Defect dominated charge transport in amorphous Ta2O5 thin films

Ta2O5 is a candidate for use in metal–oxide–metal (MOM) capacitors in several areas of silicon device technology. Understanding and controlling leakage current is critical for successful implementation of this material. We have studied thermal and photoconductive charge transport processes in Ta2O5 MOM capacitors fabricated by anodization, reactive sputtering, and chemical vapor deposition. We find that the results from each of these three methods are similar if one compares films that have the same thickness and electrodes. Two types of leakage current are identified: (a) a transient current that charges the bulk states of the films and (b) a steady state activated process involving electron transport via a defect band. The transient process involves either tunneling conductivity into states near the Fermi energy or ion motion. The steady state process, seen most commonly in films <300 A thick, is dominated by a large number of defects, ∼1019–1020 cm−3, located near the metal–oxide interfaces. The interi...

[1]  D. Vermilyea.  Annealing Anodic Ta2 O 5 Films Changes in Dissolution Behavior and X‐Ray Scattering , 1957 .

[2]  D. Vermilyea.  Ionic Conductivity of Anodic Films at High Field Strengths: Transient Behavior , 1957 .

[3]  F. Brown,et al.  The Migration of Metal and Oxygen during Anodic Film Formation , 1965 .

[4]  A. S. Grove,et al.  Ion Transport Phenomena in Insulating Films , 1965 .

[5]  T. W. Hickmott.  Electroluminescence and Photoresponse of Ta2 O 5 and TiO2 Diodes , 1966 .

[6]  S. M. Sze,et al.  Physics of semiconductor devices , 1969 .

[7]  M. Hartl.  Photoelectric detection of changes in thin insulating films caused by the evaporation of a metal electrode , 1969 .

[8]  T. Lewis,et al.  Steady and transient conduction processes in anodic tantalum oxide , 1973 .

[9]  J. H. Thomas.  Defect photoconductivity of anodic Ta2 O5 films , 1973 .

[10]  J. H. Thomas.  Photoconductivity in anodic Ta2O5 formed on nitrogen‐doped tantalum films , 1974 .

[11]  J. H. Thomas.  uv‐stimulated photocurrent spectroscopy and trapping kinetics of a 2.1‐eV trap in anodic Ta2O5 films , 1974 .

[12]  Nevill Mott,et al.  Metal-insulator transitions , 1974 .

[13]  W. Westwood,et al.  Tantalum thin films , 1975 .

[14]  Y. Shibata,et al.  Asymmetric two-site hopping model for high-electric-field-excited thermally stimulated current in evaporated silicon oxide films , 1975 .

[15]  Optical properties of tantalum oxide films on silicon , 1976 .

[16]  D. Lang,et al.  Nonradiative capture and recombination by multiphonon emission in GaAs and GaP , 1977 .

[17]  M. Capizzi,et al.  Optical measurements of the approach to the anderson transition , 1980 .

[18]  M. Jourdain,et al.  Low frequency dispersion in evaporated silicon oxide films , 1980 .

[19]  S. Makram-Ebeid,et al.  Quantum model for phonon-assisted tunnel ionization of deep levels in a semiconductor , 1982 .

[20]  Anthony R. West,et al.  Solid State Chemistry and its Applications , 1984 .

[21]  S. Pantelides.  Deep Centers in Semiconductors , 1986 .

[22]  H. Kliem.  Dielectric small-signal response by protons in amorphous insulators , 1989 .

[23]  Nevill Mott,et al.  Metal-insulator transitions , 1973 .

[24]  Shigeo Fujita,et al.  Structural and Electrical Properties of Ta2O5 Grown by the Plasma-Enhanced Liquid Source CVD Using Penta Ethoxy Tantalum Source , 1993 .

[25]  V. Kopach,et al.  Comparison of the degradation modes in sandwich structures including amorphous oxides of niobium and tantalum , 1993 .

[26]  M. Duggan,et al.  Ionic conductivity of tantalum oxide by rf sputtering , 1993 .

[27]  Reversible Photo-Induced Currents in Epitaxial Pb(Zr 0.52 Ti 0.48 )O 3 Thin Films , 1993 .

[28]  Ultrasmall polarons in amorphous tantalum oxide , 1993 .

[29]  Y. Fukuda,et al.  Current-Voltage Characteristics of Electron-Cyclotron-Resonance Sputter-Deposited SrTiO3 Thin Films , 1994 .

[30]  T. Mihara,et al.  Characteristic Change Due to Polarization Fatigue of Sol-Gel Ferroelectric Pb(Zr0.4Ti0.6)O3 Thin-Film Capacitors , 1994 .

[31]  R. Waser,et al.  Dielectric relaxation of perovskite—type oxide thin films , 1995 .

[32]  A. Yuuki,et al.  Surface Morphologies and Electrical Properties of (Ba, Sr)TiO3 Films Prepared by Two-Step Deposition of Liquid Source Chemical Vapor Deposition , 1995 .

[33]  T. Horikawa,et al.  Dielectric Relaxation of (Ba, Sr)TiO3 Thin Films , 1995 .

[34]  R. Waser,et al.  Science and technology of electroceramic thin films , 1995 .

[35]  E. Weber,et al.  Transient ion drift detection of low level copper contamination in silicon , 1997 .

[36]  R. Waser,et al.  Curie - Von Schweidler behaviour observed in ferroelectric thin films and comparison to superparaelectric thin film materials , 1998 .

[37]  Effect of dissolved oxygen on thermal oxidation in Ta2O5/Ta sandwiches , 1998 .

[38]  J. Autran,et al.  Tantalum pentoxide (Ta2O5) thin films for advanced dielectric applications , 1998 .

[39]  M. Brazier,et al.  Ferroelectric fatigue of Pb(Zr,Ti)O3 thin films measured in atmospheres of varying oxygen concentration , 1999 .

[40]  K. Kawakami,et al.  Electronic structure of oxygen vacancy in Ta2O5 , 1999 .

[41]  D. Jeon,et al.  Effect of annealing conditions on the leakage current characteristics of ferroelectric PZT thin films grown by sol–gel process , 1999 .

[42]  Jane P. Chang,et al.  Thermal stability of Ta2O5 in metal–oxide–metal capacitor structures , 1999 .