Black carbon emissions from modern automated cordwood stoves for space heating

Wood burning stove design is improving as regulation become stricter for particulate matter emissions. This study describes results of black carbon (BC) emissions from three modern automated wood stoves when tested in common failure modes using a test protocol that included cold‐starts, high and low fuel loading densities, and use of overly large pieces of fuel. Emission sampling was performed using a dilution sampling system in tandem with an aethalometer to measure BC with high time resolution. Results show that the time‐weighted average BC emission rates were 0.91, 4.30, and 1.74 g/h for the three stoves tested (A, B, and C respectively), the values, both higher and lower than the United States 2020 certification test emission limit of 2.5 g/h. The results demonstrate good performance overall, given the rigorous nature of the testing protocol used. The aethalometer data showed that the performance was relatively poor during cold‐start, when the fuel was ignited and combusted without a coalbed, and when stoves failed to optimize air delivery due to specific loading and output conditions. During the cold‐start test section, the average BC emission rate was seven times higher than the overall average for Stove A, 10 times above the average for Stove B, and two times above the average emission rate for Stove C. Calculations of the Average Angstrom Absorption Exponent (AAE) of the exhaust aerosol showed little correlation with BC concentration. The results show that automation results in a quantifiable reduction in particular BC emissions.

[1]  R. Trojanowski,et al.  A review of regulatory standard test methods for residential wood heaters and recommendations for their advancement , 2023, Renewable and Sustainable Energy Reviews.

[2]  Brian P. Frank,et al.  Realistic operation of two residential cordwood-fired outdoor hydronic heater appliances—Part 3: Optical properties of black and brown carbon emissions , 2022, Journal of the Air & Waste Management Association.

[3]  V. Fthenakis,et al.  Realistic operation of two residential cordwood-fired outdoor hydronic heater appliances—Part 1: Particulate and gaseous emissions , 2022, Journal of the Air & Waste Management Association.

[4]  Mehdi Ahmadi,et al.  Development of an integrated duty cycle test method to assess cordwood stove performance , 2022, Journal of the Air & Waste Management Association.

[5]  L. Rector,et al.  Impact of fueling protocols on emission outcomes for residential wood-fired appliances , 2022, Journal of the Air and Waste Management Association.

[6]  L. Rector,et al.  Residential wood heating: An overview of U.S. impacts and regulations , 2022, Journal of the Air & Waste Management Association.

[7]  T. Butcher,et al.  Results of the 2018 Wood Stove Design Challenge , 2021 .

[8]  J. Sjöblom,et al.  Light my fire but don’t choke on the smoke: Wellbeing and pollution from fireplace use in Sweden , 2020, Energy Research & Social Science.

[9]  C. Sioutas,et al.  Source apportionment of black carbon (BC) from fossil fuel and biomass burning in metropolitan Milan, Italy , 2019, Atmospheric Environment.

[10]  Nicholas Good,et al.  The Fort Collins commuter study: Variability in personal exposure to air pollutants by microenvironment , 2019, Indoor air.

[11]  R. Zimmermann,et al.  Time-resolved chemical composition of small-scale batch combustion emissions from various wood species , 2018, Fuel.

[12]  Handbook on the Least Developed Country Category , 2018 .

[13]  M. Zheng,et al.  Source apportionment of black carbon during winter in Beijing. , 2018, The Science of the total environment.

[14]  T. Butcher,et al.  Repeatability in Particulate and Gaseous Emissions from Pellet Stoves for Space Heating , 2018 .

[15]  Colin Vance,et al.  Outdoor cooking prevalence in developing countries and its implication for clean cooking policies , 2017 .

[16]  G. Evans,et al.  Ambient measurements and source apportionment of fossil fuel and biomass burning black carbon in Ontario , 2017 .

[17]  S. Ramachandran,et al.  Characteristics and source apportionment of black carbon aerosols over an urban site , 2017, Environmental Science and Pollution Research.

[18]  C. Long,et al.  Critical review of black carbon and elemental carbon source apportionment in Europe and the United States , 2016 .

[19]  Yan-lin Zhang,et al.  Evaluation of the absorption Ångström exponents for traffic and wood burning in the Aethalometer-based source apportionment using radiocarbon measurements of ambient aerosol , 2016 .

[20]  L. Knibbs,et al.  Daily personal exposure to black carbon: a pilot study , 2016 .

[21]  Teresa Nunes,et al.  Influence of operating conditions on chemical composition of particulate matter emissions from residential combustion , 2015 .

