Application of Computational Fluid Dynamics in Simulating Film Boiling of Cryogens

This paper presents a computational fluid dynamic (CFD) model, simulating film boiling based on Rayleigh–Taylor (R-T) instability, using the volume of fluid (VOF) method to track the liquid/vapor interface. Film boiling of cryogenic liquids (e.g., LNG and liquid nitrogen) is simulated to estimate the vapor generation rate during an accidental spill. The simulated heat fluxes were compared with heat fluxes obtained from Berenson and Klimenko correlations. The effects of wall superheats on the bubble generation frequency were studied. This study helps researchers to understand the physics of film boiling that are useful during the risk assessment of a cryogenic spill scenario. For example, it was found that the bubble released from the node and the antinode points between the consecutive bubble generations cycles do not follow the alternating nature under the realistic film boiling conditions. Therefore, empirical expressions assuming alternating bubble generation might be unsuitable for cryogenic vaporizat...

[1]  N. Zuber.  Hydrodynamic aspects of boiling heat transfer (thesis) , 1959 .

[2]  P. J. Berenson.  Film-Boiling Heat Transfer From a Horizontal Surface , 1961 .

[3]  E. Hosler.  Film Boiling on a Horizontal Plate , 1962 .

[4]  P. J. Berenson.  Experiments on pool-boiling heat transfer , 1962 .

[5]  V. Dhir,et al.  The taylor wave configuration during boiling from a flat plate , 1973 .

[6]  C. W. Hirt,et al.  Volume of fluid (VOF) method for the dynamics of free boundaries , 1981 .

[7]  V. V. Klimenko,et al.  Film boiling on a horizontal plate — new correlation , 1981 .

[8]  V. Klimenko,et al.  Film boiling on a horizontal plate—a supplementary communication , 1982 .

[9]  J. Brackbill,et al.  A continuum method for modeling surface tension , 1992 .

[10]  Vijay K. Dhir,et al.  Numerical Simulation of Saturated Film Boiling on a Horizontal Surface , 1997 .

[11]  M. Rudman.  INTERNATIONAL JOURNAL FOR NUMERICAL METHODS IN FLUIDS, VOL. 24, 671–691 (1997) VOLUME-TRACKING METHODS FOR INTERFACIAL FLOW CALCULATIONS , 2022 .

[12]  G. Son,et al.  Numerical Simulation of Film Boiling Near Critical Pressures With a Level Set Method , 1998 .

[13]  D. Juric,et al.  Computations of Boiling Flows , 1998 .

[14]  R. I. Issa,et al.  A Method for Capturing Sharp Fluid Interfaces on Arbitrary Meshes , 1999 .

[15]  S. Welch,et al.  A Volume of Fluid Based Method for Fluid Flows with Phase Change , 2000 .

[16]  S. George Bankoff,et al.  Nonlinear dynamics in horizontal film boiling , 1998, Journal of Fluid Mechanics.

[17]  D. Banerjee,et al.  Study of Subcooled Film Boiling on a Horizontal Disc: Part I—Analysis , 2001 .

[18]  V. Dhir.  Numerical Simulations of Pool-Boiling Heat Transfer , 2001 .

[19]  Samuel W. J. Welch,et al.  NUMERICAL COMPUTATION OF FILM BOILING INCLUDING CONJUGATE HEAT TRANSFER , 2002 .

[20]  G. Tryggvason,et al.  Computations of film boiling. Part II: multi-mode film boiling , 2004 .

[21]  Samuel W. J. Welch,et al.  Planar Simulation of Bubble Growth in Film Boiling in Near-Critical Water Using a Variant of the VOF Method , 2004 .

[22]  G. Tryggvason,et al.  Computations of film boiling. Part I: numerical method , 2004 .

[23]  Gaurav Tomar,et al.  Numerical simulation of bubble growth in film boiling using a coupled level-set and volume-of-fluid method , 2005 .

[24]  Frédéric Gibou,et al.  A level set based sharp interface method for the multiphase incompressible Navier-Stokes equations with phase change , 2007, J. Comput. Phys..

[25]  Samuel W. J. Welch,et al.  Direct simulation of film boiling including electrohydrodynamic forces , 2007 .

[26]  Gaurav Tomar,et al.  Two-phase electrohydrodynamic simulations using a volume-of-fluid approach , 2007, J. Comput. Phys..

[27]  Tom Spicer,et al.  United states regulations for siting LNG terminals: problems and potential. , 2007, Journal of hazardous materials.

[28]  Yanhua Yang,et al.  Numerical simulation of film boiling on a sphere with a volume of fluid interface tracking method , 2008 .

[29]  Gaurav Tomar,et al.  Multimode analysis of bubble growth in saturated film boiling , 2008 .

[30]  S. Hardt,et al.  Evaporation model for interfacial flows based on a continuum-field representation of the source terms , 2008, J. Comput. Phys..

[31]  Peter Stephan,et al.  CFD Simulation of Boiling Flows Using the Volume-of-Fluid Method within OpenFOAM , 2009 .

[32]  Tomoaki Kunugi,et al.  BRIEF REVIEW OF LATEST DIRECT NUMERICAL SIMULATION ON POOL AND FILM BOILING , 2012 .

[33]  Yi Liu,et al.  Laboratory scale analysis of the influence of different heat transfer mechanisms on liquid nitrogen vaporization rate , 2013 .

[34]  G. Biswas,et al.  Analysis of interfacial instability and multimode bubble formation in saturated boiling using coupled level set and volume-of-fluid approach , 2014 .

[35]  Yi Liu,et al.  Modeling of a cryogenic liquid pool boiling by CFD simulation , 2015 .