GaN-Based ${\rm S}_{0}$ -Wave Sensors on Silicon for Chemical and Biological Sensing in Liquid Environments

In this paper, we successfully developed Lamb-wave sensors in a two-port delay line topology with suspending GaN thin films on silicon substrates. The liquid insusceptibility of the lowest order symmetric mode (S0) Lamb wave was experimentally investigated, and the relative frequency shift to water loading of the two-port S0-wave sensors was found to be as small as 0.12%. Our GaN-on-Si sensors, exhibiting a high mass sensitivity (272 cm2/g) and a sharp signal response at a low concentration (1 μg/mL) of anti-bovine serum albumin, were demonstrated to be suitable for chemical and biological sensing in liquid environments. In addition, the small size of the sensors and their potential to be integrated with a wide range of GaN-based devices allow for a robust, low-cost miniature sensing system to be manufactured with GaN-on-Si substrates.

[1]  D. Neculoiu,et al.  Microwave FBAR Structures Fabricated using Micromachined GaN Membranes , 2007, 2007 IEEE/MTT-S International Microwave Symposium.

[2]  Jean-François Manceau,et al.  Sensitivity of a Lamb wave sensor with 2 μm AlN membrane , 2006 .

[3]  E. Adler.  Electromechanical coupling to Lamb and shear-horizontal modes in piezoelectric plates , 1989, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[4]  Wen-Yang Chang,et al.  Phase Detection of the Two-port FPW Sensor for Biosensing , 2005, 2005 IEEE Engineering in Medicine and Biology 27th Annual Conference.

[5]  K. Wong,et al.  GaN-based lamb-wave mass-sensors on silicon substrates , 2010, 2010 IEEE Sensors.

[6]  Ventsislav Yantchev,et al.  Shear mode AlN thin film electro-acoustic resonant sensor operation in viscous media , 2007 .

[7]  L. Arapan,et al.  Sensitivity Features of Thin Film Plate Acoustic Wave Resonators , 2011, IEEE Sensors Journal.

[8]  I. Huang,et al.  Development of a FPW allergy biosensor for human IgE detection by MEMS and cystamine-based SAM technologies , 2008 .

[9]  Bastian E. Rapp,et al.  Surface acoustic wave biosensors: a review , 2008, Analytical and bioanalytical chemistry.

[10]  Seokheun Choi,et al.  A High-Quality-Factor Film Bulk Acoustic Resonator in Liquid for Biosensing Applications , 2011, Journal of Microelectromechanical Systems.

[11]  Michael J. Vellekoop,et al.  A smart lamb-wave sensor system for the determination of fluid properties , 1994 .

[12]  O. Sugiura,et al.  Film Characteristics of Low-Temperature Plasma-Enhanced Chemical Vapor Deposition Silicon Dioxide Using Tetraisocyanatesilane and Oxygen , 1998 .

[13]  Richard M. White,et al.  A multisensor employing an ultrasonic Lamb-wave oscillator , 1988 .

[14]  Improvement of the Mass Sensitivity in Flexural Plate Wave Biosensor Based on PZT Thin Film , 2005 .

[15]  Mark E. Thompson,et al.  A film bulk acoustic resonator in liquid environments , 2005 .

[16]  G. Feuillard,et al.  Propagation of Lamb waves in 1-3 piezocomposite bordered by liquids , 1999, Proceedings of the 1999 Joint Meeting of the European Frequency and Time Forum and the IEEE International Frequency Control Symposium (Cat. No.99CH36313).

[17]  Denis Remiens,et al.  Lamb wave and plate mode in ZnO/silicon and AlN/silicon membrane: Application to sensors able to operate in contact with liquid , 2000 .

[18]  Brian T. Cunningham,et al.  Detection of proteins and intact microorganisms using microfabricated flexural plate silicon resonator arrays , 2003 .

[19]  Masayoshi Esashi,et al.  Antisymmetric-mode lamb wave methanol sensor with edge reflectors for fuel cell applications , 2010, 2010 IEEE 23rd International Conference on Micro Electro Mechanical Systems (MEMS).

[20]  George Konstantinidis,et al.  A high frequency GaN Lamb-wave sensor device , 2010 .

[21]  F. Bastien,et al.  Multi-parameter sensing in liquid using a lamb wave based microsensor , 2008, Symposium on Piezoelectricity, Acoustic Waves and Device Applications.

[22]  Salvador Mir,et al.  AlGaN/GaN heterostructure-based surface acoustic wave-structures for chemical sensors , 2008 .

[23]  I-Yu Huang,et al.  Development of a Novel Flexural Plate Wave Biosensor for Immunoglobulin-E Detection by Using SAM and MEMS Technologies , 2006, 2006 5th IEEE Conference on Sensors.

[24]  I. A. Viktorov.  Rayleigh and Lamb Waves , 1967 .