NOM and TEP fouling of a forward osmosis (FO) membrane: Foulant identification and cleaning

Abstract The study of forward osmosis (FO) membranes has increased due to the already demonstrated advantages compared to high-energy membrane processes such as reverse osmosis (RO). This research focuses on characterization of the natural organic matter (NOM) fraction causing fouling on the active layer (AL) of a FO membrane in a novel plate and frame module configuration, facing secondary wastewater effluent as a feed solution (FS) and seawater used as a draw solution (DS). In addition, transparent exopolymer particles (TEP) were observed on the support layer (SL) of the membrane in contact with the DS. The NOM fouling layer, after characterizing the water samples and membranes used, was found to be composed of biopolymers and protein-like substances, which adversely affect the flux of water through the FO membrane. However, NOM fouling showed high reversibility, up to 90% when air scouring for 15 min is used as a cleaning technique. The irreversible fouling in this work was found to be 8.2% after chemical cleaning. On the support layer of the membrane, TEP formed clusters clearly identifiable with an optical microscope and a TEP-specific dye. Chemical cleaning with 1% NaOCl for 10 min proved to be the most effective method to remove TEP.

[1]  Tong Zhan,et al.  Flux patterns and membrane fouling propensity during desalination of seawater by forward osmosis. , 2012, Water research.

[2]  Menachem Elimelech,et al.  High performance thin-film composite forward osmosis membrane. , 2010, Environmental science & technology.

[3]  Jean-Philippe Croué,et al.  Identification and understanding of fouling in low-pressure membrane (MF/UF) filtration by natural organic matter (NOM). , 2004, Water research.

[4]  Anthony G Fane,et al.  Direct microscopic observation of forward osmosis membrane fouling. , 2010, Environmental science & technology.

[5]  I. Pinnau,et al.  Fouling of reverse osmosis membranes by biopolymers in wastewater secondary effluent: Role of membrane surface properties and initial permeate flux , 2007 .

[6]  T. Berman,et al.  Transparent exopolymer particles (TEP): A critical factor in aquatic biofilm initiation and fouling on filtration membranes , 2011 .

[7]  Victor Yangali-Quintanilla,et al.  Rejection of micropollutants by clean and fouled forward osmosis membrane. , 2011, Water research.

[8]  Zhenyu Li,et al.  Indirect desalination of Red Sea water with forward osmosis and low pressure reverse osmosis for water reuse , 2011 .

[9]  Chuyang Y. Tang,et al.  Coupled effects of internal concentration polarization and fouling on flux behavior of forward osmosis membranes during humic acid filtration , 2010 .

[10]  W. Pronk,et al.  Characterisation of aquatic humic and non-humic matter with size-exclusion chromatography--organic carbon detection--organic nitrogen detection (LC-OCD-OND). , 2011, Water research.

[11]  Menachem Elimelech,et al.  Chemical and physical aspects of organic fouling of forward osmosis membranes , 2008 .

[12]  Menachem Elimelech,et al.  Comparison of fouling behavior in forward osmosis (FO) and reverse osmosis (RO) , 2010 .

[13]  Jaeweon Cho,et al.  Membrane filtration of natural organic matter: factors and mechanisms affecting rejection and flux decline with charged ultrafiltration (UF) membrane , 2000 .

[14]  T. Berman,et al.  Transparent exopolymer particles: Potential agents for organic fouling and biofilm formation in desalination and water treatment plants , 2009 .

[15]  D.J.H. Harmsen,et al.  Membrane fouling and process performance of forward osmosis membranes on activated sludge , 2008 .

[16]  Tzahi Y Cath,et al.  Forward osmosis for concentration of anaerobic digester centrate. , 2007, Water research.

[17]  Menachem Elimelech,et al.  Chemical and physical aspects of natural organic matter (NOM) fouling of nanofiltration membranes , 1997 .

[18]  M. Elimelech,et al.  Organic fouling of forward osmosis membranes: Fouling reversibility and cleaning without chemical reagents , 2010 .

[19]  Xiao-yan Li,et al.  Accumulation of biopolymer clusters in a submerged membrane bioreactor and its effect on membrane fouling. , 2008, Water research.

[20]  Viatcheslav Freger,et al.  Chemical cleaning of UF membranes fouled by BSA , 2005 .

[21]  J. McCutcheon,et al.  Internal concentration polarization in forward osmosis: role of membrane orientation , 2006 .

[22]  G. Amy,et al.  The fate of Transparent Exopolymer Particles (TEP) in integrated membrane systems: removal through pre-treatment processes and deposition on reverse osmosis membranes. , 2009, Water research.

[23]  C. D. Lundin,et al.  A multi-barrier osmotic dilution process for simultaneous desalination and purification of impaired water , 2010 .