Theory-driven design of high-valence metal sites for water oxidation confirmed using in situ soft X-ray absorption.

The efficiency with which renewable fuels and feedstocks are synthesized from electrical sources is limited at present by the sluggish oxygen evolution reaction (OER) in pH-neutral media. We took the view that generating transition-metal sites with high valence at low applied bias should improve the activity of neutral OER catalysts. Here, using density functional theory, we find that the formation energy of desired Ni4+ sites is systematically modulated by incorporating judicious combinations of Co, Fe and non-metal P. We therefore synthesized NiCoFeP oxyhydroxides and probed their oxidation kinetics with in situ soft X-ray absorption spectroscopy (sXAS). In situ sXAS studies of neutral-pH OER catalysts indicate ready promotion of Ni4+ under low overpotential conditions. The NiCoFeP catalyst outperforms IrO2 and retains its performance following 100 h of operation. We showcase NiCoFeP in a membrane-free CO2 electroreduction system that achieves a 1.99 V cell voltage at 10 mA cm-2, reducing CO2 into CO and oxidizing H2O to O2 with a 64% electricity-to-chemical-fuel efficiency.

[1]  I. Natkaniec,et al.  Atomic structure and lattice dynamics of Ni and Mg hydroxides , 2010 .

[2]  H. Monkhorst,et al.  SPECIAL POINTS FOR BRILLOUIN-ZONE INTEGRATIONS , 1976 .

[3]  Pamela A. Silver,et al.  Water splitting–biosynthetic system with CO2 reduction efficiencies exceeding photosynthesis , 2016, Science.

[4]  M. Koper,et al.  The importance of nickel oxyhydroxide deprotonation on its activity towards electrochemical water oxidation† †Electronic supplementary information (ESI) available. See DOI: 10.1039/c5sc04486c , 2016, Chemical science.

[5]  Thomas J. Kempa,et al.  Influence of iron doping on tetravalent nickel content in catalytic oxygen evolving films , 2017, Proceedings of the National Academy of Sciences.

[6]  Jens K Nørskov,et al.  Identification of highly active Fe sites in (Ni,Fe)OOH for electrocatalytic water splitting. , 2015, Journal of the American Chemical Society.

[7]  Antonio Abate,et al.  Efficient photosynthesis of carbon monoxide from CO2 using perovskite photovoltaics , 2015, Nature Communications.

[8]  Oleksandr Voznyy,et al.  Enhanced electrocatalytic CO2 reduction via field-induced reagent concentration , 2016, Nature.

[9]  J. Goodenough,et al.  A Perovskite Oxide Optimized for Oxygen Evolution Catalysis from Molecular Orbital Principles , 2011, Science.

[10]  M. Toroker,et al.  Designing efficient doped NiOOH catalysts for water splitting with first principles calculations , 2016 .

[11]  M. Zwierzycki,et al.  Multiplet ligand-field theory using Wannier orbitals , 2011, 1111.4940.

[12]  J. Savéant,et al.  Efficient electrolyzer for CO2 splitting in neutral water using earth-abundant materials , 2016, Proceedings of the National Academy of Sciences.

[13]  Y. Shao-horn,et al.  Reversibility of Ferri-/Ferrocyanide Redox during Operando Soft X-ray Spectroscopy , 2015 .

[14]  E. Carter,et al.  Structural and Electronic Features of β-Ni(OH)2 and β-NiOOH from First Principles , 2015 .

[15]  Sawatzky,et al.  Doping dependence of Ni 2p x-ray-absorption spectra of MxNi1-xO (M=Li,Na). , 1994, Physical Review B (Condensed Matter).

[16]  Jack J. Dongarra,et al.  Efficient implementation of quantum materials simulations on distributed CPU-GPU systems , 2015, SC15: International Conference for High Performance Computing, Networking, Storage and Analysis.

[17]  Marc T. M. Koper,et al.  Guidelines for the Rational Design of Ni-Based Double Hydroxide Electrocatalysts for the Oxygen Evolution Reaction , 2015 .

[18]  P. Yang,et al.  Covalent organic frameworks comprising cobalt porphyrins for catalytic CO2 reduction in water , 2015, Science.

[19]  F. Costanzo.  Effect of doping β-NiOOH with Co on the catalytic oxidation of water: DFT+U calculations. , 2016, Physical chemistry chemical physics : PCCP.

[20]  Itamar Willner,et al.  Cyclic control of the surface properties of a monolayer-functionalized electrode by the electrochemical generation of Hg nanoclusters. , 2006, Chemistry.

[21]  Daniel G. Nocera,et al.  Mechanistic studies of the oxygen evolution reaction mediated by a nickel-borate thin film electrocatalyst. , 2013, Journal of the American Chemical Society.

