Sorption-enhanced Fischer–Tropsch synthesis with continuous adsorbent regeneration in GTL technology: Modeling and optimization

Abstract Fischer–Tropsch synthesis (FTS) plays an important role in the production of clean liquid transportation fuels, chemicals, and other hydrocarbon products. This work proposes a novel configuration of FTS reactor in which zeolite 4A, with the composition of Na12(Si12Al12O48)·27H2O, is considered as water adsorbent. For this purpose, a gas-flowing solids-fixed bed reactor (GFSFBR) is used instead of conventional reactor. The main advantage of GFSFBR over the conventional sorption-enhanced reaction process is the continuous adsorbent regeneration in this novel configuration. Simulation result demonstrates that selective adsorption of water from FTS in GFSFBR leads to significant enhancement in the gasoline yield and reduction in CO2 production in comparison with the zero solid mass flux condition. Subsequently, the aforementioned reactor is optimized using differential evolution (DE) algorithm as an effective and robust optimization method. Optimization results show that there are optimum values for eight decision variables under which the highest gasoline productivity can be achieved. Afterwards, the simulation and optimization results are compared with the ones in conventional reactor. This paper shows how the concept of in situ water adsorption is feasible and beneficial for FTS.

[1]  S. Ledakowicz,et al.  Hydrocarbon selectivity model for the slurry phase Fischer–Tropsch synthesis on precipitated iron catalysts , 2001 .

[2]  C. H. Bartholomew,et al.  Fundamentals of Industrial Catalytic Processes , 2005 .

[3]  Hans Schulz,et al.  Short history and present trends of Fischer–Tropsch synthesis , 1999 .

[4]  Faïçal Larachi,et al.  Sorption-enhanced dimethyl ether synthesis—Multiscale reactor modeling , 2011 .

[5]  A. Erdem-Senatalar,et al.  Optimization of the cycle durations of adsorption heat pumps employing zeolite coatings synthesized on metal supports , 2000 .

[6]  Aacm Beenackers,et al.  Intra-particle diffusion limitations in low-pressure methanol synthesis , 1990 .

[7]  G. Schaub,et al.  Synthetic hydrocarbon fuels and CO2 utilization , 2004 .

[8]  Mohammad Reza Rahimpour,et al.  A comparative study of combination of Fischer–Tropsch synthesis reactors with hydrogen-permselective membrane in GTL technology , 2009 .

[9]  Morteza Sohrabi,et al.  Fischer‐Tropsch Synthesis: Modeling and Performance Study for Fe‐HZSM5 Bifunctional Catalyst , 2005 .

[10]  Don W. Green,et al.  Perry's Chemical Engineers' Handbook , 2007 .

[11]  M. Rahimpour,et al.  Simultaneous hydrogen injection and in-situ H2O removal in a novel thermally coupled two-membrane reactor concept for Fischer–Tropsch synthesis in GTL technology , 2012 .

[12]  Hongwei Xiang,et al.  Kinetic modeling of Fischer–Tropsch synthesis over Fe–Cu–K–SiO2Fe–Cu–K–SiO2 catalyst in slurry phase reactor , 2007 .

[13]  K. Hall.  A new gas to liquids (GTL) or gas to ethylene (GTE) technology , 2005 .

[14]  D. Do,et al.  Adsorption analysis : equilibria and kinetics , 1998 .

[15]  F. Kapteijn,et al.  Application of a sodalite membrane reactor in esterification—Coupling reaction and separation , 2010 .

[16]  R. Reid,et al.  The Properties of Gases and Liquids , 1977 .

[17]  F. Kapteijn,et al.  Fischer–Tropsch synthesis with in situ H2O removal – Directions of membrane development , 2008 .

[18]  Hongwei Xiang,et al.  Modeling of catalyst pellets for Fischer-Tropsch synthesis , 2001 .

[19]  M. M. Montazer Rahmati,et al.  RATE EQUATIONS FOR THE FISCHER-TROPSCH REACTION ON A PROMOTED IRON CATALYST , 2001 .

[20]  Gilbert F. Froment,et al.  Kinetics of the Fischer-Tropsch reaction on a precipitated promoted iron catalyst. 1. Experimental procedure and results , 1993 .

[21]  M. Khademi,et al.  Optimal conditions for hydrogen production from coupling of dimethyl ether and benzene synthesis , 2011 .

[22]  J. Fierro,et al.  Fischer–Tropsch synthesis on mono- and bimetallic Co and Fe catalysts in fixed-bed and slurry reactors , 2007 .

[23]  Behdad Moghtaderi,et al.  Genetic algorithm strategy (GA) for optimization of a novel dual-stage slurry bubble column membrane configuration for Fischer–Tropsch synthesis in gas to liquid (GTL) technology , 2011 .

[24]  N. Nikačević,et al.  Enhanced ammonia synthesis in multifunctional reactor with in situ adsorption , 2011 .

[25]  Mohammad Reza Rahimpour,et al.  A novel water perm-selective membrane dual-type reactor concept for Fischer–Tropsch synthesis of GTL (gas to liquid) technology , 2011 .

[26]  Mohammad Reza Rahimpour,et al.  Optimization of a novel combination of fixed and fluidized-bed hydrogen-permselective membrane reactors for Fischer–Tropsch synthesis in GTL technology , 2009 .

[27]  M. Menéndez,et al.  Use of membranes in fischer-tropsch reactors , 2000 .

[28]  Klaas R. Westerterp,et al.  Methanol synthesis in a countercurrent gas-solid-solid trickle flow reactor. An experimental study , 1987 .

[29]  Gilbert F. Froment,et al.  Kinetics of the Fischer-Tropsch reaction on a precipitated promoted iron catalyst. 2. Kinetic modeling , 1993 .

[30]  W. V. Swaaij,et al.  Hydrodynamic behaviour of a gas—solid counter-current packed column at trickle flow , 1979 .

[31]  F. Kapteijn,et al.  Water vapour separation from permanent gases by a zeolite-4A membrane , 2005 .

[32]  K. Kobe,et al.  Chemical engineering kinetics , 1956 .

[33]  Edward L Cussler,et al.  Diffusion: Mass Transfer in Fluid Systems , 1984 .