Temperature phased anaerobic digestion increases apparent hydrolysis rate for waste activated sludge.

It is well established that waste activated sludge with an extended sludge age is inherently slow to degrade with a low extent of degradation. Pre-treatment methods can be used prior to anaerobic digestion to improve the efficiency of activated sludge digestion. Among these pre-treatment methods, temperature phased anaerobic digestion (TPAD) is one promising method with a relatively low energy input and capital cost. In this study, an experimental thermophilic (50-70 °C)-mesophilic system was compared against a control mesophilic-mesophilic system. The thermophilic-mesophilic system achieved 41% and 48% volatile solids (VS) destruction during pre-treatment of 60 °C and 65 °C (or 70 °C) respectively, compared to 37% in the mesophilic-mesophilic TPAD system. Solubilisation in the first stage was enhanced during thermophilic pre-treatment (15% at 50 °C and 27% at 60 °C, 65 °C and 70 °C) over mesophilic pre-treatment (7%) according to a COD balance. This was supported by ammonia-nitrogen measurements. Model based analysis indicated that the mechanism for increased performance was due to an increase in hydrolysis coefficient under thermophilic pre-treatment of 60 °C (0.5 ± 0.1 d(-1)), 65 °C (0.7 ± 0.2 d(-1)) and 70 °C (0.8 ± 0.2 d(-1)) over mesophilic pre-treatment (0.2 ± 0.1 d(-1)), and thermophilic pre-treatment at 50 °C (0.12 ± 0.06 d(-1)).

[1]  Adriana Artola,et al.  Effects of thermal and mechanical pretreatments of secondary sludge on biogas production under thermophilic conditions , 2007 .

[2]  Ulf Jeppsson,et al.  An ASM/ADM model interface for dynamic plant-wide simulation. , 2009, Water research.

[3]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[4]  M. Switzenbaum,et al.  Relationship Between the Van Kleeck and Mass‐Balance Calculation of Volatile Solids Loss , 2003, Water environment research : a research publication of the Water Environment Federation.

[5]  John T. Pfeffer,et al.  Temperature effects on anaerobic fermentation of domestic refuse , 1974 .

[6]  Samir Kumar Khanal,et al.  Ultrasound Applications in Wastewater Sludge Pretreatment: A Review , 2007 .

[7]  Damien J Batstone,et al.  Anaerobic digestion of spent bedding from deep litter piggery housing. , 2009, Bioresource technology.

[8]  Richard R. Dague,et al.  Laboratory studies on the temperature‐phased anaerobic digestion of domestic primary sludge , 1997 .

[9]  J. Gossett,et al.  Anaerobic Digestion of Waste Activated Sludge , 1982 .

[10]  D. Batstone,et al.  Pre-treatment mechanisms during thermophilic-mesophilic temperature phased anaerobic digestion of primary sludge. , 2010, Water research.

[11]  Jing Liu,et al.  Effects of anaerobic pre-treatment on the degradation of dewatered-sewage sludge , 2009 .

[12]  D J Batstone,et al.  Kinetics of thermophilic, anaerobic oxidation of straight and branched chain butyrate and valerate , 2003, Biotechnology and bioengineering.

[13]  W. Clarke,et al.  Concurrent microscopic observations and activity measurements of cellulose hydrolyzing and methanogenic populations during the batch anaerobic digestion of crystalline cellulose. , 2005, Biotechnology and bioengineering.

[14]  S. Ghosh.  Kinetics of acid-phase fermentation in anaerobic digestion , 1981 .

[15]  P. Pavan,et al.  Two-Phase Anaerobic Digestion of Waste Activated Sludge: Effect of an Extreme Thermophilic Prefermentation , 2007 .

[16]  Irini Angelidaki,et al.  Acetate Oxidation Is the Dominant Methanogenic Pathway from Acetate in the Absence of Methanosaetaceae , 2006, Applied and Environmental Microbiology.

[17]  J. Keller,et al.  Two-stage thermophilic-mesophilic anaerobic digestion of waste activated sludge from a biological nutrient removal plant. , 2006, Water science and technology : a journal of the International Association on Water Pollution Research.

[18]  G. Zupančič,et al.  Thermophilic anaerobic digestion of waste activated sludge , 2003 .

[19]  Stephen H. Zinder,et al.  Effects of Temperature on Methanogenesis in a Thermophilic (58°C) Anaerobic Digestor , 1984 .

[20]  D J Batstone,et al.  Estimation of hydrolysis parameters in full-scale anerobic digesters. , 2009, Biotechnology and bioengineering.

[21]  Irini Angelidaki,et al.  Influence of Environmental Conditions on Methanogenic Compositions in Anaerobic Biogas Reactors , 2022 .