Reductions in emissions of carbonaceous particulate matter and polycyclic aromatic hydrocarbons from combustion of biomass pellets in comparison with raw fuel burning.

Biomass pellets are emerging as a cleaner alternative to traditional biomass fuels. The potential benefits of using biomass pellets include improving energy utilization efficiency and reducing emissions of air pollutants. To assess the environmental, climate, and health significance of replacing traditional fuels with biomass pellets, it is critical to measure the emission factors (EFs) of various pollutants from pellet burning. However, only a few field measurements have been conducted on the emissions of carbon monoxide (CO), particulate matter (PM), and polycyclic aromatic hydrocarbons (PAHs) from the combustion of pellets. In this study, pine wood and corn straw pellets were burned in a pellet burner (2.6 kW), and the EFs of CO, organic carbon, elemental carbon, PM, and PAHs (EF(CO), EF(OC), EF(EC), EF(PM), and EF(PAH)) were determined. The average EF(CO), EF(OC), EF(EC), and EF(PM) were 1520 ± 1170, 8.68 ± 11.4, 11.2 ± 8.7, and 188 ± 87 mg/MJ for corn straw pellets and 266 ± 137, 5.74 ± 7.17, 2.02 ± 1.57, and 71.0 ± 54.0 mg/MJ for pine wood pellets, respectively. Total carbonaceous carbon constituted 8 to 14% of the PM mass emitted. The measured values of EF(PAH) for the two pellets were 1.02 ± 0.64 and 0.506 ± 0.360 mg/MJ, respectively. The secondary side air supply in the pellet burner did not change the EFs of most pollutants significantly (p > 0.05). The only exceptions were EF(OC) and EF(PM) for pine wood pellets because of reduced combustion temperatures with the increased air supply. In comparison with EFs for the raw pine wood and corn straw, EF(CO), EF(OC), EF(EC), and EF(PM) for pellets were significantly lower than those for raw fuels (p < 0.05). However, the differences in EF(PAH) were not significant (p > 0.05). Based on the measured EFs and thermal efficiencies, it was estimated that 95, 98, 98, 88, and 71% reductions in the total emissions of CO, OC, EC, PM, and PAHs could be achieved by replacing the raw biomass fuels combusted in traditional cooking stoves with pellets burned in modern pellet burners.

[1]  Christoffer Boman,et al.  Stove performance and emission characteristics in residential wood log and pellet combustion : Part 2: Wood stove , 2011 .

[2]  Sara Janhäll,et al.  Biomass burning aerosol emissions from vegetation fires: particle number and mass emission factors and size distributions , 2009 .

[3]  G. Schoenau,et al.  Compaction characteristics of barley, canola, oat and wheat straw , 2009 .

[4]  Joakim Pagels,et al.  Health effects of residential wood smoke particles: the importance of combustion conditions and physicochemical particle properties , 2009, Particle and Fibre Toxicology.

[5]  Zhao Lixin,et al.  Effects comparison on anti-slagging additives of corn straw biomass pellet fuel. , 2010 .

[6]  Christoffer Boman,et al.  Biomass combustion in residential heating : particulate measurements, sampling and physiochemical and toxicological characterisation , 2008 .

[7]  Viktor Popov,et al.  A review of European standards for pellet quality , 2011 .

[8]  Maria E. Olsson,et al.  Specific chimney emissions and biofuel characteristics of softwood pellets for residential heating in Sweden. , 2003 .

[9]  John S. Kinsey,et al.  Polycyclic aromatic hydrocarbon size distributions in aerosols from appliances of residential wood combustion as determined by direct thermal desorption—GC/MS , 2003 .

[10]  Thomas Nussbaumer,et al.  Particulate Emissions from Biomass Combustion in IEA Countries Survey on Measurements and Emission Factors. , 2008 .

[11]  Ralf Zimmermann,et al.  On-line analysis of the size distribution of fine and ultrafine aerosol particles in flue and stack gas of a municipal waste incineration plant: effects of dynamic process control measures and emission reduction devices. , 2003, Environmental science & technology.

[12]  B. Leckner,et al.  Emission characteristics of modern and old-type residential boilers fired with wood logs and wood pellets , 2004 .

[13]  Stellan Marklund,et al.  Emission of PCDD/F, PCB, and HCB from combustion of firewood and pellets in residential stoves and boilers. , 2006, Environmental Science and Technology.

[14]  D. Streets,et al.  A technology‐based global inventory of black and organic carbon emissions from combustion , 2004 .

[15]  Li Xing,et al.  Renewable energy from agro-residues in China: Solid biofuels and biomass briquetting technology , 2009 .

[16]  Christoffer Boman,et al.  Characterization of inorganic particulate matter from residential combustion of pelletized biomass fuels , 2004 .

