Experimental investigation of CuO–water nanofluid flow and heat transfer inside a microchannel heat sink

Abstract This paper presents an experimental investigation of the hydraulic and thermal fields of a 29 nm CuO nanoparticle–water nanofluid with various volume fractions, 0.24%, 1.03% and 4.5% flowing inside a rectangular microchannel heat sink under both laminar and turbulent conditions. The isothermal and heated tests are conducted for Reynolds number up to ≈5000 and to ≈2500, respectively. For a given fluid flow rate experimental results show an increase of the pressure drop and the friction factor with respect to water. This increase can be as high as 70%, 25%, and 0–30%, respectively, for the 4.5%, 1.03%, and 0.24% particle volume fractions. Although the laminar-to-turbulent transition was observed at nearly the same critical Reynolds number Re c  ≈ 1000 for water and the tested nanofluids, this value of Re c is clearly lower than that corresponding to a smooth surface microchannel. Results show a slight heat transfer enhancement with respect to water for nanofluids with low particle volume fractions, 0.24% and 1.03%, while for the 4.5% fraction a clear decrease of heat transfer was found. In general, the nanofluid overall energetic performance, defined by the heat transferred/pumping power ratio, remains lower than that of water for a given Reynolds number. This ratio decreases with an augmentation of the particle volume fraction.

[1]  J. P. Holman,et al.  Experimental methods for engineers , 1971 .

[2]  Rahman Saidur,et al.  Heat transfer and fluid flow characteristics in microchannels heat exchanger using nanofluids: A review , 2011 .

[3]  Satish G. Kandlikar,et al.  Single-Phase Liquid Friction Factors in Microchannels , 2006 .

[4]  D. Lelea.  The performance evaluation of Al2O3/water nanofluid flow and heat transfer in microchannel heat sink , 2011 .

[5]  Normah Mohd-Ghazali,et al.  Thermal and hydrodynamic analysis of microchannel heat sinks: A review , 2013 .

[6]  Sudipto Chakraborty,et al.  Numerical study of conjugate heat transfer in rectangular microchannel heat sink with Al2O3/H2O nanofluid , 2009 .

[7]  Dong Liu,et al.  Single-Phase Thermal Transport of Nanofluids in a Minichannel , 2011 .

[8]  Angel Huminic,et al.  Application of nanofluids in heat exchangers: A review , 2012 .

[9]  S. Garimella,et al.  TRANSPORT IN MICROCHANNELS - A CRITICAL REVIEW , 2003 .

[10]  Chien-Hsin Chen.  Forced convection heat transfer in microchannel heat sinks , 2007 .

[11]  A. Bejan,et al.  The optimal spacing of parallel plates cooled by forced convection , 1992 .

[12]  Clement Kleinstreuer,et al.  Laminar nanofluid flow in microheat-sinks , 2005 .

[13]  Jason Chuang,et al.  Experimental microchannel heat sink performance studies using nanofluids , 2007 .

[14]  Ching-Jenq Ho,et al.  An experimental investigation of forced convective cooling performance of a microchannel heat sink with Al2O3/water nanofluid , 2010 .

[15]  S. Kakaç,et al.  Review of convective heat transfer enhancement with nanofluids , 2009 .

[16]  Kirk D. Hagen.  Heat Transfer with Applications , 1998 .

[17]  Sarit K. Das,et al.  Experimental and Numerical Investigation Into the Heat Transfer Study of Nanofluids in Microchannel , 2011 .

[18]  Yue-Tzu Yang,et al.  Numerical study of flow and heat transfer characteristics of alumina-water nanofluids in a microchannel using the lattice Boltzmann method , 2011 .

[19]  Chien-Hsin Chen,et al.  Study on the thermal behavior and cooling performance of a nanofluid-cooled microchannel heat sink. , 2011 .

[20]  Stephen U. S. Choi,et al.  Cooling performance of a microchannel heat sink with nanofluids , 2006 .

[21]  C. T. Nguyen,et al.  Experimental investigation of Al2O3 nanofluids thermal properties and rheology – Effects of transient and steady-state heat exposure , 2014 .

[22]  W. Minkowycz,et al.  Three-dimensional laminar slip-flow and heat transfer in a rectangular microchannel with constant wall temperature , 2008 .

[23]  K. Christensen,et al.  The impact of surface roughness on flow through a rectangular microchannel from the laminar to turbulent regimes , 2010 .

[24]  Yizhong Wang,et al.  Cooling Performance of Nanofluids in a Microchannel Heat Sink , 2009 .

[25]  C. T. Nguyen,et al.  New temperature dependent thermal conductivity data for water-based nanofluids , 2009 .

[26]  Jung-Yeul Jung,et al.  Forced convective heat transfer of nanofluids in microchannels , 2009 .

[27]  G. Morini.  Single-phase Convective Heat Transfer in Microchannels: a Review of Experimental Results , 2004 .

[28]  H. Shokouhmand,et al.  Investigation of a nanofluid-cooled microchannel heat sink using Fin and porous media approaches , 2009 .

[29]  Somchai Wongwises,et al.  Enhancement of heat transfer using nanofluids—An overview , 2010 .

[30]  C. T. Nguyen,et al.  Two-phase Modelling Of Nanofluid HeatTransfer In A Microchannel Heat Sink , 2009 .

[31]  Yulong Ding,et al.  Effect of particle migration on heat transfer in suspensions of nanoparticles flowing through minichannels , 2005 .

[32]  Zhang Hainan,et al.  Heat transfer and flow features of Al2O3–water nanofluids flowing through a circular microchannel – Experimental results and correlations , 2013 .

[33]  Stéphane Le Person,et al.  Scale effects on hydrodynamics and heat transfer in two-dimensional mini and microchannels , 2002 .

[34]  W. Roetzel,et al.  Conceptions for heat transfer correlation of nanofluids , 2000 .

[35]  Alexandre K. da Silva,et al.  Experimental thermal–hydraulic evaluation of CuO nanofluids in microchannels at various concentrations with and without suspension enhancers , 2012 .

[36]  Sarit K. Das,et al.  Experimental and numerical investigation into the hydrodynamics of nanofluids in microchannels , 2012 .

[37]  H. Mohammed,et al.  The impact of various nanofluid types on triangular microchannels heat sink cooling performance , 2011 .

[38]  C. T. Nguyen,et al.  Temperature and particle-size dependent viscosity data for water-based nanofluids : Hysteresis phenomenon , 2007 .

[39]  C. Kleinstreuer,et al.  Thermal performance of nanofluid flow in microchannels , 2008 .

[40]  Dong Liu,et al.  Experimental Investigation of Single-Phase Convective Heat Transfer of Nanofluids in a Minichannel , 2010 .

[41]  K. Khanafer,et al.  A critical synthesis of thermophysical characteristics of nanofluids , 2011 .

[42]  R. Shah.  Laminar Flow Forced convection in ducts , 1978 .

[43]  K. Leong,et al.  Thermophysical and electrokinetic properties of nanofluids – A critical review , 2008 .

[44]  M. Saffar-Avval,et al.  Experimental and numerical investigation of nanofluid forced convection inside a wide microchannel heat sink , 2012 .

[45]  Somchai Wongwises,et al.  A critical review of convective heat transfer of nanofluids , 2007 .