Nitrate reduction by metallic iron

Abstract Chemical reduction of nitrate by metallic iron (Fe 0 ) was studied as a potential technology to remove nitrate from water. The effects of pH and the iron-to-nitrate ratio on both nitrate reduction rate and percent removal were investigated. Rate constants and the apparent reaction order with respect to nitrate were determined and a mass balance was obtained. Rapid nitrate reduction by iron powder was observed only at pH≤4. pH control with sulfuric acid significantly prolonged nitrate reduction and increased the percent removal. At high nitrate loadings, both the rate and the percent removal increased with decreasing pH. An iron-to-nitrate ratio of 120 m 2 Fe 0 /mol NO 3 or higher was required to completely remove nitrate within an hour. An apparent reaction order of 1.7 with respect to nitrate was observed, which may be partly due to the inhibitory effect of sulfate. Ammonia was the end product of nitrate reduction and accounted for all nitrate transformed under our experimental conditions. Acidity is the principal factor which controls the rate and the extent of nitrate removal by Fe 0 . The rapid reduction of nitrate at low pH was most likely due to either direct reduction by Fe 0 or indirect reduction by surface hydrogen derived from proton. Ferrous species, Fe 2+ and Fe(OH) 2 , were probably not involved in this reaction.

[1]  G. W. Whitman,et al.  Effect of Hydrogen-Ion Concentration on the Submerged Corrosion of Steel. , 1924 .

[2]  E. Reardon,et al.  Anaerobic corrosion of granular iron: measurement and interpretation of hydrogen evolution rates. , 1995, Environmental science & technology.

[3]  E. J. Weber.  Iron-mediated reductive transformations : investigation of reaction mechanism , 1996 .

[4]  Timothy L. Johnson,et al.  Kinetics of Halogenated Organic Compound Degradation by Iron Metal , 1996 .

[5]  H. H. Johnson,et al.  Steady state hydrogen transport through zone refined irons , 1975 .

[6]  R. Buresh,et al.  Chemical Reduction of Nitrate by Ferrous Iron , 1976 .

[7]  Abinash Agrawal,et al.  Reduction of Nitro Aromatic Compounds by Zero-Valent Iron Metal , 1996 .

[8]  Q. Fernaǹdo,et al.  Electrochemical dechlorination of 4-chlorophenol to phenol , 1997 .

[9]  Robert W. Gillham,et al.  Dechlorination of Trichloroethene in Aqueous Solution Using Fe0 , 1996 .

[10]  H. Shuval,et al.  Infant methemoglobinemia and other health effects of nitrates in drinking water , 1977 .

[11]  Paul G Tratnyek,et al.  Reductive dehalogenation of chlorinated methanes by iron metal. , 1994, Environmental science & technology.

[12]  Q. Fernaǹdo,et al.  Rapid dechlorination of polychlorinated biphenyls on the surface of a pd/fe bimetallic system. , 1995, Environmental science & technology.

[13]  A. L. Roberts,et al.  Reductive Elimination of Chlorinated Ethylenes by Zero-Valent Metals , 1996 .

[14]  I. Francis Cheng,et al.  Reduction of nitrate to ammonia by zero-valent iron , 1997 .

[15]  L. Baert,et al.  Chemo-denitrification of nitrate-polluted water. , 1990, Environmental pollution.

[16]  M. Reinhard,et al.  Catalytic hydrodehalogenation of chlorinated ethylenes using palladium and hydrogen for the treatment of contaminated water , 1995 .

[17]  M. Reinhard,et al.  Treatment of 1,2-dibromo-3-chloropropane and nitrate-contaminated water with zero-valent iron or hydrogen/palladium catalysts , 1996 .

[18]  Gary S. Logsdon,et al.  Treatment Technology to Meet the Interim Primary Drinking Water Regulations for Inorganics: Part 3 , 1978 .