Vibration analysis and control technologies of hydraulic pipeline system in aircraft: A review

Abstract Vibrations in aircraft hydraulic pipeline system, due to multi-source excitation of high fluid pressure fluctuation and serious vibration environment of airframe, can cause the pipeline system vibration failures through overload in engineering field. Controlling the vibrations in hydraulic pipeline is a challenging work to ensure the flight safety of aircraft. The common vibration control technologies have been demonstrated to be effective in typical structures such as aerospace structures, shipbuilding structures, marine offshore structures, motor structures, etc. However, there are few research literatures on vibration control strategies of aircraft hydraulic pipeline. Combining with the development trend of aircraft hydraulic pipeline system and the requirement of vibration control technologies, this paper provides a detailed review on the current vibration control technologies in hydraulic pipeline system. A review of the general approaches following the passive and active control technologies are presented, which are including optimal layout technique of pipeline and clamps, constrained layer damping technique, vibration absorber technique, hydraulic hose technique, optimal pump structure technique, and active vibration control technique of pipeline system. Finally, some suggestions for the application of vibration control technologies in engineering field are given.

[1]  Jingyu Zhai,et al.  Dynamic response analysis of aero hydraulic pipeline system under pump fluid pressure fluctuation , 2019 .

[2]  A. M. Ulanov,et al.  Calculation of Vibration of Pipeline Bundle with Damping Support Made of MR Material , 2017 .

[3]  Leonardo Ramos Rodrigues,et al.  Using Degradation Messages to Predict Hydraulic System Failures in a Commercial Aircraft , 2018, IEEE Transactions on Automation Science and Engineering.

[4]  Yih-Hwang Lin,et al.  ACTIVE FLUTTER CONTROL OF A CANTILEVER TUBE CONVEYING FLUID USING PIEZOELECTRIC ACTUATORS , 1996 .

[5]  Jiao Zongxia.  Research Actuality and Prospect of Active Control of Hydraulic Fluid Fluctuation , 2006 .

[6]  Liu Yongshou.  Sensitivity analysis and dynamic optimization design of supports' positions for engine pipelines , 2012 .

[7]  Zheng Zhang,et al.  Optimization design of aeronautical hydraulic pipeline system based on non-probabilistic sensitivity analysis , 2019, Proceedings of the Institution of Mechanical Engineers, Part O: Journal of Risk and Reliability.

[8]  Noah D. Manring,et al.  The Impact of Using a Secondary Swash-Plate Angle Within an Axial Piston Pump , 2004 .

[10]  Yongshou Liu,et al.  Dynamic reliability of aircraft hydraulic pipelines under random pressure pulsation and vibration , 2010 .

[11]  Yongshou Liu,et al.  Dynamic response of pipeline conveying fluid to random excitation , 2011 .

[12]  Fan Yang,et al.  Filtering performance and optimization of double-chamber compound hydraulic attenuators , 2018 .

[13]  Tianzhi Yang,et al.  Enhanced targeted energy transfer for adaptive vibration suppression of pipes conveying fluid , 2018, Nonlinear Dynamics.

[14]  Chen Ping,et al.  Theoretical Study on Vibration Active Control of Power Supply and Pipeline Systems , 2002 .

[15]  Yanbo Zhu,et al.  A practical approach for evaluating safe fatigue life of hydraulic actuator in helicopter based on a nominal force concept and minimal datasets , 2017 .

[16]  Du Qiang,et al.  Compressive mechanical behavior of multiple wire metal rubber , 2018 .

[17]  Shang Yaoxing,et al.  Active Control of Fluid Pressure Pulsation in Hydraulic Pipe System by Bilateral-Overflow of Piezoelectric Direct-Drive Slide Valve , 2014 .

[18]  S. Elliott,et al.  A non-intrusive fluid-wave actuator and sensor pair for the active control of fluid-borne vibrations in a pipe , 1996 .

[19]  Cheng Huang,et al.  An integrated self-energized brake system for aircrafts based on a switching valve control , 2017 .

[20]  Karl Grosh,et al.  A theoretical study of structural acoustic silencers for hydraulic systems. , 2002, The Journal of the Acoustical Society of America.

[21]  Masaaki Shinada,et al.  Development of an Active Attenuator for Pressure Pulsation in Liquid Piping Systems : Trial Construction of the System and Fundamental Experiments on Attenuation Characteristics , 1993 .

[22]  Mehrdad Ehsani,et al.  Aircraft power systems: technology, state of the art, and future trends , 2000 .

[23]  Feng Zhang,et al.  Optimal design of the positions of the hoops for a hydraulic pipelines system , 2011 .

[24]  Jian-Jun Shu,et al.  Modelling vaporous cavitation on fluid transients , 2014 .

