Waste tyre rubber as a secondary fuel for power plants

Approximately 1 billion waste tyres are generated worldwide each year, with the US producing 300 million and the EU 260 million tyres, representing an enormous waste management problem. At the same time, increasingly stringent emission control targets are being imposed on electric power generating plants. The development of science and technology for clean coal combustion is crucial for a sustainable environment which is dependent on a mix of energy production systems. In this pilot scale study we have shown that tyre rubber can be fired with pulverised coal and may have a role to play in co-firing configurations in full scale power plant boilers as wastes are beginning to feature in ‘fuel switching’ scenarios for CO2 mitigation. Utilisation of waste tyres in a coal combustion plant can, in one step, reduce NO emissions and recover energy from waste tyres, efficiently. Therefore, through this process, a problem waste stream is effectively utilised to help solve a major environmental pollution problem. We present data demonstrating reburning and co-firing configurations utilising waste tyre rubber. Low levels of NO emission (up to 80% reduction at reburning fuel fractions <12%th) can be achieved, when using a lower volatile South African coal as the primary fuel. The results for tyre reburning are compared with the performance of a suite of reburning fuels with differing volatile hydrocarbon contents. Direct co-firing of tyre with coal can also reduce NO levels but the degree of reduction is dependent on the reactivity of the coal and the prevailing combustion conditions in the primary zone of the mixed fuel flame.

[1]  Y. Inoue,et al.  Ground level ozone concentrations and its association with NOx and meteorological parameters in Kathmandu valley, Nepal , 2006 .

[2]  P. Glarborg,et al.  Low temperature interactions between hydrocarbons and nitric oxide: An experimental study , 1997 .

[3]  L. A. Ruth.  The U.S. Department of Energy's Combustion 2000 program: Clean, efficient electricity from coal , 1997 .

[4]  Gordon McKay,et al.  Production of activated carbons from waste tire--process design and economical analysis. , 2004, Waste management.

[5]  T. Muneer,et al.  Energy supply, its demand and security issues for developed and emerging economies , 2007 .

[6]  B. Adams,et al.  Reburning using biomass for NOx control , 1998 .

[7]  B. M. Gibbs,et al.  Optimisation of NOx reduction in advanced coal reburning systems and the effect of coal type , 2003 .

[8]  Loc Ho,et al.  Alternative fuel reburning , 1999 .

[9]  I. Marco,et al.  Chromatographic analysis of the gases obtained in tyre pyrolysis , 2000 .

[10]  Craig A. Penterson,et al.  Minimize NOx using only combustion control : Burning PRB Coal , 2005 .

[11]  M. Costa,et al.  THE EFFECTIVENESS OF REBURNING USING RICE HUSK AS SECONDARY FUEL FOR NO X REDUCTION IN A FURNACE , 2005 .

[12]  Denise L. Mauzerall,et al.  NOx emissions from large point sources : variability in ozone production, resulting health damages and economic costs , 2004 .

[13]  J. Smart,et al.  The effectiveness of multi-fuel reburning in an internally fuel-staged burner for NOx reduction , 1994 .

[14]  Paul T. Williams,et al.  Composition of oils derived from the batch pyrolysis of tyres , 1998 .

[15]  Klaus R. G. Hein,et al.  Basic effects on NOx emissions in air staging and reburning at a bench-scale test facility , 1996 .

[16]  H. Spliethoff,et al.  The effect of different reburning fuels on NOx-reduction , 1994 .

[17]  Paul T. Williams,et al.  The evaluation of waste tyre pulverised fuel for NOx reduction by reburning , 2008 .

[18]  R. Bilbao,et al.  Evaluation of the use of different hydrocarbon fuels for gas reburning , 1997 .

[19]  G. C. Hunter,et al.  Power-station contributions to local concentrations of NO2 at ground level , 1998 .

[20]  David A. Tillman,et al.  Cofiring multiple opportunity fuels with coal at Bailly Generating Station , 2000 .