Discussion on "Can water cause brittle fracture failures of non-ceramic insulators in the absence of electric field" [and reply]

It was postulated by J. Montesinos et al. (see ibid., vol.9, p.236-43, 2002), based on experimental evidence, that brittle fracture failures of composite (non-ceramic) HV insulators could be caused by water and mechanical stresses. It was also claimed therein that the brittle fracture process was more likely to happen with water than acids. This postulation could be of major importance as its ramifications might affect the entire composite insulator technology and, in particular, the usage of glass fiber polymer matrix composites in HV applications. Such an important statement should not be left without an independent verification. Therefore, attempts have been made in this research to initiate this process in unidirectional E-glass/modified polyester and E-glass/vinyl ester composites, used in non-ceramic insulators, by subjecting them to water under four-point bending conditions. This was done to independently verify the main conclusion of J. Montesinos et al. that water may be more damaging to unidirectional E-glass/polymer composites than acids. It has been clearly shown in this work that water, in the absence of electrical field, cannot cause stress corrosion cracking of unidirectional E-glass/polymer composites and thus brittle fracture of composite non-ceramic insulators. Thus the main results of J. Montesinos et al. could not be independently reproduced.

[1]  M. Kumosa,et al.  Causes and potential remedies of brittle fracture failure of composite (nonceramic) insulators , 2004, IEEE Transactions on Dielectrics and Electrical Insulation.

[2]  Maciej Kumosa,et al.  Acoustic emission from stress corrosion cracks in aligned GRP , 1987 .

[3]  Maciej Kumosa,et al.  Boron-free fibers for prevention of acid induced brittle fracture of composite insulator GRP rods , 2003 .

[4]  Maciej Kumosa,et al.  The Stress Corrosion Experiments on an E-Glass/Epoxy Unidirectional Composite , 2000 .

[5]  P. Spitéri,et al.  Durability of Closed-End Pressurized GRP Pipes under Hygrothermal Conditions. Part I: Monotonic Tests , 1996 .

[6]  H. Herman A Structural Materials: Properties, Microstructure and Processing. , 1995 .

[7]  Barzin Mobasher,et al.  Mechanism of brittle fracture in nonceramic insulators , 2002 .

[8]  M. Kumosa,et al.  Can water cause brittle fracture failures of composite non-ceramic insulators in the absence of electric fields? , 2004, IEEE Transactions on Dielectrics and Electrical Insulation.

[9]  A. Akhtar,et al.  Failure analysis of brittle fracture in nonceramic insulators , 1987 .

[10]  L. Pargamin,et al.  "Brittle fracture" of composite insulators: why and how they occur , 2000, 2000 Power Engineering Society Summer Meeting (Cat. No.00CH37134).

[11]  M. Kumosa,et al.  FTIR analysis of non-ceramic composite insulators , 2004, IEEE Transactions on Dielectrics and Electrical Insulation.

[12]  J. T. Burnham,et al.  Gunshot damage to ceramic and nonceramic insulators , 1997 .

[13]  R. Gorur,et al.  Brittle fracture in nonceramic insulators: electrical aspects of microscopic flaws in glass reinforced plastic (GRP) rods , 2002 .

[14]  P. Davies,et al.  Influence of mechanical stresses on the hydrolytic aging of standard and low styrene unsaturated polyester composites , 2002 .

[15]  Maciej Kumosa,et al.  An investigation of brittle fracture of composite insulator rods in an acid environment with either static or cyclic loading , 2000 .

[16]  David W. Lischer,et al.  The Durability of E-Glass/Vinyl Ester Composite Materials Subjected to Environmental Conditioning and Sustained Loading , 1998 .

[17]  Qiong Qiu Brittle fracture mechanisms of glass-fiber reinforced polymer insulators , 1995 .

[18]  Maciej Kumosa,et al.  Stress corrosion cracking in a unidirectional E-glass/polyester composite subjected to static and cyclic loading conditions , 2003 .

[19]  R. Gupta,et al.  Effect of Aging Environment on Degradation of Glass-Reinforced Epoxy , 2002 .

[20]  Maciej Kumosa,et al.  Chemical analysis of a field-failed composite suspension insulator , 1998 .

[21]  Y. Mai,et al.  Evaluation of Property Retention in E-Glass/Vinylester Composites after Exposure to Salt Solution and Natural Weathering , 2000 .

[22]  Maciej Kumosa,et al.  Brittle Fracture of Non-Ceramic Suspension Insulators with Epoxy Cone End-Fittings , 1997 .

[23]  Maciej Kumosa,et al.  Resistance to stress corrosion cracking of unidirectional ECR-glass/polymer composites for high voltage composite insulator applications , 2003 .

[24]  H. M. Schneider,et al.  Aging of non-ceramic insulators due to corona from water drops. Discussion , 1999 .

