A 50-V Isolation, 100-MHz, 50-mW Single-Chip Junction Isolated DC-DC Converter With Self-Tuned Maximum Power Transfer Frequency

A fully integrated, point-of-load, low-noise, isolated dc–dc converter for supply regulation of high dynamic range analog and mixed-signal isolated sensor signal-chains is presented. The isolated dc–dc converter utilizes an integrated planar air-core micro-transformer as a coupled-resonator and an isolation barrier, and enables direct connection of low-voltage mixed-signal circuits to higher supply rails for current and voltage sensing. The transformer is driven at its resonant frequency of 100 MHz to achieve maximum power transfer. A mixed-signal perturb-and-observe-based frequency search algorithm is developed to improve maximum power transfer efficiency by 60% across the isolation barrier compared to fixed driving frequency method. The switching ripple at output is reduced by 11 dB utilizing spread spectrum clocking in the driver, and 21 dB using a low-dropout regulator. Conducted and radiated EMI distribution on the IC is measured by a set of proposed ring oscillator-based noise sensors with −68-dBm noise sensitivity. The proposed isolated converter achieves the highest level of integration compared to state-of-the-art integrated isolated converters, and provides 50-V on-chip junction isolation using standard CMOS technology.

[1]  Alexandre Boyer,et al.  On-Chip Noise Sensor for Integrated Circuit Susceptibility Investigations , 2012, IEEE Transactions on Instrumentation and Measurement.

[2]  Howard C. Luong,et al.  A 1V 4 GHz-and-10 GHz transformer-based dual-band quadrature VCO in 0.18 μm CMOS , 2007, 2007 IEEE Custom Integrated Circuits Conference.

[3]  Vincenzo Fiore,et al.  16.7 A fully-integrated half-duplex data/power transfer system with up to 40Mb/s data rate, 23mW output power and on-chip 5kV galvanic isolation , 2016, 2016 IEEE International Solid-State Circuits Conference (ISSCC).

[4]  Lee-Sup Kim,et al.  A Spread Spectrum Clock Generator for DisplayPort Main Link , 2011, IEEE Transactions on Circuits and Systems II: Express Briefs.

[5]  On-chip spiral inductors with patterned ground shields for Si-based RF ICs , 1998 .

[6]  Nunzio Spina,et al.  A Galvanically Isolated DC–DC Converter Based on Current-Reuse Hybrid-Coupled Oscillators , 2017, IEEE Transactions on Circuits and Systems II: Express Briefs.

[7]  Takehiro Imura,et al.  Basic experimental study on helical antennas of wireless power transfer for Electric Vehicles by using magnetic resonant couplings , 2009, 2009 IEEE Vehicle Power and Propulsion Conference.

[8]  Zhiwei Zhou,et al.  A stretchable EMI measurement sheet with 8×8 coil array, 2V organic CMOS decoder, and −70dBm EMI detection circuits in 0.18¼m CMOS , 2009, 2009 IEEE International Solid-State Circuits Conference - Digest of Technical Papers.

[9]  Baoxing Chen,et al.  Fully integrated isolated dc-dc converter using micro-transformers , 2008, 2008 Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition.