论文信息 - ANALYSIS OF CONVECTIVE HEAT TRANSFER DURING IMMERSION FRYING

ANALYSIS OF CONVECTIVE HEAT TRANSFER DURING IMMERSION FRYING

ABSTRACT Immersion frying was studied as a high temperature drying process and analogies drawn between periods found in drying and similar periods in immersion frying. Analysis of external heat transfer during immersion frying showed a highly complex system of free and forced convection augmented by boiling conditions. Oil flow was found to be driven downward by buoyancy forces due to cooling at the sample surface then upward due to entrainment in vapor bubbles during boiling conditions. Experimental work showed the convective heat transfer coefficient to be a dynamic property ranging from 300 to 1100 W/m2°C and to be strongly coupled with bulk movement of the oil. Heat flux measurements found a peak flux of nearly 30,000 W/m3. Based on analysis of bubble dynamics it is hypothesized that heat flux increases with increased oil degradation through a reduction in vapor bubble size and increase in bubble frequency due to changes in interfacial properties of the oil.

Brian E. Farkas | B. Farkas | Lynn J. Hubbard | L. J. Hubbard

[1] J. C. Jaeger,et al. Conduction of Heat in Solids , 1952 .

[2] B. Farkas,et al. A METHOD FOR DETERMINING THE CONVECTIVE HEAT TRANSFER COEFFICIENT DURING IMMERSION FRYING , 1999 .

[3] B. Farkas,et al. Modeling heat and mass transfer in immersion frying. I, model development , 1996 .

[4] R. Singh,et al. VISCOSITY and SURFACE TENSION of CORN OIL AT FRYING TEMPERATURES , 1995 .

[5] B. Farkas,et al. Viscosity and heat transfer coefficients for canola, corn, palm, and soybean oil , 1994 .

[6] Dennis R. Heldman,et al. Introduction to food engineering , 1984 .

[7] P. Richardson,et al. Boiling heat transfer and two-phase flow , 1956 .

[8] B. Gil,et al. The effect of surfactants on the interfacial tension of frying fat , 1995 .

[9] Richard F. Stier,et al. Optimization of deep-fat frying operations , 1991 .

[10] G. Saravacos,et al. Effect of ethyl oleate on the rate of air-drying of foods , 1988 .

[11] B. Farkas,et al. Modeling heat and mass transfer in immersion frying. II, model solution and verification , 1996 .

[12] R. Moreira,et al. SIMULTANEOUS HEAT and MASS TRANSFER DURING the DEEP FAT FRYING of TORTILLA CHIPS , 1995 .

[13] G. Takeoka,et al. Effect of Heating on the Characteristics and Chemical Composition of Selected Frying Oils and Fats , 1997 .

[14] Y. Jaluria,et al. An Introduction to Heat Transfer , 1950 .