[17]  Jiming Hao,et al.  Revisiting China's CO emissions after the Transport and Chemical Evolution over the Pacific (TRACE-P) mission: Synthesis of inventories, atmospheric modeling, and observations , 2006 .

[18]  David G. Streets,et al.  Primary anthropogenic aerosol emission trends for China, 1990–2005 , 2011 .

[19]  C. R. Purvis,et al.  Fine Particulate Matter (PM) and Organic Speciation of Fireplace Emissions , 2000 .

[20]  S. Tao,et al.  Emission of polycyclic aromatic hydrocarbons in China. , 2006, Environmental science & technology.

[21]  L. Chen,et al.  PM2.5 source profiles for black and organic carbon emission inventories. , 2011 .

[22]  Thomas W. Kirchstetter,et al.  Origin of carbonaceous aerosols over the tropical Indian Ocean: Biomass burning or fossil fuels? , 2000 .

[23]  Candis Claiborn,et al.  Particulate emissions from wheat and Kentucky bluegrass stubble burning in eastern Washington and northern Idaho , 2006 .

[24]  Zhao Lixin,et al.  Comparison on characterization effect of biomass pellet fuels on combustion behavior. , 2010 .

[25]  Judith C Chow,et al.  Measurement of Ultrafine Particle Size Distributions from Coal-, Oil-, and Gas-Fired Stationary Combustion Sources , 2004, Journal of the Air & Waste Management Association.

[26]  E. Feil,et al.  Climate Effects of Black Carbon Aerosols in China and India , 2002 .

[27]  Dan Boström,et al.  Slagging Characteristics during Combustion of Corn Stovers with and without Kaolin and Calcite , 2008 .

[28]  Risto Hillamo,et al.  Physicochemical characterization of fine particles from small-scale wood combustion , 2010 .

[29]  H. Wiinikka.  High temperature aerosol formation and emission minimisation during combustion of wood pellets , 2005 .

[30]  Wei Li,et al.  Emissions of PAHs from indoor crop residue burning in a typical rural stove: emission factors, size distributions, and gas-particle partitioning. , 2011, Environmental science & technology.

[31]  Linda Bäfver,et al.  Particle emissions from pellets stoves and modern and old-type wood stoves. , 2011 .

[32]  Kirk R. Smith,et al.  Household Air Pollution from Coal and Biomass Fuels in China: Measurements, Health Impacts, and Interventions , 2007, Environmental health perspectives.

[33]  S. Tao,et al.  Atmospheric polycyclic aromatic hydrocarbons in north China: a winter-time study. , 2007, Environmental science & technology.

[34]  Chang-Yu Wu,et al.  Combustion Aerosols: Factors Governing Their Size and Composition and Implications to Human Health , 2000, Journal of the Air & Waste Management Association.

[35]  Jennica Kjällstrand,et al.  Emissions from burning of softwood pellets , 2004 .

[36]  Zhang Yanyan,et al.  Emission factors, size distributions, and emission inventories of carbonaceous particulate matter from residential wood combustion in rural China. , 2012, Environmental science & technology.

[37]  Thomas W. Kirchstetter,et al.  Emissions of trace gases and aerosols during the open combustion of biomass in the laboratory , 2009 .

[38]  M. Perzon.  Emissions of organic compounds from the combustion of oats - a comparison with softwood pellets , 2010 .

[39]  Vida N. Sharifi,et al.  Comparison of Emission Characteristics of Small-Scale Heating Systems Using Biomass Instead of Coal , 2010 .

[40]  Frank Fiedler,et al.  The state of the art of small-scale pellet-based heating systems and relevant regulations in Sweden, Austria and Germany , 2004 .

[41]  Ge Peng,et al.  Particulate and gaseous emissions from manually and automatically fired small scale combustion systems , 2011 .

[42]  S. Tao,et al.  Global atmospheric emission inventory of polycyclic aromatic hydrocarbons (PAHs) for 2004 , 2009 .

[43]  Yan Yong-lin.  Problems and countermeasures in application and development of the biomass pellet fuel in our country , 2005 .

[44]  J. Hansen,et al.  Climate Effects of Black Carbon Aerosols in China and India , 2002, Science.

[45]  S. Tao,et al.  Inhalation exposure to ambient polycyclic aromatic hydrocarbons and lung cancer risk of Chinese population , 2009, Proceedings of the National Academy of Sciences.

[46]  Z. Klimont,et al.  Primary emissions of fine carbonaceous particles in Europe , 2007 .

[47]  P. S. Praveen,et al.  Brown Clouds over South Asia: Biomass or Fossil Fuel Combustion? , 2009, Science.

[48]  Armistead G Russell,et al.  Emission factors of particulate matter and elemental carbon for crop residues and coals burned in typical household stoves in China. , 2010, Environmental science & technology.