[25]  Jian-Jun Shu.  A Finite Element Model and Electronic Analogue of Pipeline Pressure Transients With Frequency-Dependent Friction , 2003 .

[26]  Xin Li,et al.  Flow field and pressure loss analysis of junction and its structure optimization of aircraft hydraulic pipe system , 2013 .

[27]  Yih-Hwang Lin,et al.  ADAPTIVE MODAL VIBRATION CONTROL OF A FLUID-CONVEYING CANTILEVER PIPE , 1997 .

[28]  Melih Cemal Kuşhan,et al.  Fatigue failure in aircraft structural components , 2016 .

[29]  Hua Deng,et al.  Dynamic response and vibration suppression of a cantilevered pipe conveying fluid under periodic excitation , 2019, Journal of Vibration and Control.

[30]  E. Benjamin Wylie,et al.  Fluid Transients in Systems , 1993 .

[31]  Hongkang Dong,et al.  A novel approach for predicting inlet pressure of aircraft hydraulic pumps under transient conditions , 2019, Chinese Journal of Aeronautics.

[32]  Jun Zou,et al.  Novel Integrated Control of Fluid-Borne Noise in Hydraulic Systems , 2018, BATH/ASME 2018 Symposium on Fluid Power and Motion Control.

[33]  Chen Yan.  Damping Characteristics of Thin Metal Rubber Damper for Aeroengine Piping System , 2001 .

[34]  K A Edge,et al.  Simulation of hydraulic pipeline pressure transients using Matlab Simulink , 2005 .

[35]  As Arris Tijsseling,et al.  FLUID-STRUCTURE INTERACTION IN LIQUID- FILLED PIPE SYSTEMS : A REVIEW , 1996 .

[36]  Hitoshi Doki,et al.  Active Control of Cantilevered Pipes Conveying Fluid With Constraints on Input Energy , 1997, 4th International Symposium on Fluid-Structure Interactions, Aeroelasticity, Flow-Induced Vibration and Noise: Volume II.

[37]  D. Nigel Johnston,et al.  Frequency modelling and solution of fluid–structure interaction in complex pipelines , 2014 .

[38]  Bing Xu,et al.  A new design method for the transition region of the valve plate for an axial piston pump , 2015 .

[39]  Ayman A. Aly.  An Artificial Neural Network Flow Control of Variable Displacement Piston Pump with Pressure Compensation , 2015 .

[40]  D. Wiggert,et al.  Modal Analysis of Vibrations in Liquid-Filled Piping Systems , 1990 .

[41]  Xingjian Wang,et al.  A multi-source information fusion fault diagnosis for aviation hydraulic pump based on the new evidence similarity distance , 2017 .

[42]  D. Wiggert,et al.  Analysis of Liquid and Structural Transients in Piping by the Method of Characteristics , 1987 .

[43]  Soon Keat Tan,et al.  Vibration and pressure fluctuation in a flexible hydraulic power systemon an aircraft , 1998 .

[44]  X Luo,et al.  Semi-active accumulator absorbing pressure pulsation in high-pressure water-jet propulsion system , 2011 .

[45]  Alex Elvin,et al.  The Flutter Response of a Piezoelectrically Damped Cantilever Pipe , 2009 .

[46]  Sina Razvarz,et al.  Control of Flow Rate in Pipeline Using PID Controller , 2019, 2019 IEEE 16th International Conference on Networking, Sensing and Control (ICNSC).

[47]  Monika Ivantysynova,et al.  Effect of Combining Precompression Grooves, PCFV And DCFV on Pump Noise Generation , 2011 .

[48]  Zongxia Jiao,et al.  A compact design of pulsation attenuator for hydraulic pumps , 2016, 2016 IEEE International Conference on Aircraft Utility Systems (AUS).

[49]  A. Javed,et al.  Analysis of premature failure of aircraft hydraulic pipes , 2020 .

[50]  S. Khajehpour,et al.  VIBRATION SUPPRESSION OF A ROTATING FLEXIBLE CANTILEVER PIPE CONVEYING FLUID USING PIEZOELECTRIC LAYERS , 2015 .

[51]  Satyajit Panda,et al.  A design of active constrained layer damping treatment for vibration control of circular cylindrical shell structure , 2018 .

[52]  Zhu Jihong,et al.  Maximization of structural natural frequency with optimal support layout , 2006 .

[53]  Zheng Zhang,et al.  Sensitivity analysis for probabilistic anti-resonance design of aeronautical hydraulic pipelines , 2019 .

[54]  Kenneth A. Cunefare,et al.  Compact Helmholtz Resonators for Hydraulic Systems , 2012 .

[55]  Songjing Li,et al.  Simulation of Hydraulic Pipeline Pressure Transients Accompanying Cavitation and Gas Bubbles Using Matlab/Simulink , 2006 .

