Crystal modification of phenytoin using different solvents and crystallization conditions.

Phenytoin crystals having different types of habits, were prepared by recrystallization from ethanol and acetone solutions under different conditions (cooling rate or crystallization temperature, solvent evaporation and watering-out techniques). Scanning electron microscopy, X-ray powder diffractometry, FT-IR spectrometry and differential scanning calorimetry were used to investigate the physical characteristics of the crystals. The dissolution behavior and compaction properties of various batches of crystals were also studied. It was found that using watering-out technique as a crystallization method, produced thin plate crystals, while the crystals obtained by other methods were needle shape for alcoholic solutions and rhombic for acetone solutions. X-ray diffraction spectra and differential scanning calorimetry studies, did not show any polymorphic change. The dissolution rate of different crystals was lower than that of untreated samples. The compacts of phenytoin crystals produced from alcohol or acetone (especially those made by watering-out method) had higher crushing strengths than untreated phenytoin compacts due to the lower porosity and the lower elastic recovery.

[1]  Z. Berkovitch-yellin.  Toward an ab initio derivation of crystal morphology , 1985 .

[2]  G. Biggio,et al.  Dissolution properties and anticonvulsant activity of phenytoin-polyethylene glycol 6000 and -polyvinylpyrrolidone K-30 solid dispersions. , 2001, International journal of pharmaceutics.

[3]  H. Burt,et al.  Effect of habit modification on dissolution rate , 1980 .

[4]  G. Alderborn,et al.  Studies on direct compression of tablets. III. The effect on tablet strength of changes in particle shape and texture obtained by milling. , 1982, Acta pharmaceutica Suecica.

[5]  N. Pilpel,et al.  The effect of particle shape on the mechanical properties of powders , 1990 .

[6]  M. Spring,et al.  STUDIES ON PARACETAMOL CRYSTALS PRODUCED BY GROWTH IN AQUEOUS SOLUTIONS , 1994 .

[7]  M. H. Rubinstein,et al.  Formation and compression characteristics of prismatic polyhedral and thin plate-like crystals of paracetamol. , 1999, International journal of pharmaceutics.

[8]  A. Watanabe,et al.  Crystal Habits and Dissolution Behavior of Aspirin , 1982 .

[9]  M. H. Rubinstein,et al.  Highly compressible paracetamol: I: crystallization and characterization. , 2000, International journal of pharmaceutics.

[10]  M. H. Rubinstein,et al.  Highly compressible paracetamol - II. Compression properties. , 2000, International journal of pharmaceutics.

[11]  E. Khamskii.  Some Problems of Crystal Habit Modification , 1976 .

[12]  A. Chow,et al.  MODIFICATION OF PHENYTOIN CRYSTALS: INFLUENCE OF 3-ACETOXYMETHYL-5, 5-DIPHENYLHYDANTOIN ON SOLUTION - PHASE CRYSTALLIZATION AND RELATED CRYSTAL PROPERTIES , 1991 .

[13]  N. Nguyen,et al.  Crystal habit modifications and altered tabletting characteristics , 1992 .

[14]  A. Chow,et al.  Modification of acetaminophen crystals: influence of growth in aqueous solutions containing p-acetoxyacetanilide on crystal properties , 1985 .

[15]  L. Leiserowitz,et al.  The effect of solvent on crystal growth and morphology , 2001 .

[16]  P. York,et al.  Crystallisation solvent induced solid-state and particulate modifications of nitrofurantoin , 1989 .

[17]  P. Di Martino,et al.  Improved compression properties of propyphenazone spherical crystals. , 2000, International journal of pharmaceutics.

[18]  K. Kachrimanis,et al.  Crystallisation conditions and physicomechanical properties of ibuprofen–Eudragit® S100 spherical crystal agglomerates prepared by the solvent-change technique , 1998 .