A Fast Rolling Soft Robot Driven by Dielectric Elastomer

This paper presents a fast rolling soft robot (RSR) driven by dielectric elastomer. Through novel structure design based on multisegment dielectric elastomer minimum energy structure, the robot appears to be a fully flexible circular configuration with excellent ability of active deformation for its body controlled by applied voltages. An equivalent pseudo-rigid-body model is developed to provide an effective analysis for the deformation and rolling mechanism. The detailed fabrication process is described, and then a robot prototype is fabricated. The resulting RSR weighs 0.88 g with a diameter of 49.66 mm, which exhibits uniquely advantageous properties including low mass, mechanical flexibility and resilience, silent operation, and fast response. Controlled by three sequential open-loop control signals generated by a developed multiplex high-voltage control system, the robot prototype can realize continuous and steady rolling locomotion on flat ground. The response time of active deformation and restoration of the robot is less than 50 ms, the speed-mass ratio is about 41.22 mm/(s·g) and the maximum speed-diameter ratio reaches approximately 0.95 s−1. Compared with the previous similar rolling soft robots, our robot demonstrates higher rolling speed and larger speed-mass ratio, which can find potential future use in scouting and exploration missions.

[1]  Mark Yim,et al.  Dynamic Rolling for a Modular Loop Robot , 2006, ISER.

[2]  Matthew D. Lichter,et al.  On the design of large degree-of-freedom digital mechatronic devices based on bistable dielectric elastomer actuators , 2006, IEEE/ASME Transactions on Mechatronics.

[3]  Tingyu Cheng,et al.  Fast-moving soft electronic fish , 2017, Science Advances.

[4]  G. Vassura,et al.  Optimal Synthesis of Conically Shaped Dielectric Elastomer Linear Actuators: Design Methodology and Experimental Validation , 2011, IEEE/ASME Transactions on Mechatronics.

[5]  Yanju Liu,et al.  Electromechanical instability and snap-through instability of dielectric elastomers undergoing polarization saturation , 2012 .

[6]  Ronald S. Fearing,et al.  Robotic vertical jumping agility via series-elastic power modulation , 2016, Science Robotics.

[7]  A. Gent.  A New Constitutive Relation for Rubber , 1996 .

[8]  Rocco Vertechy,et al.  Dynamic modeling and experimental evaluation of a constant-force dielectric elastomer actuator , 2013 .

[9]  Lanny S. Smoot,et al.  Self locomotion of a spherical rolling robot using a novel deformable pneumatic method , 2010, 2010 IEEE International Conference on Robotics and Automation.

[10]  Samuel Rosset,et al.  Tunable Optics: Ultrafast All‐Polymer Electrically Tunable Silicone Lenses (Adv. Funct. Mater. 11/2015) , 2015 .

[11]  H. Shea,et al.  Multifunctional shape memory electrodes for dielectric elastomer actuators enabling high holding force and low-voltage multisegment addressing , 2017 .

[12]  Yanju Liu,et al.  Stability of dielectric elastomer/carbon nanotube composites coupling electrostriction and polarization , 2015 .

[13]  Xin Chen,et al.  Soft Mobile Robots with On-Board Chemical Pressure Generation , 2011, ISRR.

[14]  J. Leng,et al.  Bistable dielectric elastomer minimum energy structures , 2016 .

[15]  F. Carpi,et al.  Electroactive polymer actuators as artificial muscles: are they ready for bioinspired applications? , 2011, Bioinspiration & biomimetics.

[16]  D. Rus,et al.  Design, fabrication and control of soft robots , 2015, Nature.

[17]  Todd A. Gisby,et al.  Self sensing feedback for dielectric elastomer actuators , 2013 .

[18]  Chen Li,et al.  A Terradynamics of Legged Locomotion on Granular Media , 2013, Science.

[19]  Q. Pei,et al.  Improvement on output torque of dielectric elastomer minimum energy structures , 2015 .

[20]  Qibing Pei,et al.  Phenomena of nonlinear oscillation and special resonance of a dielectric elastomer minimum energy structure rotary joint , 2015 .

