Biological removal of siloxanes from landfill and digester gases: opportunities and challenges.

The presence of volatile methyl siloxanes (VMSs) presents challenges for using landfill and digester gases as energy fuels because of the formation of silicon dioxide deposits during combustion. This study looks at the feasibility of using biological treatment to control VMSs. Biotrickling filters removing octamethylcyclotetrasiloxane (D4), selected as a model VMS, from aerobic and anaerobic waste gas streams were setup. The efficacy of both aerobic and anaerobic biotrickling filters was low. The removal of D4 in the aerobic biotrickling filter followed a linear trend, reaching 43% at a gas empty bed residence time of 19.5 min. Aerobic biodegradation of D4 in shake flasks was found to be extremely slow, with trace concentrations requiring 3-4 months for complete degradation. Gas-liquid partition tests revealed that D4 partitions poorly into aqueous phases and that interphase mass transfer is slow. Using the mass transfer data, we estimated the maximum possible mass transfer rate of D4 in the biotrickling filter to be in the range of 30-100 mg m(-3) h(-1). These values are low and suggest that mass transfer limitations play an important role in the low treatment performance that was observed. The possibility of enhancing D4 mass transfer by using oleyl alcohol as a second nonmiscible liquid phase was unsuccessful. Overall, the results demonstrate that biological treatment of D4 vapors is possible but poses significant challenges.

[1]  A. Hirner,et al.  Microbial Degradation of Octamethylcyclotetrasiloxane , 1999, Applied and Environmental Microbiology.

[2]  J. W. van Groenestijn,et al.  Elimination of alkanes from off-gases using biotrickling filters containing two liquid phases , 1999 .

[3]  E. Wheless,et al.  Siloxanes in Landfill and Digester Gas Update , 2005 .

[4]  Sergio Revah,et al.  Two-phase partitioning bioreactors for treatment of volatile organic compounds. , 2007, Biotechnology advances.

[5]  D J Kent,et al.  Octamethylcyclotetrasiloxane in aquatic sediments: toxicity and risk assessment. , 1994, Ecotoxicology and environmental safety.

[6]  Y. Oh,et al.  Removal of nitrobenzene vapors by a trickling air biofilter , 1997, Journal of Industrial Microbiology and Biotechnology.

[7]  M. Deshusses,et al.  Biofiltration for air pollution control , 1998 .

[8]  R. G. Lehmann,et al.  Degradation of silicone polymer in a variety of soils , 1995 .

[9]  J. Hobson.  Existing chemical testing for environmental fate and effects under TSCA section 4 : a case study with octamethylcyclotetrasiloxane (OMCTS) , 1995 .

[10]  H. H. Beeftink,et al.  Feasibility of using water-immiscible organic solvents in biological waste-gas treatment , 1995 .

[11]  R. Niessner,et al.  Removal of siloxanes in biogases. , 2001, Journal of hazardous materials.

[12]  H. Collins,et al.  Microbial Degradation of Dimethylsilanediol in Soil , 1998 .

[13]  A Kornberg,et al.  Science or Technology* , 1980, Journal of dental research.

[14]  L J Thibodeaux,et al.  Air‐water partition constants for volatile methyl siloxanes , 2001, Environmental toxicology and chemistry.

[15]  L. D. Collins,et al.  Benzene/toluene/p-xylene degradation. Part I. Solvent selection and toluene degradation in a two-phase partitioning bioreactor , 1999, Applied Microbiology and Biotechnology.

[16]  N. A T H A L I,et al.  Treatment of Methyl tert-Butyl Ether Vapors in Biotrickling Filters . 1 . Reactor Startup , Steady-State Performance , and Culture Characteristics , 1999 .

[17]  Georg M. Guebitz,et al.  Siloxane removal from biogas by biofiltration: biodegradation studies , 2008 .

[18]  Raf Dewil,et al.  Energy use of biogas hampered by the presence of siloxanes. , 2006 .

[19]  J. Spivack,et al.  Biodegradation of dimethylsilanediol in soils , 1996, Applied and environmental microbiology.

[20]  P. Hentschel,et al.  Determination of siloxanes in biogas from landfills and sewage treatment plants , 2002 .

[21]  M. Deshusses,et al.  Comparison of Different Packing Materials for the Biofiltration of Air Toxics , 2006, Journal of the Air & Waste Management Association.

[22]  A. Vaidya,et al.  Biotreatment of waste gas containing pyridine in a biofilter. , 2007, Bioresource technology.

[23]  J. Hamelink,et al.  Henry's law constant, volatilization rate, and aquatic half-life of octamethylcyclotetrasiloxane , 1996 .

[24]  R. Niessner,et al.  Determination of Siloxanes and VOC in Landfill Gas and Sewage Gas by Canister Sampling and GC-MS/AES Analysis , 1999 .

[25]  N. A T H A L I,et al.  Treatment of Methyl tert-Butyl Ether Vapors in Biotrickling Filters . 2 . Analysis of the Rate-Limiting Step and Behavior under Transient Conditions , 1999 .

[26]  H. Schröder,et al.  Cyclic siloxanes in the biological waste water treatment process – Determination, quantification and possibilities of elimination , 1996 .

[27]  M. Deshusses,et al.  Development of foamed emulsion bioreactor for air pollution control , 2003, Biotechnology and bioengineering.

[28]  A. Pauss,et al.  Removal of Styrene from Waste Gas Using a Biological Trickling Filter , 2005 .

[29]  J. W. Barton,et al.  Influence of high biomass concentrations on alkane solubilities , 2000, Biotechnology and bioengineering.

[30]  M. Deshusses,et al.  Methyl tert-butyl ether (MTBE) degradation by a microbial consortium. , 2001, Environmental microbiology.