Role of dopant concentration, crystal phase and particle size on microbial inactivation of Cu-doped TiO2 nanoparticles

The properties of Cu-doped TiO2 nanoparticles (NPs) were independently controlled in a flame aerosol reactor by varying the molar feed ratios of the precursors, and by optimizing temperature and time history in the flame. The effect of the physico-chemical properties (dopant concentration, crystal phase and particle size) of Cu-doped TiO2 nanoparticles on inactivation of Mycobacterium smegmatis (a model pathogenic bacterium) was investigated under three light conditions (complete dark, fluorescent light and UV light). The survival rate of M. smegmatis (in a minimal salt medium for 2 h) exposed to the NPs varied depending on the light irradiation conditions as well as the dopant concentrations. In dark conditions, pristine TiO2 showed insignificant microbial inactivation, but inactivation increased with increasing dopant concentration. Under fluorescent light illumination, no significant effect was observed for TiO2. However, when TiO2 was doped with copper, inactivation increased with dopant concentration, reaching more than 90% (>3 wt% dopant). Enhanced microbial inactivation by TiO2 NPs was observed only under UV light. When TiO2 NPs were doped with copper, their inactivation potential was promoted and the UV-resistant cells were reduced by over 99%. In addition, the microbial inactivation potential of NPs was also crystal-phase-and size-dependent under all three light conditions. A lower ratio of anatase phase and smaller sizes of Cu-doped TiO2 NPs resulted in decreased bacterial survival. The increased inactivation potential of doped TiO2 NPs is possibly due to both enhanced photocatalytic reactions and leached copper ions.

[1]  P. Biswas,et al.  Characterization of doped TiO2 nanoparticle dispersions , 2011 .

[2]  P. Biswas,et al.  Single-step processing of copper-doped titania nanomaterials in a flame aerosol reactor , 2011, Nanoscale research letters.

[3]  Pratim Biswas,et al.  Role of Surface Area, Primary Particle Size, and Crystal Phase on Titanium Dioxide Nanoparticle Dispersion Properties , 2010, Nanoscale research letters.

[4]  C. Karunakaran,et al.  Cu-doped TiO(2) nanoparticles for photocatalytic disinfection of bacteria under visible light. , 2010, Journal of colloid and interface science.

[5]  Pratim Biswas,et al.  Photocatalytic reduction of CO2 with H2O on mesoporous silica supported Cu/TiO2 catalysts , 2010 .

[6]  Fubing Peng,et al.  High-throughput screening of silver nanoparticle stability and bacterial inactivation in aquatic media: influence of specific ions. , 2010, Environmental science & technology.

[7]  Jimmy C. Yu,et al.  Inorganic materials for photocatalytic water disinfection , 2010 .

[8]  J. Weaver,et al.  Aggregation and charge behavior of metallic and nonmetallic nanoparticles in the presence of competing similarly-charged inorganic ions. , 2010, Environmental science & technology.

[9]  Yinjie J. Tang,et al.  Bacterial responses to Cu-doped TiO(2) nanoparticles. , 2010, The Science of the total environment.

[10]  Tae-ho Yoon,et al.  Inactivation of environmental mycobacteria by free chlorine and UV. , 2010, Water research.

[11]  K. Klabunde,et al.  A multifunctional biocide/sporocide and photocatalyst based on titanium dioxide (TiO2) codoped with silver, carbon, and sulfur. , 2010, Langmuir : the ACS journal of surfaces and colloids.

[12]  H. Karlsson,et al.  Size-dependent toxicity of metal oxide particles--a comparison between nano- and micrometer size. , 2009, Toxicology letters.

[13]  Yinjie J. Tang,et al.  Central metabolism in Mycobacterium smegmatis during the transition from O2-rich to O2-poor conditions as studied by isotopomer-assisted metabolite analysis , 2009, Biotechnology Letters.

[14]  Michael V. Liga,et al.  Antimicrobial nanomaterials for water disinfection and microbial control: potential applications and implications. , 2008, Water research.

[15]  Å. Holgersson,et al.  Mechanisms related to the genotoxicity of particles in the subway and from other sources. , 2008, Chemical research in toxicology.

[16]  Pratim Biswas,et al.  Does nanoparticle activity depend upon size and crystal phase? , 2008, Nanotoxicology.

