Thermophilic Anaerobic Treatment of Sulfate-Rich Pulp and Paper Integrate Process Water

Anaerobic treatment of sulfate - rich (COD/SO 4 ratio 1.4-2.1) clarified Whitewater from a thermomechanical pulping (TMP) process was studied in three laboratory-scale upflow anaerobic sludge blanket (UASB) reactors at 55°C and in batch digesters at 55° and 65°C. Different seed materials were used in the UASB reactors. The highest COD removal efficiency (effluent sulfide stripped) achieved was approximately 65 % in the UASB reactors. About 55 % COD removal efficiency was obtained at a loading rate of about 41 kgCODm −3 d −1 in the UASB reactor seeded with thermophilic sludge cultivated with volatile fatty acids (VFAs). The total sulfide present in the liquid phase after anaerobic treatment accounted for approximately 65-78 % and 15-61 % of the removed COD in the batch digesters and the UASB reactors, respectively. Sulfate reduction was almost complete in the batch digesters, whereas about 24-64 % of sulfate was reduced in the UASB reactors. Acetate utilization for sulfate reduction was apparent in the batch digesters, whereas that could not be demonstrated in the UASB reactors. Sulfate reduction in the UASB reactors was obviously substrate limited. In conclusion, thermophilic anaerobic treatment is an alternative for the treatment of warm sulfate rich TMP process water.

[1]  G. Olsson,et al.  Anaerobic treatment of CTMP effluent , 1987 .

[2]  G Lettinga,et al.  Thermophilic anaerobic digestion of sugars in upflow anaerobic sludge blanket reactors. , 1985, Biotechnology and bioengineering.

[3]  Jukka Rintala,et al.  Anaerobic-aerobic treatment of thermomechanical pulping effluents , 1988 .

[4]  J. Puhakka,et al.  Sulfur Reduction and Inhibition in Anaerobic Treatment of Simulated Pulp Mill Wastewater , 1989 .

[5]  A. Rinzema,et al.  Anaerobic treatment of wastewater with high concentrations of lipids or sulfate , 1988 .

[6]  R. Battino,et al.  Low-pressure solubility of gases in liquid water , 1977 .

[7]  W. J. Jewell,et al.  High rates conversions of soluble organics with a thermophilic anaerobic attached film expanded bed , 1984 .

[8]  H. Kroiss,et al.  Sulfide toxicity with anaerobic waste water treatment , 1983 .

[9]  W. Wiegant,et al.  Granulation of biomass in thermophilic upflow anaerobic sludge blanket reactors treating acidified wastewaters , 1986, Biotechnology and bioengineering.

[10]  W. M. Haynes.  CRC Handbook of Chemistry and Physics , 1990 .

[11]  F. Widdel,et al.  Microbiology and ecology of sulfate-and sulfur-reducing bacteria , 1988 .

[12]  John F. Ferguson,et al.  Carbon flow in acetotrophic enrichment cultures from pulp mill effluent treatment , 1990 .

[13]  A. Rinzema,et al.  Sulfide inhibition of the methanogenic activity of granular sludge at various pH-levels , 1986 .

[14]  G Lettinga,et al.  Thermophilic anaerobic digestion of high strength wastewaters , 1985, Biotechnology and bioengineering.