Performance of a hydroxygen-blended gasoline engine at different hydrogen volume fractions in the hydroxygen

Abstract The gasoline engines always encounter the deteriorated thermal efficiency and increased toxic emissions at part load conditions. This paper investigated the effect of hydrogen/oxygen blends (hydroxygen) addition on the performance of a gasoline engine at different hydrogen volume fractions in the hydroxygen. The experiment was conducted on a 1.6 L gasoline engine equipped with a hydrogen and oxygen port injection system. A hybrid electronic control unit was adopted to control the spark timing and the injection timings and durations of hydrogen, oxygen and gasoline. The test was performed at a typical city driving speed of 1400 rpm, a manifolds absolute pressure of 61.5 kPa and two excess oxygen ratios of 1.00 and 1.20. The overall volume fraction of the hydroxygen in the total intake gas was fixed at 3%. The hydrogen volume fraction in the hydroxygen was raised from 0% to 100% by changing the injection durations of hydrogen and oxygen. The test results demonstrated that the engine thermal efficiency was obviously increased with the increase of hydrogen volume fraction in the hydroxygen. The fuel energy flow rate of the 3% hydroxygen-blended gasoline engine was lower than that of the original engine when the hydrogen volume fraction in the hydroxygen exceeded 70%. Both the flame development and propagation periods were shortened after the hydroxygen addition. HC, CO and NOx emissions were decreased with the increase of hydrogen volume fraction in the hydroxygen. But NOx emissions of the hydroxygen-blended engine were higher than those of the original engine for all hydrogen volume fractions in the hydroxygen. Moreover, at an excess oxygen ratio of 1.00, CO from the 3% hydroxygen-blended gasoline engine was also higher than that from the original engine. The reduced particulate emissions can be obtained only at relatively high hydrogen volume fractions in the hydroxygen.

[1]  Saiful Bari,et al.  Effect of H2/O2 addition in increasing the thermal efficiency of a diesel engine , 2010 .

[2]  R. Bilbao,et al.  Formation of PAH and soot during acetylene pyrolysis at different gas residence times and reaction temperatures , 2012 .

[3]  Zuo-hua Huang,et al.  Measurements of laminar burning velocities for natural gas–hydrogen–air mixtures , 2006 .

[4]  L. M. Das,et al.  Hydrogen-oxygen reaction mechanism and its implication to hydrogen engine combustion , 1996 .

[5]  Derek Dunn-Rankin,et al.  Lean Combustion Technology and Control , 2011 .

[6]  P. Henshaw,et al.  Effects of addition of electrolysis products on methane/air premixed laminar combustion , 2001 .

[7]  Deming Jiang,et al.  Study of cyclic variations of direct-injection combustion fueled with natural gas–hydrogen blends using a constant volume vessel , 2008 .

[8]  F. Barbir,et al.  Hydrogen: the wonder fuel , 1992 .

[9]  Maher A.R. Sadiq Al-Baghdadi,et al.  A prediction study of the effect of hydrogen blending on the performance and pollutants emission of a four stroke spark ignition engine , 1999 .

[10]  V. Balasubramanian,et al.  Hydrogen fueled spark ignition engine with electronically controlled manifold injection: An experimental study , 2008 .

[11]  Baris Ozerdem,et al.  An experimental study on performance and emission characteristics of a hydrogen fuelled spark ignition engine , 2007 .

[12]  S. Turns.  An Introduction to Combustion: Concepts and Applications , 2000 .

[13]  Yituan He,et al.  Idle characteristics of a hydrogen fueled SI engine , 2011 .

[14]  H. K. Abdel-Aal,et al.  A new approach to utilize Hydrogen as a safe fuel , 2005 .

[15]  C. Rakopoulos,et al.  Hydrogen enrichment effects on the second law analysis of natural and landfill gas combustion in engine cylinders , 2006 .

