In situ decoration of Zn 2 SnO 4 nanoparticles on reduced graphene oxide for high performance ethanol sensor

Abstract Developing novel metal oxide semiconductor (MOS) gas-sensing materials with high performance has attracted much attention in the field of gas sensor. In this work, Zn2SnO4 nanoparticles/reduced graphene oxide (ZTO/RGO) nanocomposites with various contents of RGO were successfully synthesized via a solvothermal method combined with subsequent annealing process. Through the present method, ZTO nanoparticles with the size about 20 nm were in situ decorated on the surface of RGO nanosheets. The results of gas-sensing tests indicated that the as-prepared ZTO/RGO showed an enhanced sensing performance to ethanol in comparison with pure ZTO. The response of the sensor fabricated with 8ZTO/RGO (with the optimal mass ratio of ZTO:RGO = 8:1) to 100 ppm ethanol at the optimal operating temperature of 275 °C is as high as 38, which is about 6 times higher than that of the bare ZTO sensor. Besides of high sensitivity, the 8ZTO/RGO sensor also showed impressive selectivity and fast response/recover behavior, as well as good linearity in a relatively wide range of ethanol concentration (5–1200 ppm). These good sensing characteristics make 8ZTO/RGO a promising candidate for practically detecting ethanol. The gas-sensing mechanism of the composite to ethanol was also discussed in detail.

[1]  Y. Guan,et al.  Cu2O nanorods modified by reduced graphene oxide for NH3 sensing at room temperature , 2015 .

[2]  Y. Mortazavi,et al.  Highly enhanced response and selectivity of electrospun ZnO-doped SnO2 sensors to ethanol and CO in presence of CH4 , 2013 .

[3]  Feng Liu,et al.  Acetone gas sensors based on graphene-ZnFe2O4 composite prepared by solvothermal method , 2013 .

[4]  Zheng Lou,et al.  Ethanol Gas Detection Using a Yolk-Shell (Core-Shell) α-Fe2O3 Nanospheres as Sensing Material. , 2015, ACS applied materials & interfaces.

[5]  Yanli Liu,et al.  One-step synthesis of 3D flower-like Zn2SnO4 hierarchical nanostructures and their gas sensing properties , 2015 .

[6]  S. Liang,et al.  Zn2SnO4/graphene composites as anode materials for high performance lithium-ion batteries , 2017 .

[7]  Liang Li,et al.  Fabrication and characterization of polliwog-like Sn/Zn2SnO4 heterostructure nanocrystal and their gas sensing properties , 2013 .

[8]  Xin Wang,et al.  Synthesis of α-Fe2O3 with the aid of graphene and its gas-sensing property to ethanol , 2015 .

[9]  Yan Li,et al.  Synthesis of Zn2SnO4 via a co-precipitation method and its gas-sensing property toward ethanol , 2015 .

[10]  Jianliang Cao,et al.  Synthesis and improved gas sensing properties of NiO-decorated SnO2 microflowers assembled with porous nanorods , 2016 .

[11]  Dongzhi Zhang,et al.  Facile fabrication of ZnO nanocrystalline-modified graphene hybrid nanocomposite toward methane gas sensing application , 2015, Journal of Materials Science: Materials in Electronics.

[12]  Xueling Gao,et al.  Zn2SnO4-doped SnO2 hollow spheres for phenylamine gas sensor application , 2017 .

[13]  Yan Li,et al.  Ethanol gas-sensing characteristic of the Zn2SnO4 nanospheres , 2016 .

[14]  Nan Qin,et al.  The crystal facet-dependent gas sensing properties of ZnO nanosheets: Experimental and computational study , 2017 .

[15]  Jin Xu,et al.  Controllable Evolution of Dual Defect Zni and VO Associate-Rich ZnO Nanodishes with (0001) Exposed Facet and Its Multiple Sensitization Effect for Ethanol Detection. , 2017, ACS applied materials & interfaces.

[16]  Chao Chen,et al.  Rapid synthesis of rGO–MoO3 hybrids and mechanism of enhancing sensing performance to H2S , 2015 .

[17]  S. S. Kim,et al.  Synthesis and gas sensing performance of ZnO–SnO2 nanofiber–nanowire stem-branch heterostructure , 2013 .

[18]  S. R. Silva,et al.  From 1D and 2D ZnO nanostructures to 3D hierarchical structures with enhanced gas sensing properties. , 2014, Nanoscale.

[19]  Nan Qin,et al.  A biomimetic nest-like ZnO: Controllable synthesis and enhanced ethanol response , 2014 .

[20]  Wang Xinming,et al.  Synthesis, characterization and photocatalytic property of nano-sized Zn2SnO4 , 2002 .

[21]  Wei Yang,et al.  Synthesis of surface layered hierarchical octahedral-like structured Zn2SnO4/SnO2 with excellent sensing properties toward HCHO , 2017 .

[22]  Ling-Dong Sun,et al.  Control of ZnO Morphology via a Simple Solution Route , 2002 .

[23]  Linfeng Hu,et al.  One‐Step Hydrothermal Synthesis of 2D Hexagonal Nanoplates of α‐Fe2O3/Graphene Composites with Enhanced Photocatalytic Activity , 2014 .

[24]  Gwiy-Sang Chung,et al.  Low temperature acetylene gas sensor based on Ag nanoparticles-loaded ZnO-reduced graphene oxide hybrid , 2015 .

[25]  Changwen Hu,et al.  Novel Zn2SnO4 Hierarchical Nanostructures and Their Gas Sensing Properties toward Ethanol , 2011 .

[26]  Xiaoqing Li,et al.  Calcination-temperature-dependent gas-sensing properties of mesoporous α-Fe2O3 nanowires as ethanol sensors , 2017 .

[27]  H. Zeng,et al.  Polyhedral Zn2SnO4: Synthesis, enhanced gas sensing and photocatalytic performance , 2016 .

[28]  K. Govardhan,et al.  Metal/Metal Oxide Doped Semiconductor Based Metal Oxide Gas Sensors-A Review , 2016 .

[29]  Hoang Xuan Thanh,et al.  On-chip growth of single phase Zn2SnO4 nanowires by thermal evaporation method for gas sensor application , 2017 .

[30]  E. Alarousu,et al.  Fast Crystallization and Improved Stability of Perovskite Solar Cells with Zn2SnO4 Electron Transporting Layer: Interface Matters. , 2015, ACS applied materials & interfaces.

[31]  C. Lee,et al.  In situ and ex situ carbon coated Zn2SnO4 nanoparticles as promising negative electrodes for Li-ion batteries , 2015 .

[32]  S. Akbar,et al.  Gas sensing properties of zinc stannate (Zn2SnO4) nanowires prepared by carbon assisted thermal evaporation process , 2015 .

[33]  Xiaoyan Hu,et al.  Ethanol gas sensing performance of Zn2SnO4 nanopowder prepared via a hydrothermal route with different solution pH values , 2015 .

[34]  Bowen Yao,et al.  An improved Hummers method for eco-friendly synthesis of graphene oxide , 2013 .

[35]  Hongyu Guan,et al.  Honeycombed SnO2 with ultra sensitive properties to H2 , 2013 .