Design of Novel Ceramic Preconcentrator and Integration in Gas Chromatographic System for Detection of Ethylene Gas from Ripening Bananas

In this paper, a novel ceramic preconcentrator is manufactured using aluminum nitride (ALN) ceramics. The preconcentrator consists of a heater, a preconcentrator body, a gas inlet and a gas outlet. The adsorption material, Carbosieve SII, is loaded into the preconcentrator. The preconcentrator is integrated with a previously developed micro gas chromatographic system filled with ethylene. When operated, adequate ethylene gas is adsorbed into the preconcentrator. The application of heat pulse also successfully desorbs the ethylene gas. Tests are conducted with ethylene gas at concentrations of 10 ppm, 5 ppm and 2.5 ppm and 400 ppb, respectively. The system is also tested with ethylene gas from ripening bananas over a period of three days. No interference signal is observed in the chromatogram because of other ripening gases (e.g., carbon dioxide, oxygen, alcohol) and humidity. A detection limit of 25 ppb is realized with this system. The developed preconcentrator has several applications, e.g., in food industry and environmental monitoring.

[1]  Gong Shu-sheng.  On the Logistics Network Modes of Fresh Food Cold Chain , 2006 .

[2]  Walter Lang,et al.  High sensitive and selective ethylene measurement by using a large-capacity-on-chip preconcentrator device , 2014 .

[3]  Julien Mandon,et al.  Current methods for detecting ethylene in plants. , 2013, Annals of botany.

[4]  W. Lang,et al.  Design and Fabrication of a Micropreconcentrator Focuser for Sensitivity Enhancement of Chemical Sensing Systems , 2012, IEEE Sensors Journal.

[5]  Walter Lang,et al.  Miniature 3D Gas Chromatography Columns with Integrated Fluidic Connectors Using High-resolution Stereolithography Fabrication☆ , 2015 .

[6]  S Janssen,et al.  Ethylene detection in fruit supply chains , 2014, Philosophical Transactions of the Royal Society A: Mathematical, Physical and Engineering Sciences.

[7]  D. Zukor,et al.  Midterm Outcomes of the Recently FDA Approved Ceramic on Ceramic Bearing in Total Hip Arthroplasty Patients Under 65 Years of Age. , 2015, The Journal of arthroplasty.

[8]  U. Sonesson,et al.  Global food losses and food waste: extent, causes and prevention , 2011 .

[9]  P. P. Vinayaka,et al.  Detection of Ethylene Using Gas Chromatographic System , 2016 .

[10]  Walter Lang,et al.  Application of a miniaturised packed gas chromatography column and a SnO2 gas detector for analysis of low molecular weight hydrocarbons with focus on ethylene detection , 2013 .

[11]  N. D. Amos,et al.  TEMPERATURE VARIABILITY DURING SHIPMENT OF FRESH PRODUCE , 2003 .

[12]  R. Leitner,et al.  Ethylene gas sensing using non-dispersive infrared spectroscopy , 2016, 2016 IEEE SENSORS.

[13]  Walter Lang,et al.  A Gas Chromatographic System for the Detection of Ethylene Gas Using Ambient Air as a Carrier Gas , 2017, Sensors.

[14]  Christophe A. Serra,et al.  Portable novel micro-device for BTEX real-time monitoring: Assessment during a field campaign in a low consumption energy junior high school classroom , 2016 .

[15]  C. Serra,et al.  Development of a novel portable miniaturized GC for near real-time low level detection of BTEX , 2016 .

[16]  Raimund Leitner,et al.  Quantitative Ethylene Measurements with MOx Chemiresistive Sensors at Different Relative Air Humidities , 2015, Sensors.

[17]  H. Katz,et al.  Ethylene Detection Based on Organic Field-Effect Transistors With Porogen and Palladium Particle Receptor Enhancements. , 2017, ACS applied materials & interfaces.