Droplets movement and deposition of an eight-rotor agricultural UAV in downwash flow field

Abstract: The movement and deposition of the droplets sprayed by agricultural unmanned aerial vehicle (UAV) are influenced by the complex downwash flow field of the rotors. Instead of conducting field experiment, a high speed particle image velocimetry (PIV) method was used to measure the movement and deposition of the droplets at different rotating speeds of rotors (1000-3000 r/min) or at different transverse injecting points (20-50 cm away from its nearby rotors) in the downwash flow field of an agricultural UAV with eight rotors and conical nozzles. The maximum speed and size of the high speed zone of the droplets were found greatly influenced by the downwash velocity. The initial spray angle of the nozzle declined with the increase of downwash flow speed. It was found that the downwash velocity could not only change the deposition zone of the droplets, but also influence their distribution. The increase of the downwash velocity would increase the deposition uniformity of the droplets. The nozzle position in the downwash flow field could also influence the deposition of the droplets. When the transverse distance between the nozzle and its nearby rotors increased, the relative deposition near the downwash flow of the rotors increased simultaneously. However, the distance between the deposition peak and the nozzle stayed constant. The initial spray angle of the nozzle was not influenced by the transverse distance between the nozzle and its nearby rotors. The research results could provide a theoretical basis and reference for the optimization of the spray application of multi-rotor UAV to minimize droplets deposition uncertainty. Keywords: chemical spray, droplet deposition, UAV, flow field, multi-rotor DOI: 10.3965/j.ijabe.20171003.3075 Citation: Tang Q, Zhang R R, Chen L P, Xu M, Yi T C, Zhang B. Droplets movement and deposition of an eight-rotor agricultural UAV in downwash flow field. Int J Agric & Biol Eng, 2017; 10(3): 47–56.

[1]  Alfred Gessow,et al.  Aerodynamics of the Helicopter , 1981 .

[2]  D. K. Giles,et al.  Unmanned aerial platforms for spraying: deployment and performance. , 2014 .

[3]  Song Jianli,et al.  Influence of spraying parameters of unmanned aircraft on droplets deposition. , 2012 .

[4]  Alfred Gessow,et al.  Understanding and Predicting Helicopter Behavior — Then and Now , 1986 .

[5]  J. Leishman,et al.  Flow Field of a Rotating-Wing Micro Air Vehicle , 2006 .

[6]  Us Agricultural,et al.  Current Status and Future Trends of Agricultural Aerial Spraying Technology in China , 2014 .

[7]  J. Gordon Leishman,et al.  Investigation of Sediment Entrainment Using Dual-Phase, High-Speed Particle Image Velocimetry , 2010 .

[8]  K. Pengel,et al.  Recording and evaluation methods of PIV investigations on a helicopter rotor model , 2004 .

[9]  Young Mo Koo,et al.  Flight Attitudes and Spray Patterns of a Roll-Balanced Agricultural Unmanned Helicopter , 2013 .

[10]  A. T. Conlisk,et al.  MODERN HELICOPTER AERODYNAMICS , 1997 .

[11]  Richard B. Green,et al.  The flow around a model helicopter main rotor in ground effect , 2012 .

[12]  Bradley K. Fritz,et al.  AERIAL APPLICATION METHODS FOR INCREASING SPRAY DEPOSITION ON WHEAT HEADS , 2006 .

[13]  W Clint,et al.  Design of Variable Spraying System and Influencing Factors on Droplets Deposition of Small UAV , 2016 .

[14]  H. P. W. Jayasuriya,et al.  Suitability of low-altitude remote sensing images for estimating nitrogen treatment variations in rice cropping for precision agriculture adoption , 2007 .

[15]  Tae-Hwan Kang,et al.  Development of Aerial Application System Attachable to Unmanned Helicopter - Basic Spraying Characteristics for Aerial Application System - , 2010 .

[16]  Durham K. Giles,et al.  Deployment and Performance of a Uav for Crop Spraying , 2015 .

[17]  Zhang Pa,et al.  Evaluation of spraying effect using small unmanned aerial vehicle(UAV) in citrus orchard , 2016 .

[18]  K. Swain,et al.  Adoption of an unmanned helicopter for low-altitude remote sensing to estimate yield and total biomass of a rice crop. , 2010 .

[19]  Hugues Richard,et al.  Analysis methodology for 3C-PIV data of rotary wing vortices , 2006 .

[20]  Yubin Lan,et al.  Development of a Spray System for an Unmanned Aerial Vehicle Platform , 2009 .

[21]  Xin-Yu Xue,et al.  Droplet deposition and control effect of insecticides sprayed with an unmanned aerial vehicle against plant hoppers , 2016 .

[22]  W. J. McCroskey.  Vortex wakes of rotorcraft , 1995 .

[23]  W. Johnson,et al.  Recent developments in rotary-wing aerodynamic theory , 1986 .

[24]  J. Garratt.  The Atmospheric Boundary Layer , 1992 .