Aluminum oxide as a dielectric and passivation layer for (flexible) metal-oxide and 2D semiconductor devices

We discuss the role of aluminum oxide (i.e. Al2O3 when stoichiometric) for transistors and sensors based on oxide semiconductors such as InGaZnO (IGZO) and two-dimensional (2D) semiconductors, such as monolayer MoS2. Aluminum oxide is a well-known capping and dielectric layer in semiconductor technology typically deposited by atomic-layer deposition (ALD), which offers a dense and high-quality film with low gas permeability even when deposited on flexible substrates. However, when deposited at low temperature (< 200°C), aluminum oxide can include a significant amount of fixed charges and defects, which lead to unusual charge trapping and doping effects in semiconductor devices. For example, such charge trapping can cause (apparent) sub-60 mV/decade subthreshold swing at room temperature in IGZO transistors, but can also lead to potential applications in neuromorphic computing. We also discuss effective doping (~1013 cm-2) of 2D semiconductors by thin ALD-grown non-stoichiometric AlOx capping layers. This is achieved with an aluminum seed layer, which enables uniform growth of the subsequently deposited ALD film. This approach leads to a negative shift in threshold voltage, record on-state current (~700 μA/μm) in a monolayer semiconductor, and drastic reduction in contact resistance. Finally, we investigate the passivation effects of Al2O3 capping, which limits the interaction of the underlying semiconductors with ambient air and moisture. We demonstrate improved response in MoS2 temperature sensors and long-term stability in flexible MoS2 transistors (8 months). Further, we evaluate the effects of Al2O3 passivation on IGZO transistors after aging for 80 months.

[1]  Eric Pop,et al.  Approaching ballistic transport in monolayer MoS2 transistors with self-aligned 10 nm top gates , 2016, 2016 IEEE International Electron Devices Meeting (IEDM).

[2]  I. Radu,et al.  Nucleation and growth mechanisms of Al2O3 atomic layerdeposition on synthetic polycrystalline MoS2. , 2017, The Journal of chemical physics.

[3]  Gerhard Tröster,et al.  Photo-Induced Room-Temperature Gas Sensing with a-IGZO Based Thin-Film Transistors Fabricated on Flexible Plastic Foil , 2018, Sensors.

[4]  A. Franquet,et al.  Material-selective doping of 2D TMDC through AlxOy encapsulation. , 2019, ACS applied materials & interfaces.

[5]  J F Conley,et al.  Instabilities in Amorphous Oxide Semiconductor Thin-Film Transistors , 2010, IEEE Transactions on Device and Materials Reliability.

[6]  Pekka Soininen,et al.  Perfectly Conformal TiN and Al2O3 Films Deposited by Atomic Layer Deposition , 1999 .

[7]  Matthew T. Cole,et al.  Flexible Electronics: The Next Ubiquitous Platform , 2012, Proceedings of the IEEE.

[8]  K. Mistry,et al.  The High-k Solution , 2007, IEEE Spectrum.

[9]  S. George,et al.  Low-Temperature Al2O3 Atomic Layer Deposition , 2004 .

[10]  John Robertson,et al.  Oxygen vacancy levels and electron transport in Al2O3 , 2010 .

[11]  E. Pop,et al.  Uncovering the Effects of Metal Contacts on Monolayer MoS2. , 2020, ACS nano.

[12]  W. Kessels,et al.  From the Bottom-Up: Toward Area-Selective Atomic Layer Deposition with High Selectivity† , 2018, Chemistry of materials : a publication of the American Chemical Society.

[13]  V. Weisskopf,et al.  Effects of Configuration Interaction on Intensities and Phase Shifts , 2001 .

[14]  D. Farmer,et al.  Uniform Growth of Sub-5-Nanometer High-κ Dielectrics on MoS2 Using Plasma-Enhanced Atomic Layer Deposition. , 2017, ACS applied materials & interfaces.

[15]  Gerhard Tröster,et al.  Charge Trapping Mechanism Leading to Sub-60-mV/decade-Swing FETs , 2017, IEEE Transactions on Electron Devices.

[16]  G. Tröster,et al.  Ferroelectric‐Like Charge Trapping Thin‐Film Transistors and Their Evaluation as Memories and Synaptic Devices , 2017 .

[17]  G. Tröster,et al.  Long-Term Aging of Al2O3 Passivated and Unpassivated Flexible a-IGZO TFTs , 2020, IEEE Transactions on Electron Devices.

[18]  G. Tröster,et al.  Metal oxide semiconductor thin-film transistors for flexible electronics , 2016 .

[19]  A. Yanguas-Gil,et al.  Consistency and reproducibility in atomic layer deposition , 2020 .

[20]  Steven M. George,et al.  Ca test of Al2O3 gas diffusion barriers grown by atomic layer deposition on polymers , 2006 .

[21]  D. Briand,et al.  Synaptic transistors with aluminum oxide dielectrics enabling full audio frequency range signal processing , 2020, Scientific reports.

[22]  M. Lanza,et al.  Insulators for 2D nanoelectronics: the gap to bridge , 2020, Nature Communications.

[23]  Conor P. Cullen,et al.  Atomic layer deposition on 2D transition metal chalcogenides: layer dependent reactivity and seeding with organic ad-layers. , 2015, Chemical communications.

[24]  J. Robertson,et al.  High-K materials and metal gates for CMOS applications , 2015 .

[25]  Xinran Wang,et al.  Electrical characterization of back-gated bi-layer MoS2 field-effect transistors and the effect of ambient on their performances , 2012 .

[26]  E. Pop,et al.  Reduction of hysteresis in MoS2 transistors using pulsed voltage measurements , 2016, 2016 74th Annual Device Research Conference (DRC).

[27]  Steven M. George,et al.  Electrical characterization of thin Al2O3 films grown by atomic layer deposition on silicon and various metal substrates , 2002 .

[28]  Gerhard Tröster,et al.  Positive charge trapping phenomenon in n-channel thin-film transistors with amorphous alumina gate insulators , 2016 .

[29]  E. Pop,et al.  High Current Density in Monolayer MoS2 Doped by AlOx. , 2020, ACS nano.

[30]  Jhuma Gope,et al.  Influence of deposition temperature of thermal ALD deposited Al2O3 films on silicon surface passivation , 2015 .