[22]  Bo Li,et al.  Personal exposure to black carbon during commuting in peak and off-peak hours in Shanghai. , 2015, The Science of the total environment.

[23]  Teresa Nunes,et al.  Emission of carbon monoxide, total hydrocarbons and particulate matter during wood combustion in a stove operating under distinct conditions , 2015 .

[24]  Guofeng Shen,et al.  Influence of fuel moisture, charge size, feeding rate and air ventilation conditions on the emissions of PM, OC, EC, parent PAHs, and their derivatives from residential wood combustion. , 2013, Journal of environmental sciences.

[25]  A. Robinson,et al.  Absorptivity of brown carbon in fresh and photo-chemically aged biomass-burning emissions , 2013 .

[26]  Bin Li,et al.  Influence of fuel mass load, oxygen supply and burning rate on emission factor and size distribution of carbonaceous particulate matter from indoor corn straw burning. , 2013, Journal of environmental sciences.

[27]  Abderrahmane Touati,et al.  Emissions characterization of residential wood-fired hydronic heater technologies , 2012 .

[28]  Geert Wets,et al.  Personal exposure to Black Carbon in transport microenvironments , 2012 .

[29]  Svend Bram,et al.  A Review on Particle Emissions from Small Scale Biomass Combustion , 2012 .

[30]  Ge Peng,et al.  Particulate and gaseous emissions from manually and automatically fired small scale combustion systems , 2011 .

[31]  G. Scheffknecht,et al.  Characterisation of particulates and carcinogenic polycyclic aromatic hydrocarbons in wintertime wood-fired heating in residential areas , 2011 .

[32]  H. R. Anderson,et al.  Black Carbon as an Additional Indicator of the Adverse Health Effects of Airborne Particles Compared with PM10 and PM2.5 , 2011, Environmental health perspectives.

[33]  J. Ogren.  Comment on “Calibration and Intercomparison of Filter-Based Measurements of Visible Light Absorption by Aerosols” , 2010 .

[34]  W. P. Arnott,et al.  Strong spectral variation of biomass smoke light absorption and single scattering albedo observed with a novel dual-wavelength photoacoustic instrument , 2008 .

[35]  B. Coull,et al.  Ambient site, home outdoor and home indoor particulate concentrations as proxies of personal exposures. , 2008, Journal of environmental monitoring : JEM.

[36]  Sönke Szidat,et al.  Using aerosol light absorption measurements for the quantitative determination of wood burning and traffic emission contributions to particulate matter. , 2008, Environmental science & technology.

[37]  Sönke Szidat,et al.  Comparison of several wood smoke markers and source apportionment methods for wood burning particulate mass , 2008 .

[38]  R. Gebart,et al.  THE INFLUENCE OF FUEL TYPE ON PARTICLE EMISSIONS IN COMBUSTION OF BIOMASS PELLETS , 2005 .

[39]  Thomas W. Kirchstetter,et al.  Evidence that the spectral dependence of light absorption by aerosols is affected by organic carbon , 2004 .

[40]  B. Leckner,et al.  Emission characteristics of modern and old-type residential boilers fired with wood logs and wood pellets , 2004 .

[41]  Christoffer Boman,et al.  Characterization of inorganic particulate matter from residential combustion of pelletized biomass fuels , 2004 .

[42]  Joakim Pagels,et al.  Boiler operation influence on the emissions of submicrometer-sized particles and polycyclic aromatic hydrocarbons from biomass-fired grate boilers , 2004 .

[43]  H. Horvath,et al.  UV-VIS-NIR spectral optical properties of soot and soot-containing aerosols , 2003 .

[44]  Judith C. Chow,et al.  Fine Particle and Gaseous Emission Rates from Residential Wood Combustion , 2000 .

[45]  T. E. Ward,et al.  Quality-assurance procedures: Method 28 certification and auditing of wood heaters , 1989 .

[46]  G. Reichert,et al.  Advanced Test Methods for Firewood Stoves , 2018 .

[47]  Christoph Hochenauer,et al.  beReal - Development of a New Test Method for Firewood Roomheaters Reflecting Real Life Operation , 2016 .

[48]  Ingwald Obernberger,et al.  Fine particulate emissions from modern Austrian small-scale biomass combustion plants , 2007 .

[49]  U. Wieser,et al.  Field investigations of nanoparticle emissions from various biomass combustion systems , 2022 .