[16]  Fanhua Ma,et al.  Study on the extension of lean operation limit through hydrogen enrichment in a natural gas spark-ignition engine , 2008 .

[17]  Yong Li,et al.  Effects of hydrogen addition on cycle-by-cycle variations in a lean burn natural gas spark-ignition engine , 2008 .

[18]  Maher A.R. Sadiq Al-Baghdadi,et al.  Effect of compression ratio, equivalence ratio and engine speed on the performance and emission characteristics of a spark ignition engine using hydrogen as a fuel , 2004 .

[19]  Bo Zhang,et al.  Starting a spark-ignited engine with the gasoline―hydrogen mixture , 2011 .

[20]  Bing Liu,et al.  Cycle-by-cycle variations in a spark ignition engine fueled with natural gas–hydrogen blends combined with EGR , 2009 .

[21]  G. G. Lucas,et al.  The Hydrogen/Petrol Engine - The Means to Give Good Part-Load Thermal Efficiency , 1982 .

[22]  Jinhua Wang,et al.  Numerical study of the effect of hydrogen addition on methane–air mixtures combustion , 2009 .

[23]  N. Kahraman,et al.  Internal combustion engines fueled by natural gas—hydrogen mixtures , 2004 .

[24]  Zafer Dülger,et al.  Fuel economy improvement by on board electrolytic hydrogen production , 2000 .

[25]  Nafiz Kahraman,et al.  Experimental study on a spark ignition engine fuelled by methane–hydrogen mixtures , 2007 .

[26]  Fanhua Ma,et al.  Performance and emission characteristics of a turbocharged spark-ignition hydrogen-enriched compressed natural gas engine under wide open throttle operating conditions , 2010 .

[27]  Gyeung Ho Choi,et al.  Performance and emissions characteristics of a hydrogen enriched LPG internal combustion engine at 1400 rpm , 2005 .

[28]  David S.-K. Ting,et al.  The addition of hydrogen to a gasoline-fuelled SI engine , 2004 .

[29]  Shuofeng Wang,et al.  Experimental study on combustion and emissions performance of a hybrid hydrogen–gasoline engine at lean burn limits , 2010 .

[30]  Jinhua Wang,et al.  Effect of hydrogen addition on early flame growth of lean burn natural gas–air mixtures , 2010 .

[31]  Bo Zhang,et al.  Combustion and emissions characteristics of a hybrid hydrogen–gasoline engine under various loads and lean conditions , 2010 .

[32]  T. W. Forest,et al.  Effect of hydrogen addition on the performance of methane-fueled vehicles. Part I: effect on S.I. engine performance , 2001 .

[33]  Zhi Ning,et al.  Experimental investigation of the effect of exhaust gas cooling on diesel particulate , 2004 .

[34]  M. Wietschel,et al.  The future of hydrogen : opportunities and challenges , 2009 .

[35]  Shuofeng Wang,et al.  Effect of hydrogen addition on the idle performance of a spark ignited gasoline engine at stoichiometric condition , 2009 .

[36]  D. Lata,et al.  Analysis of ignition delay period of a dual fuel diesel engine with hydrogen and LPG as secondary fuels , 2011 .

[37]  Hongsheng Guo,et al.  Numerical study on the influence of hydrogen addition on soot formation in a laminar ethylene-air diffusion flame , 2006 .

[38]  Richard Stone,et al.  Analysis of the particulate emissions and combustion performance of a direct injection spark ignition engine using hydrogen and gasoline mixtures , 2010 .

[39]  Yong Li,et al.  Experimental study on thermal efficiency and emission characteristics of a lean burn hydrogen enriched natural gas engine , 2007 .

[40]  Syed Yousufuddin,et al.  Effect of ignition timing and compression ratio on the performance of a hydrogen–ethanol fuelled engine , 2009 .

[41]  R. N. Guile,et al.  Hydrocarbon-fueled scramjet combustor investigation , 1992 .