[56]  Chen Yan.  Piping System Design of Aero-Engine Using Genetic Algorithms , 2002 .

[57]  Masaaki Shinada,et al.  Fluid Transient Phenomena Accompanied with Column Separation in Fluid Power Pipeline : 1st Report, On the Horizontal Pipeline Downstream of a Valve Instantaneously Closed , 1984 .

[58]  K A Edge,et al.  A method to reduce noise in hydraulic systems by optimizing pipe clamp locations , 1998 .

[60]  Dazhe Zhao,et al.  Fault diagnosis and location of the aero-engine hydraulic pipeline based on Kalman filter , 2017 .

[61]  D. N. Johnston,et al.  Active control of pressure pulsation in a piping system using measured dynamic flow rate , 2013 .

[62]  Liu Hongmei,et al.  Active Control on Fluid Borne Pulsation Using Piezoelectric Valve as Absorber , 2006, 2006 IEEE Conference on Robotics, Automation and Mechatronics.

[63]  Yuanzhi Xu,et al.  Exact solution of axial liquid-pipe vibration with time-line interpolation , 2017 .

[64]  C. Lavooij,et al.  Fluid-structure interaction in liquid-filled piping systems , 1991 .

[65]  S. Ishikawa,et al.  Vibration analysis of viscoelastic damping material attached to a cylindrical pipe by added mass and added damping , 2019, Journal of Sound and Vibration.

[66]  Avic South,et al.  Failure Analysis of Clamp of Bending Tube in Engine , 2012 .

[67]  Masaaki Shinada,et al.  Development of an Active Attenuator for Pressure Pulsation in Liquid Piping Systems : A Real Time-Measuring Method of Progressive Wave in a Pipe , 1991 .

[68]  W. L. Green.  Aircraft Hydraulic Systems: An Introduction to the Analysis of Systems and Components , 1986 .

[69]  Shinichi Yokota,et al.  Study on an Active Accumulator. (Active Control of High-Frequency Pulsation of Flow Rate in Hydraulic Systems). , 1996 .

[70]  Tao Yang,et al.  A Novel Optimization Layout Method for Clamps in a Pipeline System , 2020, Applied Sciences.

[71]  G. V. Lazutkin,et al.  Design of Elastic-damping Supports Made of MR Material for Pipeline Supports☆ , 2017 .

[72]  A. Tijsseling.  Exact solution of linear hyperbolic four-equation system in axial liquid-pipe vibration , 2003 .

[73]  Wei Sun,et al.  Inverse identification of the mechanical parameters of a pipeline hoop and analysis of the effect of preload , 2019, Frontiers of Mechanical Engineering.

[74]  Tianxiao Zhang,et al.  Reliability design for impact vibration of hydraulic pressure pipeline systems , 2013 .

[75]  Min Pan,et al.  Active control of pressure pulsation in a switched inertance hydraulic system , 2012, J. Syst. Control. Eng..

[76]  Qingkai Han,et al.  A model reduction approach for the vibration analysis of hydraulic pipeline system in aircraft , 2016 .

[77]  D N Johnston,et al.  A time-domain model of axial wave propagation in liquid-filled flexible hoses , 2006 .

[78]  D K Longmore,et al.  Transmission of Vibration and Pressure Fluctuations Through Hydraulic Hoses , 1991 .

[79]  Yu Wang,et al.  Performance reliability of jet pipe servo valve under random vibration environment , 2019 .

[80]  Saeed Bab,et al.  Vibration control of a pipe conveying fluid under external periodic excitation using a nonlinear energy sink , 2016 .

[81]  A. M. Ulanov,et al.  Calculation Method of Pipeline Vibration with Damping Supports Made of the MR Material , 2016 .

[82]  Zhu Feng Yue,et al.  Supports’ Dynamical Optimized Design for the External Pipeline of Aircraft Engine , 2010 .

[83]  Zongxia Jiao,et al.  An integrated load sensing valve-controlled actuator based on power-by-wire for aircraft structural test , 2018 .

[84]  Christopher Robert Fuller,et al.  Fluid wave actuator for the active control of hydraulic pulsations in piping systems , 1999 .

[85]  Qingkai Han,et al.  Vibration and damping analysis of aerospace pipeline conveying fluid with constrained layer damping treatment , 2018 .

[86]  Zongxia Jiao,et al.  Modeling and Optimal Design of 3 Degrees of Freedom Helmholtz Resonator in Hydraulic System , 2012 .

[87]  Shaoping Wang,et al.  Modal analysis of two typical fluid-filled pipes in aircraft , 2011, Proceedings of 2011 International Conference on Fluid Power and Mechatronics.

[88]  Hua Zhou,et al.  Investigations on Pulsation-Reduction Characteristics of Hydraulic Attenuator Based on Experimental Method , 2014 .

