics letters.

[11]  Harry J. Levinson,et al.  Principles of Lithography , 2001 .

[12]  R. Baets,et al.  Fabrication of photonic crystals in silicon-on-insulator using 248-nm deep UV lithography , 2002 .

[13]  R.M. Osgood,et al.  Ultracompact corner-mirrors and T-branches in silicon-on-insulator , 2002, IEEE Photonics Technology Letters.

[14]  M. Notomi,et al.  Structural tuning of guiding modes of line-defect waveguides of silicon-on-insulator photonic crystal slabs , 2002 .

[15]  Lars Hagedorn Frandsen,et al.  Low-loss silicon-on-insulator photonic crystal waveguides , 2002 .

[16]  Wim Bogaerts,et al.  Scattering at sidewall roughness in photonic crystal slabs. , 2003, Optics letters.

[17]  Franck Robin,et al.  An efficient proximity-effect correction method for electron-beam patterning of photonic-crystal devices , 2003 .

[18]  Y. Vlasov,et al.  Ultra-low loss photonic integrated circuit with membrane-type photonic crystal waveguides. , 2003, Optics express.

[19]  M. Notomi,et al.  Waveguides, resonators and their coupled elements in photonic crystal slabs. , 2004, Optics express.

[20]  Yoshimasa Sugimoto,et al.  Low propagation loss of 0.76 dB/mm in GaAs-based single-line-defect two-dimensional photonic crystal slab waveguides up to 1 cm in length. , 2004, Optics express.

[21]  P. Dumon,et al.  Basic structures for photonic integrated circuits in Silicon-on-insulator. , 2004, Optics express.

[22]  Joseph W. Haus,et al.  Photonic Band Gap Structures , 2004 .

[23]  D. Van Thourhout,et al.  Low-loss SOI photonic wires and ring resonators fabricated with deep UV lithography , 2004, IEEE Photonics Technology Letters.