Modeling a Passive Cooling System for Photovoltaic Cells Under Concentration

Cooling of photovoltaic cells under high intensity solar irradiance is a major concern when designing concentrating photovoltaic systems. The cell temperature will increase if the waste heat is not removed and the cell voltage/power will decrease with increasing cell temperature. This paper presents an analysis of the passive cooling system on the Amonix high concentration photovoltaic system (HCPV). The concentrator geometry is described. A model of the HCPV passive cooling system was made using Gambit. Assumptions are discussed that were made to create the numerical model based on the actual system, the methods for drawing the model is discussed, and images of the model are shown. Fluent was used to compute the numerical results. In addition to the theoretical results that were computed, measurements were made on a system in the field. These data are compared to the theoretical data and differences are calculated. Theoretical conditions that were studied included uniform cell temperatures and worst case weather scenarios, i.e., no wind, high ambient conditions, and high solar irradiance. The performance of the Amonix high concentrating system could be improved if more waste heat were removed from the cell. Now that a theoretical model has been developed and verified, it will be used to investigate different designs and material for increasing the cooling of the system.Copyright © 2007 by ASME

[1]  D. L. Evans,et al.  Cost studies on terrestrial photovoltaic power systems with sunlight concentration , 1977 .

[2]  K. Araki,et al.  Super high-efficiency multi-junction and concentrator solar cells , 2006 .

[3]  V. Garboushian,et al.  Long term reliability of mass-produced high-efficiency silicon point-contact solar cells under 250/spl times/ concentration , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[4]  M. W. Edenburn,et al.  Low-cost, high-performance, point-focus concentrator array design , 1980 .

[5]  M. W. Edenburn,et al.  Photovoltaic Concentrator Technology in the USA , 1982 .

[6]  C. Dey,et al.  Cooling of photovoltaic cells under concentrated illumination: a critical review , 2005 .

[7]  S. R. Dhariwal,et al.  Thermal non-uniformities in concentrator solar cells , 1984 .

[8]  Tapas K. Mallick,et al.  Using air flow to alleviate temperature elevation in solar cells within asymmetric compound parabolic concentrators , 2007 .

[9]  L. W. Florschuetz.  On heat rejection from terrestrial solar cell arrays with sunlight concentration , 1975 .

[10]  R. M. Swanson,et al.  Silicon point contact concentrator solar cells , 1985, IEEE Electron Device Letters.

[11]  A. R. Moore,et al.  Design considerations for high‐intensity solar cells , 1977 .

[12]  D. L. Evans,et al.  Terrestrial concentrating photovoltaic power system studies , 1976 .

[13]  K. Araki,et al.  A simple passive cooling structure and its heat analysis for 500/spl times/ concentrator PV module , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[14]  J. J. Guerin,et al.  Autonomous photovoltaic converter with linear focusing concentrator , 1981 .

[15]  Rick Hurt,et al.  Operation and Performance of the Amonix High Concentration Photovoltaic System at the University of Nevada, Las Vegas During the Second Year of Operation , 2006 .

[16]  H. Card,et al.  A model of silicon solar cells for concentrator photovoltaic and photovoltaic/thermal system design , 1985 .

[17]  Aliakbar Akbarzadeh,et al.  Heat pipe-based cooling systems for photovoltaic cells under concentrated solar radiation , 1996 .

[18]  M. Pinar Mengüç,et al.  Thermal Radiation Heat Transfer , 2020 .

[19]  L. Clements,et al.  Thermal-electric performance analysis for actively cooled, concentrating photovoltaic systems , 1980 .

[20]  Antonio Luque,et al.  Solar Cells and Optics for Photovoltaic Concentration , 1989 .

[21]  M. W. Edenburn,et al.  Passive Cooling Measurements for a Concentrating Photovoltaic Array , 1981 .

[22]  Antonio Luque,et al.  Electric and thermal model for non-uniformly illuminated concentration cells , 1998 .

[23]  D. Pachon,et al.  Rating and modelling of concentrator systems , 2002, Conference Record of the Twenty-Ninth IEEE Photovoltaic Specialists Conference, 2002..

[24]  Tsukasa Takebayashi,et al.  Solar Energy System , 2001 .