Effect of a magnetic water treatment on homogeneous and heterogeneous precipitation of calcium carbonate.

In this paper are reported experimental results on the effect of a magnetic field on the precipitation process of calcium carbonate scale from a hard water. Carbonically pure water was circulated at a constant flow rate in a magnetic field. After this treatment, calcium carbonate precipitation was induced by degassing dissolved carbonic gas. The nucleation time was identified from the variations of the pH and the Ca(2+) concentration. The ratio between homogeneous and heterogeneous nucleation was determined from the measurement of the mass of precipitated calcium carbonate. It is shown that the magnetic treatment increases the total amount of precipitate. This effect depends on the solution pH, the flow rate and the duration of the treatment. In addition, the magnetic treatment modifies the ratio between homogeneous/heterogeneous nucleation. Homogeneous nucleation is promoted by an increasing the pH of water, the flow rate as well as the residence time. The magnetic treatment enhances these effects with a maximum for a 15 min treatment time. It is shown that the presence of calcium carbonate colloid particles is not necessary. It is advanced that the main magnetic effects concern the associations of ionic species which are present in the solution and which are involved in the nucleation process of calcium carbonate precipitation.

[1]  K. Kronenberg.  Experimental evidence for effects of magnetic fields on moving water , 1985 .

[2]  H. Madsen.  Crystallization of calcium carbonate in magnetic field in ordinary and heavy water , 2004 .

[3]  Ko Higashitani,et al.  Effects of a Magnetic Field on the Formation of CaCO3 Particles , 1993 .

[4]  M. Keddam,et al.  Magnetic water treatment for scale prevention. , 2001, Water research.

[5]  L. N. Plummer,et al.  The solubilities of calcite, aragonite and vaterite in CO2-H2O solutions between 0 and 90°C, and an evaluation of the aqueous model for the system CaCO3-CO2-H2O , 1982 .

[6]  Gopalakrishnan,et al.  Magnetohydrodynamic Aggregation of Cholesterol and Polystyrene Latex Suspensions , 1996, Journal of colloid and interface science.

[7]  B. Tribollet,et al.  Impedance techniques at partially blocked electrodes by scale deposition , 1997 .

[8]  J. Lédion,et al.  Détermination du caractère incrustant d'une eau par un essai d'entartrage accéléré , 1985 .

[9]  J. M. D. Coey,et al.  Magnetic water treatment , 2000 .

[10]  Higashitani,et al.  Magnetic Effects on Electrolyte Solutions in Pulse and Alternating Fields. , 1999, Journal of colloid and interface science.

[11]  Simon Judd,et al.  Magnetically Augmented Water Treatment , 1997 .

[12]  P. Leroy,et al.  EFFECTS AND CONSEQUENCES OF ELECTRIC TREATMENT IN PREVENTING SCALING OF DRINKING WATER SYSTEMS , 1997 .

[13]  H. Madsen,et al.  Influence of magnetic field on the precipitation of some inorganic salts , 1995 .

[14]  Claude Gabrielli,et al.  Nucleation and growth of calcium carbonate by an electrochemical scaling process , 1999 .

[15]  J. Lédion,et al.  Méthodes d'évaluation du pouvoir entartrant de l'eau , 2002 .

[16]  E. Chibowski,et al.  Adhesion of in situ precipitated calcium carbonate in the presence and absence of magnetic field in quiescent conditions on different solid surfaces. , 2003, Water research.

[17]  J. Bollinger,et al.  Calcium carbonate solubility: a reappraisal of scale formation and inhibition. , 1996, Talanta.

[18]  Kenneth W. Busch,et al.  Laborator studies on magnetic water treatment and their relationship to a possible mechanism for scale reduction , 1997 .

[19]  C. Gabrielli,et al.  Characterization of CaCO3 hydrates by micro‐Raman spectroscopy , 2002 .

[20]  H. Elfil,et al.  Role of hydrate phases of calcium carbonate on the scaling phenomenon , 2001 .

[21]  Theo Vermeiren,et al.  MAGNETIC TREATMENT OF LIQUIDS FOR SCALE AND CORROSION PREVENTION , 1958 .

[22]  M. Keddam,et al.  Estimation of the deposition rate of thermal calcareous scaling by the electrochemical impedance technique , 1996 .

[23]  J. Gal,et al.  Mechanisms of scale formation and carbon dioxide partial pressure influence. Part I. Elaboration of an experimental method and a scaling model. , 2002, Water research.

[24]  M. Tlili,et al.  Influence of water hardness, substrate nature and temperature on heterogeneous calcium carbonate nucleation , 2004 .

[25]  Higashitani,et al.  Magnetic Effects on Thickness of Adsorbed Layer in Aqueous Solutions Evaluated Directly by Atomic Force Microscope. , 1998, Journal of colloid and interface science.

[26]  H. Roques,et al.  Contribution à l'étude des phénomènes d'entartrage. I: Généralités et méthodes d'étude L.C.G.E. , 1994 .

[27]  M. Keddam,et al.  Characterization of the efficiency of antiscale treatments of water. Part II: Physical processes , 1996 .

[28]  Simon Judd,et al.  Magnetic amelioration of scale formation , 1996 .

[29]  C. Gabrielli,et al.  In situ Raman spectroscopy applied to electrochemical scaling. Determination of the structure of vaterite , 2000 .

[30]  S. Parsons,et al.  The influence of magnetic fields on calcium carbonate precipitation , 1998 .

[31]  I. Greenwald.  THE DISSOCIATION OF CALCIUM AND MAGNESIUM CARBONATES AND BICARBONATES , 1941 .

[32]  M. Keddam,et al.  Characterization of the efficiency of antiscale treatments of water Part I: Chemical processes , 1996 .

[33]  C. Gabrielli,et al.  Study of the Electrochemical Deposition of CaCO3 by In Situ Raman Spectroscopy I. Influence of the Substrate , 2003 .

[34]  Spomenka Kobe,et al.  The influence of the magnetic field on the crystallisation form of calcium carbonate and the testing of a magnetic water-treatment device , 2001 .

[35]  Ciril Pohar,et al.  The magnetic field influence on the polymorph composition of CaCO3 precipitated from carbonized aqueous solutions. , 2005, Journal of colloid and interface science.