[21]  Jinsong Leng,et al.  Dielectric elastomer film actuators: characterization, experiment and analysis , 2009 .

[22]  ZhuJian,et al.  Interactions Between Dielectric Elastomer Actuators and Soft Bodies , 2016 .

[23]  S. Bauer,et al.  Energy minimization for self-organized structure formation and actuation , 2007 .

[24]  Zhigang Suo,et al.  Nonlinear deformation analysis of a dielectric elastomer membrane–spring system , 2010 .

[25]  Shinichi Hirai,et al.  Crawling and Jumping by a Deformable Robot , 2006, Int. J. Robotics Res..

[26]  Rhodri H. Armour,et al.  Rolling in nature and robotics: A review , 2006 .

[27]  Jian Zhu,et al.  Dynamic electromechanical instability of a dielectric elastomer balloon , 2015 .

[28]  Helmut F. Schlaak,et al.  Dynamic performance of silicone dielectric elastomer actuators with bi-stable buckled beams , 2014, Smart Structures.

[29]  Amir Firouzeh,et al.  An IPMC-made deformable-ring-like robot , 2012 .

[30]  Jinsong Leng,et al.  Comment on “Method to analyze electromechanical stability of dielectric elastomers”[Appl. Phys. Lett. 91, 061921 (2007)] , 2008 .

[31]  Yinlong Zhu,et al.  Analysis and application of a rolled dielectric elastomer actuator with two degrees of freedom , 2016 .

[32]  Yanju Liu,et al.  Electromechanical stability of dielectric elastomer , 2009 .

[33]  C. Keplinger,et al.  Giant voltage-induced deformation in dielectric elastomers near the verge of snap-through instability , 2013 .

[34]  Guang Meng,et al.  Asymmetry bistability for a coupled dielectric elastomer minimum energy structure , 2016 .

[35]  MajidiCarmel,et al.  Soft Robotics: A Perspective—Current Trends and Prospects for the Future , 2014 .

[36]  Matteo Cianchetti,et al.  Soft robotics: Technologies and systems pushing the boundaries of robot abilities , 2016, Science Robotics.

[37]  Huai-Ti Lin,et al.  GoQBot: a caterpillar-inspired soft-bodied rolling robot , 2011, Bioinspiration & biomimetics.

[38]  Q. Pei,et al.  High-speed electrically actuated elastomers with strain greater than 100% , 2000, Science.

[39]  Carlo Menon,et al.  Electroactive Elastomeric Actuators for the Implementation of a Deformable Spherical Rover , 2011, IEEE/ASME Transactions on Mechatronics.

[40]  Liwu Liu,et al.  Equivalent dynamic model of DEMES rotary joint , 2016 .

[41]  Shinichi Hirai,et al.  Rolling tensegrity driven by pneumatic soft actuators , 2012, 2012 IEEE International Conference on Robotics and Automation.

[42]  Dario Floreano,et al.  A Foldable Antagonistic Actuator , 2015, IEEE/ASME Transactions on Mechatronics.

[43]  Yanju Liu,et al.  Dielectric elastomer energy harvesting: maximal converted energy, viscoelastic dissipation and a wave power generator , 2015 .

[44]  Hitoshi Kimura,et al.  Flexible Hermetically-Sealed Mobile Robot for Narrow Spaces Using Hydrostatic Skeleton Driving Mechanism , 2006, 2006 IEEE/RSJ International Conference on Intelligent Robots and Systems.

[45]  I. Gavrilovich,et al.  Rollable Multisegment Dielectric Elastomer Minimum Energy Structures for a Deployable Microsatellite Gripper , 2015, IEEE/ASME Transactions on Mechatronics.

[46]  Jinsong Leng,et al.  Thermoelectromechanical stability of dielectric elastomers undergoing temperature variation , 2014 .

[47]  Z. Suo.  Theory of dielectric elastomers , 2010 .

[48]  Samuel Rosset,et al.  Model and design of dielectric elastomer minimum energy structures , 2014 .