[89]  Kyong Sei Lee,et al.  Attenuating characteristics of a multi-element buffer bottle in an aircraft piston pump , 2017 .

[90]  Bin Yu,et al.  Fluid-Structure-Interaction Analysis of an Aero Hydraulic Pipe Considering Friction Coupling , 2019, IEEE Access.

[91]  Yangyang Yan,et al.  Vibration Control of an Aero Pipeline System with Active Constraint Layer Damping Treatment , 2019, Applied Sciences.

[92]  Qiang Fu,et al.  Uncertain Frequency Responses of Clamp-Pipeline Systems Using an Interval-Based Method , 2020, IEEE Access.

[93]  Carlos Antonio Reis Pereira Baptista,et al.  Aircraft engine bleed system tubes: Material and failure mode analysis , 2007 .

[94]  Ian Moir,et al.  Aircraft Systems: Mechanical, Electrical, and Avionics Subsystems Integration , 2008 .

[95]  Ma Venkataswamy,et al.  Fatigue failure of aircraft components , 2008 .

[96]  D. Wiggert,et al.  The Effect of Elbow Restraint on Pressure Transients , 1985 .

[97]  Zhang Xue,et al.  Active vibration control of a hoop truss structure with piezoelectric bending actuators based on a fuzzy logic algorithm , 2018, Smart Materials and Structures.

[98]  Feng Gao,et al.  Modal Analysis of the Aircraft Hydraulic-System Pipeline , 2012 .

[99]  Zongxia Jiao,et al.  Development research of reflection-absorption compound type fluid pulsation attenuator , 2012, IEEE 10th International Conference on Industrial Informatics.

[100]  Jian Jun Wang,et al.  Dynamic Characteristics of Fluid-Conveying Pipes with Piecewise Linear Support , 2016 .

[101]  Feng Gao,et al.  A novel pulsation attenuator for aircraft piston pump , 2013 .

[102]  Jiong Tang,et al.  On Vibration Suppression and Energy Dissipation Using Tuned Mass Particle Damper , 2017 .

[103]  K A Edge,et al.  Modeling and simulation of low pressure oil-hydraulic pipeline transients , 2012 .

[104]  Mhamed Souli,et al.  Failure and fatigue life estimate of a pre-stressed Aircraft seat support tube , 2015 .

[105]  S. Ishikawa,et al.  Design of a disc-shaped viscoelastic damping material attached to a cylindrical pipe as a dynamic absorber or Houde damper , 2020, Journal of Sound and Vibration.

[106]  Dan Jiang,et al.  Pressure Transient Model of Water-Hydraulic Pipelines with Cavitation , 2018 .

[107]  Simon Barter,et al.  Fatigue crack growth lessons from thirty-five years of the Royal Australian Air Force F/A-18 A/B Hornet Aircraft Structural Integrity Program , 2020 .

[108]  Bijayani Panda,et al.  Fatigue failure of weld joint of afterburner fuel manifold of a jet engine , 2013 .

[109]  Hong Hao,et al.  Numerical simulation on the effectiveness of using viscoelastic materials to mitigate seismic induced vibrations of above-ground pipelines , 2016 .

[110]  Jiang Hong-yuan.  Research on Dynamic and Static Characteristics of Metal Rubber Isolator Used in Aero-Engine , 2004 .

[111]  Huayong Yang,et al.  Two-dimensional stress analysis of the aircraft hydraulic system pipeline , 2012 .

[112]  Wei Liu,et al.  Pressure Pulsation Analysis of Aircraft Hydraulic Power Pipelines System , 2010 .

[113]  Intan Z. Mat Darus,et al.  Fuzzy-PID Control of Transverse Vibrating Pipe Due to Vortex Induced Vibration , 2013, 2013 UKSim 15th International Conference on Computer Modelling and Simulation.

[114]  Songjing Li,et al.  Modeling of Hydraulic Pipeline Transients Accompanied With Cavitation and Gas Bubbles Using Parallel Genetic Algorithms , 2008 .

[115]  Zongxia Jiao,et al.  Adaptive vibration active control of fluid pressure pulsations , 2003 .

[116]  Gangbing Song,et al.  Experimental studies on the effectiveness and robustness of a pounding tuned mass damper for vibration suppression of a submerged cylindrical pipe , 2017 .

[117]  J.-S. Jang,et al.  REDUCTION OF PRESSURE RIPPLES USING A PARALLEL LINE IN HYDRAULIC PIPELINE , 2005 .

[118]  Yih-Hwang Lin,et al.  NON-LINEAR ACTIVE VIBRATION CONTROL OF A CANTILEVER PIPE CONVEYING FLUID , 1997 .

[119]  Angus R. Simpson,et al.  Water hammer with column separation: A historical review , 2006 .