[25]  Maciej Kumosa,et al.  The Effect of Sandblasting on the Initiation of Stress Corrosion Cracking in Unidirectional E-Glass/Polymer Composites Used in High Voltage Composite (Non-Ceramic) Insulators , 2002 .

[26]  Maciej Kumosa,et al.  Stress corrosion of aligned glass fibre-polyester composite material , 1985 .

[27]  Maciej Kumosa,et al.  Initiation of Stress Corrosion Cracking in Unidirectional Glass/Polymer Composite Materials , 2001 .

[28]  Maciej Kumosa,et al.  ANALYSES OF COMPOSITE INSULATORS WITH CRIMPED END- FITTINGS: PART II - SUITABLE CRIMPING CONDITIONS , 2002 .

[29]  Maciej Kumosa,et al.  Evaluation of Stress Corrosion Properties of Pultruded Glass Fiber/Polymer Composite Materials , 2001 .

[30]  D. Dornfeld Book reviewAcoustic emission, vol. 2: edited by J. R. Matthews; published by Gordon and Breach, New York, 1983; 168 pp.; price, U.S. $39.50 , 1985 .

[31]  M. Kumosa,et al.  Resistance to brittle fracture of glass reinforced polymer composites used in composite (nonceramic) insulators , 2005, IEEE Transactions on Power Delivery.

[32]  Maciej Kumosa,et al.  Corrosion of E-glass fibers in acidic environments , 1997 .

[33]  Maciej Kumosa,et al.  Moisture absorption properties of unidirectional glass/polymer composites used in composite (non-ceramic) insulators , 2004 .

[34]  S. J. Harris,et al.  Failure of high voltage electrical insulators with pultruded glass fibre-reinforced plastic cores , 1986 .

[35]  S. J. Harris,et al.  Metallographic investigation of the damage caused to GRP by the combined action of electrical, mechanical and chemical environments , 1984 .

[36]  M. Kuhl FRP rods for brittle fracture resistant composite insulators , 2001 .

[37]  T. M. Damiani,et al.  Phenomenological Prediction of Tensile Strength of E-Glass Composites from Available Aging and Stress Corrosion Data , 2003 .

[38]  R. Gorur,et al.  Effect of long-term corona on non-ceramic outdoor insulator housing materials , 2001 .

[39]  M. Kumosa,et al.  Water diffusion into and electrical testing of composite insulator GRP rods , 2004, IEEE Transactions on Dielectrics and Electrical Insulation.

[40]  Maciej Kumosa,et al.  An investigation of brittle fracture in composite materials used for high voltage insulators , 1998 .

[41]  Maciej Kumosa,et al.  Analyses of composite insulators with crimped end-fittings: Part I—non linear finite element computations , 2002 .

[42]  Maciej Kumosa,et al.  Mechanical Evaluation of Axially Loaded Composite Insulators with Crimped End-Fittings , 1997 .

[43]  David W. Lischer,et al.  Mechanical and microstructural properties of notched E-glass/vinyl ester composite materials subjected to the environment and a sustained load , 2001 .

[44]  Maciej Kumosa,et al.  Finite element analysis of substation composite insulators , 1995 .

[45]  Barzin Mobasher,et al.  Mechanical aspects of crimped glass reinforced plastic (GRP) rods , 2003 .

[46]  Maciej Kumosa,et al.  Acoustic emission monitoring of stress corrosion cracks in aligned GRP , 1987 .

[47]  Maciej Kumosa,et al.  An evaluation of the critical conditions for the initiation of stress corrosion cracking in unidirectional E-glass/polymer composites , 2001 .

[48]  H. W. King,et al.  The aging of silicate glass surfaces in humid air , 1997 .

[49]  R. Gorur,et al.  Impact of corona on the long-term performance of nonceramic insulators , 2003, IEEE Transactions on Dielectrics and Electrical Insulation.

[50]  K. Liao,et al.  Influence of moisture-induced stress on in situ fiber strength degradation of unidirectional polymer composite , 2001 .

[51]  M. Shioya,et al.  The use of a single-fibre fragmentation test to study environmental durability of interfaces/interphases between DGEBA/mPDA epoxy and glass fibre: the effect of moisture , 1994 .

[52]  Maciej Kumosa,et al.  Resistance to Stress Corrosion Cracking of Unidirectional Glass/Polymer Composites Based on Low and High Seed ECR- glass Fibers for High Voltage Composite Insulator Applications , 2003 .

[53]  V. Karbhari,et al.  Low‐temperature hygrothermal degradation of ambient cured E‐glass/vinylester composites , 2002 .

[54]  S. J. Harris,et al.  Stress corrosion cracking of GRP pultruded rods in acid environments , 1983 .

[55]  J. T. Burnham,et al.  IEEE Task Force Report: brittle fracture in nonceramic insulators , 2002 .