A Novel Design of Aircraft Fuel Tank Inspection Robot

Aircraft fuel tank leakage is a very common maintenance problem. A continuum robot is designed for troubleshooting of leaks for fuel tank which has strong constraints and is also explosive. The biomimetic robot with several flexible sections applies actuation redundancy through pulling its four independent driving cables to realize bending motion of two degrees of freedom (DOF). The forward kinematics about the relations of cables lengths, angles and tip coordinates of single section is established using projection curvature method and coordinates transformation method. The decoupled multi-section kinematics function is deduced based on the kinematics analysis of single section. Simulations of single section motion are presented. We demonstrate finally the correctness of kinematics method through prototype experiments. DOI:  http://dx.doi.org/10.11591/telkomnika.v11i7.2814 Full Text: PDF

[1]  John Kenneth Salisbury,et al.  Configuration Tracking for Continuum Manipulators With Coupled Tendon Drive , 2009, IEEE Transactions on Robotics.

[2]  Ian D. Walker,et al.  A novel 'elephant's trunk' robot , 1999, 1999 IEEE/ASME International Conference on Advanced Intelligent Mechatronics (Cat. No.99TH8399).

[3]  Kai Xu,et al.  An Investigation of the Intrinsic Force Sensing Capabilities of Continuum Robots , 2008, IEEE Transactions on Robotics.

[4]  Robert J. Webster,et al.  Mechanics of Precurved-Tube Continuum Robots , 2009, IEEE Transactions on Robotics.

[5]  Wang,et al.  development of a continuum robot for colonoscopy , 2009 .

[6]  Ian D. Walker,et al.  Extension versus Bending for Continuum Robots , 2006, ICINCO.

[7]  Nabil Simaan,et al.  Snake-Like Units Using Flexible Backbones and Actuation Redundancy for Enhanced Miniaturization , 2005, Proceedings of the 2005 IEEE International Conference on Robotics and Automation.

[8]  Tanneguy Redarce,et al.  A semi-autonomous micro-robotic system for Colonoscopy , 2009, 2008 IEEE International Conference on Robotics and Biomimetics.

[9]  Ian D. Walker,et al.  Limiting-case Analysis of Continuum Trunk Kinematics , 2007, Proceedings 2007 IEEE International Conference on Robotics and Automation.

[10]  John Kenneth Salisbury,et al.  Mechanics Modeling of Tendon-Driven Continuum Manipulators , 2008, IEEE Transactions on Robotics.

[11]  Tanneguy Redarce,et al.  Sensor-based guidance control of a continuum robot for a semi-autonomous colonoscopy , 2007, Robotics Auton. Syst..

[12]  Robert J. Webster,et al.  Kinematics and calibration of active cannulas , 2008, 2008 IEEE International Conference on Robotics and Automation.

[13]  Tony J. Dodd,et al.  Active Bayesian perception for angle and position discrimination with a biomimetic fingertip , 2013, 2013 IEEE/RSJ International Conference on Intelligent Robots and Systems.

[14]  Ian D. Walker,et al.  Three-Dimensional Modeling and Display of Continuum Robots , 2006, 2006 IEEE/RSJ International Conference on Intelligent Robots and Systems.

[15]  Kai Xu,et al.  Actuation compensation for flexible surgical snake-like robots with redundant remote actuation , 2006, Proceedings 2006 IEEE International Conference on Robotics and Automation, 2006. ICRA 2006..

[16]  J. Bruce C. Davies,et al.  Continuum robots - a state of the art , 1999, Proceedings 1999 IEEE International Conference on Robotics and Automation (Cat. No.99CH36288C).