Numerical assessment of an L-shaped Gurney flap for load control

The aerodynamic performance of a novel trailing edge L-shaped flap design is characterized numerically by means of computational fluid dynamics. The device is primarily thought for aerodynamic load adaptation to flight conditions. The device could be applied on a broad range of flying vehicles, like rotorcraft, for which it has been primarily designed, and also fixed wing aircraft and wind turbines. The operation of this movable surface is twofold. On one side, when the device is deployed downward, it acts as a Gurney flap, allowing the increase of the aerodynamic lift, without severe drawbacks in terms of drag rise. On the other side, when it is deflected upward, it is found capable to significantly alleviate the negative effects of stall. Simulations are carried out on a NACA 0012 airfoil equipped with the present L-shaped device at several angles of attack, both in linear and stall regimes. The reliability of numerical computations is supported by comparisons with pressure measurements and PIV surveys. Moreover, for small angles of attack, a Mach sensitivity analysis is performed, to assess the effects of compressibility on the L-shaped flap. Additionally, this work highlights how such device, when designed appropriately, can even delay the static stall onset.

[1]  Giuseppe Gibertini,et al.  Experimental investigation of a trailing edge L-shaped tab on a pitching airfoil in deep dynamic stall conditions , 2014 .

[2]  Peipei Zhang,et al.  Numerical Simulation of Gurney Flap on RAE-2822 Supercritical Airfoil , 2011 .

[3]  B. V. Leer,et al.  Towards the ultimate conservative difference scheme V. A second-order sequel to Godunov's method , 1979 .

[4]  Kolja Kindler,et al.  A comprehensive PIV measurement campaign on a fully equipped helicopter model , 2012 .

[5]  Scott J. Johnson,et al.  An overview of active load control techniques for wind turbines with an emphasis on microtabs , 2010 .

[6]  E. Turkel,et al.  Preconditioned methods for solving the incompressible low speed compressible equations , 1987 .

[7]  Valentina Motta,et al.  Linear Reduced-Order Model for Unsteady Aerodynamics of an L-Shaped Gurney Flap , 2015 .

[8]  David W. Hurst,et al.  Aerodynamics of Gurney Flaps on a Single-Element High-Lift Wing , 2000 .

[9]  Earl H. Dowell,et al.  Aerodynamic Loading for an Airfoil with an Oscillating Gurney Flap , 2007 .

[10]  Giuseppe Gibertini,et al.  Stereo particle image velocimetry measurements of perpendicular blade–vortex interaction over an oscillating airfoil , 2014, Experiments in Fluids.

[11]  Walid Khier,et al.  CFD prediction of air flow past a full helicopter configuration , 2012 .

[12]  Russell M. Cummings,et al.  Numerical Investigation of an Airfoil with a Gurney Flap , 1998 .

[13]  Kevin Standish,et al.  Two-Dimensional Wind Tunnel and Computational Investigation of a Microtab Modified Airfoil , 2005 .

[14]  Frank Thiele,et al.  Separation Control by Self-Activated Movable Flaps , 2004 .

[15]  Mustafa Yavuz.  Vortex Shedding From Circular and Rectangular Cylinders Placed Horizontally in a Turbulent Flow , 2000 .

[16]  J. Kentfield,et al.  The potential of Gurney flaps for improving the aerodynamic performance of helicopter rotors , 1993 .

[17]  Hak-Tae Lee,et al.  Computational Investigation of Airfoils with Miniature Trailing Edge Control Surfaces , 2004 .

[18]  Roberto Celi,et al.  Optimum Two-Per-Revolution Inputs for Improved Rotor Performance , 2005 .

[19]  Jinjun Wang,et al.  Gurney flap—Lift enhancement, mechanisms and applications , 2008 .

[20]  George N. Barakos,et al.  Assessment of CFD methods against experimental flow measurements for helicopter flows , 2012 .

[21]  Earl H. Dowell,et al.  Aerodynamic Flow Control of an Airfoil with Small Trailing-Edge Strips , 2006 .

[22]  J. Gordon Leishman,et al.  Principles of Helicopter Aerodynamics , 2000 .

[23]  Giuseppe Quaranta,et al.  Assessment of 2D/3D Numerical Modeling for Deep Dynamic Stall Experiments , 2014 .

[24]  Olivier A. Bauchau,et al.  A CFD–CSD coupled-analysis of HART-II rotor vibration reduction using gurney flaps , 2010 .

[25]  C. P. van Dam,et al.  Computational Analysis of a Microtab-Based Aerodynamic Load Control System for Rotor Blades , 2005 .

[26]  R. Geoffrey Benson,et al.  Influence of Airfoils on Stall Flutter Boundaries Of Articulated Helicopter Rotors , 1972 .

[27]  Earl P. N. Duque,et al.  Numerical Investigation of Miniature Trailing-Edge Effectors on Static and Oscillating Airfoils , 2005 .

[28]  Tim Lee,et al.  Pitching Airfoil with Combined Gurney Flap and Unsteady Trailing-Edge Flap Deflection , 2012 .

[29]  B. V. Leer,et al.  Towards the ultimate conservative difference scheme. IV. A new approach to numerical convection , 1977 .

[30]  Kai Richter,et al.  Experimental investigation of trailing-edge devices at transonic speeds , 2002 .

[31]  Jinjun Wang,et al.  Influences of Mounting Angles and Locations on the Effects of Gurney Flaps , 2003 .

[32]  Guy Dumas,et al.  Gurney flap effects and scaling for low-speed airfoils , 1995 .

[33]  Jun Wang,et al.  Experimental investigations on the effects of divergent trailing edge and Gurney flaps on a supercritical airfoil , 2007 .

[34]  Jose Palacios,et al.  Active Gurney Flaps: Their Application in a Rotor Blade Centrifugal Field , 2014 .

[35]  Earl P. N. Duque,et al.  Numerical Investigation on the Aerodynamics of Oscillating Airfoils with Deployable Gurney Flaps , 2010 .

[36]  Yang-Yao Niu,et al.  How Does a Gurney Flap Enhance the Aerodynamics Forces , 2010 .

[37]  Joyce A. Dever,et al.  30th Aerospace Sciences Meeting and Exhibit , 1992 .

[38]  Eusebio Valero,et al.  Aerodynamic technologies to improve aircraft performance , 2013 .

[39]  George N. Barakos,et al.  Computational aeroelastic analysis of a hovering W3 Sokol blade with gurney flap , 2015 .

[40]  I. H. Abbott,et al.  Theory of Wing Sections , 1959 .

[41]  Li Liu,et al.  Computational Study of Microflaps with Application to Vibration Reduction in Helicopter Rotors , 2011 .

[42]  V. Venkatakrishnan,et al.  IMPLICIT METHOD FOR THE COMPUTATION OF UNSTEADY FLOWS ON UNSTRUCTURED GRIDS , 1995 .

[43]  R. Liebeck.  Design of Subsonic Airfoils for High Lift , 1976 .