A FIRST-PRINCIPLES SIMULATION MODEL FOR THE START-UP AND CYCLING TRANSIENTS OF HOUSEHOLD REFRIGERATORS

Abstract A first-principles model for simulating the transient behavior of household refrigerators is presented in this study. The model was employed to simulate a typical frost-free 440-l top-mount refrigerator, in which the compressor is on–off controlled by the freezer temperature, while a thermo-mechanical damper is used to set the fresh-food compartment temperature. Innovative modeling approaches were introduced for each of the refrigerator components: heat exchangers (condenser and evaporator), non-adiabatic capillary tube, reciprocating compressor, and refrigerated compartments. Numerical predictions were compared to experimental data showing a reasonable level of agreement for the whole range of operating conditions, including the start-up and cycling regimes. The system energy consumption was found to be within ±10% agreement with the experimental data, while the air temperatures of the compartments were predicted with a maximum deviation of ±1 °C.

[1]  J. MacArthur,et al.  Unsteady compressible two-phase flow model for predicting cyclic heat pump performance and a comparison with experimental data , 1989 .

[2]  C. J. Baroczy,et al.  CORRELATION OF LIQUID FRACTION IN TWO-PHASE FLOW WITH APPLICATION TO LIQUID METALS , 1963 .

[3]  D. O’Neal,et al.  Development of a Transient Simulation Model of a Freezer Part I: Model Development , 1994 .

[4]  D. Didion,et al.  A simulation model of the transient performance of a heat pump , 1982 .

[5]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[6]  M. Zaheeruddin,et al.  Dynamic simulation and analysis of a water chiller refrigeration system , 2005 .

[7]  Christian J.L. Hermes,et al.  A study of the air-side heat transfer and pressure drop characteristics of tube-fin 'no-frost' evaporators , 2009 .

[8]  Pradeep Bansal,et al.  Transient simulation of vapour-compression packaged liquid chillers , 2002 .

[9]  Manmohan Dhar,et al.  TRANSIENT ANALYSIS OF REFRIGERATION SYSTEM , 1978 .

[10]  J. Vargas,et al.  Simulation in transient regime of a heat pump with closed-loop and on-off control , 1995 .

[11]  C. Melo,et al.  Capheat: An Homogeneous Model to Simulate Refrigerant Flow Through Non Adiabatic Capillary Tubes , 1996 .

[12]  Xiaoqiang Xu.  Modélisation dynamique d'un système frigorifique domestique à compression de vapeur , 1996 .

[13]  N. Galanis,et al.  Prediction of the transient response of heat pumps , 1987 .

[14]  L. Kuijpers,et al.  THEORETICAL AND EXPERIMENTAL INVESTIGATION OF A DYNAMIC MODEL FOR SMALL REFRIGERATING SYSTEMS. , 1988 .

[15]  David A. Yashar,et al.  An Investigation of Refrigerant Void Fraction in Horizontal, Microfin Tubes , 2001 .

[16]  L. Kuijpers,et al.  Cycling losses in domestic appliances: an experimental and theoretical analysis , 1992 .

[17]  V. W. Goldschmidt,et al.  Cyclic characteristics of a typical residential air conditioner-modeling of start-up transients , 1985 .

[18]  Christian J.L. Hermes,et al.  A heat transfer correlation for natural draft wire-and-tube condensers , 2009 .

[19]  S. Klein,et al.  NIST Standard Reference Database 23: NIST Thermodynamic and Transport Properties of Refrigerants and Refrigerant Mixtures-REFPROP, Version 6.0 | NIST , 1998 .

[20]  Min-Soo Kim,et al.  Transient thermal behavior of a water heater system driven by a heat pump , 2004 .

[21]  L. Shampine,et al.  Computer solution of ordinary differential equations : the initial value problem , 1975 .

[22]  Dongsoo Jung,et al.  Flow condensation heat transfer coefficients of pure refrigerants , 2003 .

[23]  J. MacArthur.  Transient heat pump behaviour: a theoretical investigation , 1984 .

[24]  Piotr A. Domanski,et al.  Simulation of an Evaporator with Nonuniform One-Dimensional Air Distribution | NIST , 1991 .

[25]  S. Touber,et al.  Simulation model of a vapor compression refrigeration system , 1983 .

[26]  L. Ploug-S⊘rensen,et al.  Improvements in the Modeling and Simulation of Refrigeration Systems: Aerospace Tools Applied to a Domestic Refrigerator , 1997 .

[27]  Somchai Wongwises,et al.  Two-phase evaporative heat transfer coefficients of refrigerant HFC-134a under forced flow conditions in a small horizontal tube , 2000 .

[28]  Zhijiu Chen,et al.  Dynamic simulation and optimal matching of a small-scale refrigeration system , 1991 .