Catalytic activation of CO2: Use of secondary CO2 for the production of synthesis gas and for methanol synthesis over copper-based zirconia-containing catalysts

Consumption of fossil fuel resources throughout the industrial era has resulted in an enormous increase in carbon dioxide concentration in the atmosphere. Developed countries have committed to reducing the atmospheric load of greenhouse gases and ratified the Kyoto Protocol. Chemical utilization of carbon dioxide captured from large scale stationary sources is one possible pathway to decrease the rate of emissions. Catalysis plays a crucial role in these carbon dioxide utilization reactions. In this paper, the production of synthesis gas from carbon dioxide-containing secondary gases and carbon dioxide hydrogenation to methanol over copper-based zirconia-containing catalysts have been investigated. Pathways of carbon dioxide utilization are outlined, research done on carbon dioxide hydrogenation over copper-based zirconia-containing catalysts is reviewed, and the challenges of these reactions are reported. It is argued that direct utilization of secondary carbon dioxide from industrial sources can be a significant step toward developing sustainable industrial practices and a critical part in sustainable energy strategies.

[1]  A. Kozłowska,et al.  Effect of Mg and Mn oxide additions on structural and adsorptive properties of Cu/ZnO/ZrO2 catalysts for the methanol synthesis from CO2 , 2003 .

[2]  A. Bell,et al.  Effects of Zirconia Phase on the Synthesis of Methanol over Zirconia-Supported Copper , 2002 .

[3]  G. Ertl,et al.  Handbook of Heterogeneous Catalysis , 1997 .

[4]  John J. McKetta,et al.  Encyclopedia of Chemical Processing and Design , 1976 .

[5]  Aldo Steinfeld,et al.  Thermoneutral tri-reforming of flue gases from coal- and gas-fired power stations , 2006 .

[6]  Riitta L. Keiski,et al.  The effect of ageing time on co-precipitated Cu/ZnO/ZrO2 catalysts used in methanol synthesis from CO2 and H2 , 2007 .

[7]  R. L. Sawhney,et al.  Comparison of environmental and economic aspects of various hydrogen production methods , 2008 .

[8]  Malcolm L. H. Green,et al.  Partial oxidation of methane to synthesis gas using carbon dioxide , 1991, Nature.

[9]  E. Ruckenstein,et al.  Carbon dioxide reforming of methane over nickel alkaline earth metal oxide catalysts , 1995 .

[10]  Wim Turkenburg,et al.  A comparison of electricity and hydrogen production systems with CO2 capture and storage. Part A: Review and selection of promising conversion and capture technologies , 2006 .

[11]  Qi Sun,et al.  A practical approach for the preparation of high activity Cu/ZnO/ZrO2 catalyst for methanol synthesis from CO2 hydrogenation , 1998 .

[12]  E. Ruckenstein,et al.  Carbon dioxide reforming of methane to synthesis gas over supported cobalt catalysts , 2000 .

[13]  C. Au,et al.  Carbon dioxide reforming of methane to syngas over SiO2-supported rhodium catalysts , 1997 .

[14]  J. N. Armor,et al.  Catalysis and the hydrogen economy , 2005 .

[15]  D. Resasco,et al.  Effect of promoters on supported Pt catalysts for CO2 reforming of CH4 , 1998 .

[16]  C. Mirodatos,et al.  Methane reforming reaction with carbon dioxide over Ni/SiO2 Catalyst. I. Deactivation studies , 1996 .

[17]  W. Hally,et al.  The role of the oxidic support on the deactivation of Pt catalysts during the CO2 reforming of methane , 1996 .

[18]  Yu Liang,et al.  Surface active structure of ultra-fine Cu/ZrO2 catalysts used for the CO2+H2 to methanol reaction , 2001 .

[19]  Ratna Choudhury,et al.  Beneficiation of Indian coal by chemical techniques , 1997 .

[20]  W. Sachtler,et al.  Potential of zeolite supported rhodium catalysts for the CO2 reforming of CH4 , 1997 .

[21]  Jens R. Rostrup-Nielsen,et al.  CO2-Reforming of Methane over Transition Metals , 1993 .

[22]  F. Solymosi,et al.  Activation of CH4 and Its Reaction with CO2 over Supported Rh Catalysts , 1993 .

[23]  T. Inui,et al.  Structure and function of Cu-based composite catalysts for highly effective synthesis of methanol by hydrogenation of CO2 and CO , 1997 .

[24]  David L. Trimm,et al.  The Formation and Removal of Coke from Nickel Catalyst , 1977 .