[17]  Zhiyu Jiang,et al.  Photocatalytic Inactivation Effect of Gold-Doped TiO2 (Au/TiO2) Nanocomposites on Human Colon Carcinoma LoVo Cells , 2007 .

[18]  P. Biswas,et al.  Synthesis of nanoparticles in a flame aerosol reactor with independent and strict control of their size, crystal phase and morphology , 2007 .

[19]  Robert N Grass,et al.  Exposure of engineered nanoparticles to human lung epithelial cells: influence of chemical composition and catalytic activity on oxidative stress. , 2007, Environmental science & technology.

[20]  U. Bakir,et al.  Photocatalytic microbial inactivation over Pd doped SnO2 and TiO2 thin films , 2006 .

[21]  M. Wong,et al.  Visible-Light-Induced Bactericidal Activity of a Nitrogen-Doped Titanium Photocatalyst against Human Pathogens , 2006, Applied and Environmental Microbiology.

[22]  M. Taya,et al.  Copper-aided photosterilization of microbial cells on TiO2 film under irradiation from a white light fluorescent lamp , 2006 .

[23]  Sun-Jae Kim,et al.  The photocatalytic activity of 2.5 wt% Cu-doped TiO2 nano powders synthesized by mechanical alloying , 2006 .

[24]  P. Christensen,et al.  Photoelectrocatalytic disinfection of E. coli suspensions by iron doped TiO2. , 2006, Physical chemistry chemical physics : PCCP.

[25]  W. Hijnen,et al.  Inactivation credit of UV radiation for viruses, bacteria and protozoan (oo)cysts in water: a review. , 2006, Water research.

[26]  W. D. Griffiths,et al.  Determining the performance of a commercial air purification system for reducing airborne contamination using model micro-organisms: a new test methodology. , 2005, The Journal of hospital infection.

[27]  K. Jan,et al.  Ultrafine titanium dioxide particles in the absence of photoactivation can induce oxidative damage to human bronchial epithelial cells. , 2005, Toxicology.

[28]  J. Banfield,et al.  Nanoparticulate Iron Oxide Minerals in Soils and Sediments: Unique Properties and Contaminant Scavenging Mechanisms , 2005 .

[29]  P. Ross,et al.  The effect of the particle size on the kinetics of CO electrooxidation on high surface area Pt catalysts. , 2005, Journal of the American Chemical Society.

[30]  G. Colón,et al.  Gas-phase ethanol photocatalytic degradation study with TiO2 doped with Fe, Pd and Cu , 2004 .

[31]  Wonyong Choi,et al.  Linear correlation between inactivation of E. coli and OH radical concentration in TiO2 photocatalytic disinfection. , 2004, Water research.

[32]  J. Wu,et al.  Effects of sol–gel procedures on the photocatalysis of Cu/TiO2 in CO2 photoreduction , 2004 .

[33]  Hsuan-Liang Liu,et al.  Photocatalytic inactivation of Escherichia coli and Lactobacillus helveticus by ZnO and TiO2 activated with ultraviolet light , 2003 .

[34]  K. Hashimoto,et al.  Bactericidal activity of copper-deposited TiO2 thin film under weak UV light illumination. , 2003, Environmental science & technology.

[35]  Pratim Biswas,et al.  Role of Synthesis Method and Particle Size of Nanostructured TiO2 on Its Photoactivity , 2002 .

[36]  R. Asahi,et al.  Visible-Light Photocatalysis in Nitrogen-Doped Titanium Oxides , 2001, Science.

[37]  P. Boolchand,et al.  Processing of iron-doped titania powders in flame aerosol reactors , 2001 .

[38]  F. Mizukami,et al.  Microstructure and phase transformation behavior of doped nanostructured titania , 1999 .

[39]  R. Sierka,et al.  Inactivation of Phage MS2 by Iron-Aided Titanium Dioxide Photocatalysis , 1994, Applied and environmental microbiology.

[40]  W. Jacobs,et al.  Isolation and characterization of efficient plasmid transformation mutants of Mycobacterium smegmatis , 1990, Molecular microbiology.

[41]  H. Myers,et al.  Quantitative Analysis of Anatase-Rutile Mixtures with an X-Ray Diffractometer , 1957 .