Algaculture integration in conventional wastewater treatment plants: anaerobic digestion comparison of primary and secondary sludge with microalgae biomass.

This study evaluated the feasibility of using microalgae biomass as feedstock for anaerobic digestion together with other biomasses (primary and secondary sludge) normally generated in WWTP. Raw microalgae biomass anaerobic biodegradability (33%) was higher than that of secondary sludge (23%). Thermal pretreatment enhanced 62% and 16% methane yield for Chlorellavulgaris and secondary sludge, respectively. When both substrates were codigested, methane yields remained low. On the other hand, primary sludge supported the highest anaerobic biodegradability (97%) and when combined with thermally pretreated C. vulgaris, methane yields were higher (13-17%) than the ones expected theoretically. Despite the high protein content of those substrates and the high nitrogen mineralization, no ammonia inhibition was detected. Thereby, this study showed that algae biomass is a potential cosubstrate for biogas production together with municipal wastewater sludge.

[1]  Hariklia N Gavala,et al.  Mesophilic and thermophilic anaerobic digestion of primary and secondary sludge. Effect of pre-treatment at elevated temperature. , 2003, Water research.

[2]  Y. Chisti,et al.  Protein measurements of microalgal and cyanobacterial biomass. , 2010, Bioresource technology.

[3]  P. Spolaore,et al.  Commercial applications of microalgae. , 2006, Journal of bioscience and bioengineering.

[4]  Beatriz Molinuevo-Salces,et al.  Nitrogen transformations under different conditions in open ponds by means of microalgae-bacteria consortium treating pig slurry. , 2011, Bioresource technology.

[5]  Eric Latrille,et al.  Estimating anaerobic biodegradability indicators for waste activated sludge , 2010 .

[6]  H. Carrère,et al.  Pretreatment methods to improve sludge anaerobic degradability: a review. , 2010, Journal of hazardous materials.

[7]  P. Champagne,et al.  Enzymatic hydrolysis of cellulosic municipal wastewater treatment process residuals as feedstocks for the recovery of simple sugars. , 2009, Bioresource technology.

[8]  Jakob Magid,et al.  Application of processed organic municipal solid waste on agricultural land – a scenario analysis , 2006 .

[9]  Beatriz Molinuevo-Salces,et al.  Evaluation of anaerobic codigestion of microalgal biomass and swine manure via response surface methodology , 2011 .

[10]  M. Wang,et al.  Anaerobic co-digestion of microalgae Chlorella sp. and waste activated sludge. , 2013, Bioresource technology.

[11]  W. Oswald.  Ponds in the twenty-first century , 1995 .

[12]  J P Steyer,et al.  Effect of organic loading rate on anaerobic digestion of thermally pretreated Scenedesmus sp. biomass. , 2013, Bioresource technology.

[13]  Roland Span,et al.  Anaerobic co-digestion of the marine microalga Nannochloropsis salina with energy crops. , 2013, Bioresource technology.

[14]  J. L. Ramos-Suárez,et al.  Optimization of the digestion process of Scenedesmus sp. and Opuntia maxima for biogas production , 2014 .

[15]  Cristina González-Fernández,et al.  Effect of high pressure thermal pretreatment on Chlorella vulgaris biomass: Organic matter solubilisation and biochemical methane potential , 2014 .

[16]  A. Shilton,et al.  Luxury uptake of phosphorus by microalgae in waste stabilisation ponds: current understanding and future direction , 2014, Reviews in Environmental Science and Bio/Technology.

[17]  M. Ballesteros,et al.  Protease cell wall degradation of Chlorella vulgaris: effect on methane production. , 2014, Bioresource technology.

[18]  U. Neis,et al.  Bioflocculent algal-bacterial biomass improves low-cost wastewater treatment. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[19]  F. Smith,et al.  Colorimetric Method for Determination of Sugars and Related Substances , 1956 .

[20]  A. Gianico,et al.  Reduced temperature hydrolysis at 134 °C before thermophilic anaerobic digestion of waste activated sludge at increasing organic load. , 2013, Bioresource technology.

[21]  M. Ballesteros,et al.  Enhanced methane production of Chlorella vulgaris and Chlamydomonas reinhardtii by hydrolytic enzymes addition , 2014 .

[22]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[23]  Eric P. Knoshaug,et al.  Enzymatic cell wall degradation of Chlorellavulgaris and other microalgae for biofuels production , 2012, Planta.

[24]  Cristina González-Fernández,et al.  Enhancing methane production of Chlorella vulgaris via thermochemical pretreatments. , 2013, Bioresource technology.

[25]  Pinjing He,et al.  Comparison of sludge digestion under aerobic and anaerobic conditions with a focus on the degradation of proteins at mesophilic temperature. , 2013, Bioresource technology.

[26]  N. Bernet,et al.  Experimental study on a coupled process of production and anaerobic digestion of Chlorella vulgaris. , 2011, Bioresource technology.

[27]  M. Fdz-Polanco,et al.  Continuous thermal hydrolysis and energy integration in sludge anaerobic digestion plants. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[28]  M. Ballesteros,et al.  Methane production of thermally pretreated Chlorella vulgaris and Scenedesmus sp. biomass at increasing biomass loads , 2014 .

[29]  Ziglio Giuliano,et al.  Effects of sonication on bacteria viability in wastewater treatment plants evaluated by flow cytometry--fecal indicators, wastewater and activated sludge. , 2007, Water research.

[30]  Yebo Li,et al.  Evaluation of methane production and macronutrient degradation in the anaerobic co-digestion of algae biomass residue and lipid waste. , 2012, Bioresource technology.

[31]  J. Degrève,et al.  Influence of low temperature thermal pre-treatment on sludge solubilisation, heavy metal release and anaerobic digestion. , 2010, Bioresource technology.

[32]  N. Bernet,et al.  Thermal pretreatment to improve methane production of Scenedesmus biomass , 2012 .