[25]  A. Gadalla,et al.  The role of catalyst support on the activity of nickel for reforming methane with CO2 , 1988 .

[26]  M. Bradford,et al.  The role of metal–support interactions in CO2 reforming of CH4 , 1999 .

[27]  A. Bell,et al.  In SituInfrared Study of Methanol Synthesis from CO2/H2on Titania and Zirconia Promoted Cu/SiO2 , 1999 .

[28]  Yuhan Sun,et al.  Methanol synthesis from CO2-rich syngas over a ZrO2 doped CuZnO catalyst , 2006 .

[29]  J. Bitter,et al.  Deactivation and Coke Accumulation during CO2/CH4 Reforming over Pt Catalysts , 1999 .

[30]  E. Ruckenstein,et al.  An optimum NiO content in the CO2 reforming of CH4 with NiO/MgO solid solution catalysts , 1996 .

[31]  V. Choudhary,et al.  CO2 reforming of methane to syngas over highly active and stable supported CoOx (accompanied with MgO, ZrO2 or CeO2) catalysts , 2007 .

[32]  Yun Hang Hu,et al.  Role of support in CO2 reforming of CH4 to syngas over Ni catalysts , 1996 .

[33]  Aldo Steinfeld,et al.  Fuel saving, carbon dioxide emission avoidance, and syngas production by tri-reforming of flue gases from coal- and gas-fired power stations, and by the carbothermic reduction of iron oxide , 2006 .

[34]  M. Bradford,et al.  Catalytic reforming of methane with carbon dioxide over nickel catalysts II. Reaction kinetics , 1996 .

[35]  W. Maier,et al.  CO2-Reforming of Methane on Supported Rh and Ir Catalysts , 1996 .

[36]  Chunshan Song,et al.  Tri-reforming of methane: a novel concept for catalytic production of industrially useful synthesis gas with desired H2/CO ratios , 2004 .

[37]  J. E. Lyons,et al.  Catalysis research of relevance to carbon management: progress, challenges, and opportunities. , 2001, Chemical reviews.

[38]  J. Richardson,et al.  Carbon dioxide reforming of methane with supported rhodium , 1990 .

[39]  V. Ostrovskii.  Mechanisms of methanol synthesis from hydrogen and carbon oxides at Cu–Zn-containing catalysts in the context of some fundamental problems of heterogeneous catalysis , 2002 .

[40]  Daniel E. Resasco,et al.  Effect of Promotion with Sn on Supported Pt Catalysts for CO2Reforming of CH4 , 1998 .

[41]  Masami Takeuchi,et al.  The stability of Cu/ZnO-based catalysts in methanol synthesis from a CO2-rich feed and from a CO-rich feed , 2001 .

[42]  Jens R. Rostrup-Nielsen,et al.  Technologies for large-scale gas conversion , 2001 .

[43]  Xiaoming Zheng,et al.  Methanol synthesis from CO2 hydrogenation over Cu based catalyst supported on zirconia modified γ-Al2O3 , 2006 .

[44]  Jacob A. Moulijn,et al.  Mitigation of CO2 by Chemical Conversion: Plausible Chemical Reactions and Promising Products , 1996 .

[45]  Gao Qing Lu,et al.  A Comprehensive Study on Carbon Dioxide Reforming of Methane over Ni/γ-Al2O3 Catalysts , 1999 .

[46]  Sitaram Ramaswamy,et al.  Catalytic burner for an indirect methanol fuel cell vehicle fuel processor , 2003 .

[47]  K. Tomishige,et al.  Studies on Carbon Deposition in CO2Reforming of CH4over Nickel–Magnesia Solid Solution Catalysts , 1999 .

[48]  S. C. Dhingra,et al.  K-, CeO2-, and Mn-promoted Ni/Al2O3 catalysts for stable CO2 reforming of methane , 2005 .

[49]  Sunggyu Lee,et al.  Methanol Synthesis Technology , 1989 .

[50]  Gao Qing Lu,et al.  CO2 reforming of methane on Ni catalysts: Effects of the support phase and preparation technique , 1998 .

[51]  M. Saito,et al.  Development of copper/zinc oxide-based multicomponent catalysts for methanol synthesis from carbon dioxide and hydrogen , 1996 .

[52]  Cd Keeling,et al.  Atmospheric carbon dioxide record from Mauna Loa , 2005 .

[53]  David A. J. Rand,et al.  Fuel cells for road transportation purposes — yes or no? , 2001 .