[22]  Cheng Hao Wu,et al.  The structure of interfacial water on gold electrodes studied by x-ray absorption spectroscopy , 2014, Science.

[23]  Z. Hussain,et al.  Distinct charge dynamics in battery electrodes revealed by in situ and operando soft X-ray spectroscopy , 2013, Nature Communications.

[24]  A. Yamaguchi,et al.  Regulating proton-coupled electron transfer for efficient water splitting by manganese oxides at neutral pH , 2014, Nature Communications.

[25]  Stefano de Gironcoli,et al.  Linear response approach to the calculation of the effective interaction parameters in the LDA + U method , 2004, cond-mat/0405160.

[26]  Yayuan Liu,et al.  Bifunctional non-noble metal oxide nanoparticle electrocatalysts through lithium-induced conversion for overall water splitting , 2015, Nature Communications.

[27]  J. Savéant,et al.  A Local Proton Source Enhances CO2 Electroreduction to CO by a Molecular Fe Catalyst , 2012, Science.

[28]  J. J. Rehr,et al.  Ab initioBethe-Salpeter calculations of the x-ray absorption spectra of transition metals at theL-shell edges , 2012 .

[29]  C. Berlinguette,et al.  Accounting for the Dynamic Oxidative Behavior of Nickel Anodes. , 2016, Journal of the American Chemical Society.

[30]  Wenli Bi,et al.  Operando Analysis of NiFe and Fe Oxyhydroxide Electrocatalysts for Water Oxidation: Detection of Fe⁴⁺ by Mössbauer Spectroscopy. , 2015, Journal of the American Chemical Society.

[31]  J. Newman,et al.  Comparing the Energy Content of Batteries, Fuels, and Materials , 2013 .

[32]  Uwe Bergmann,et al.  1s2p resonant inelastic X-ray scattering of iron oxides. , 2005, The journal of physical chemistry. B.

[33]  Michael R. Norris,et al.  Splitting CO2 into CO and O2 by a single catalyst , 2012, Proceedings of the National Academy of Sciences.

[34]  R. M. Jones,et al.  Characterization of Heterogeneous Nickel Sites in CO Dehydrogenases from Clostridium thermoaceticum and Rhodospirillum rubrum by Nickel L-Edge X-ray Spectroscopy , 2000 .

[35]  Maytal Caspary Toroker,et al.  Benchmarking Density Functional Theory Based Methods To Model NiOOH Material Properties: Hubbard and van der Waals Corrections vs Hybrid Functionals. , 2016, Journal of chemical theory and computation.

[36]  T. Mallouk,et al.  Assessing the utility of bipolar membranes for use in photoelectrochemical water-splitting cells. , 2014, ChemSusChem.

[37]  H. D. de Groot,et al.  Ni‐Based Electrocatalyst for Water Oxidation Developed In‐Situ in a HCO3−/CO2 System at Near‐Neutral pH , 2014 .

[38]  Vittal K. Yachandra,et al.  Structure-activity correlations in a nickel-borate oxygen evolution catalyst. , 2012, Journal of the American Chemical Society.

[39]  D. Corrigan,et al.  Photoelectrochemistry of Nickel Hydroxide Thin Films , 1989 .

[40]  Eric L. Shirley,et al.  Efficient implementation of core-excitation Bethe-Salpeter equation calculations , 2015, Comput. Phys. Commun..

[41]  Annabella Selloni,et al.  Mechanism and Activity of Water Oxidation on Selected Surfaces of Pure and Fe-Doped NiOx , 2014 .

[42]  F. D. de Groot,et al.  The CTM4XAS program for EELS and XAS spectral shape analysis of transition metal L edges. , 2010, Micron.

[43]  Matthew W Kanan,et al.  Cobalt-phosphate oxygen-evolving compound. , 2009, Chemical Society reviews.

[44]  J. J. Rehr,et al.  Theoretical optical and x-ray spectra of liquid and solid H 2 O , 2012 .

[45]  N. Ohba,et al.  First-principles study on lithium borohydrideLiBH4 , 2004 .

[46]  Kuiper,et al.  Electronic structure of Li-doped NiO. , 1992, Physical review. B, Condensed matter.

[47]  Kristin A. Persson,et al.  Prediction of solid-aqueous equilibria: Scheme to combine first-principles calculations of solids with experimental aqueous states , 2012 .

[48]  Peter Strasser,et al.  Reversible amorphization and the catalytically active state of crystalline Co3O4 during oxygen evolution , 2015, Nature Communications.

[49]  A. Anderson,et al.  Activation energies for oxygen reduction on platinum alloys: theory and experiment. , 2005, The journal of physical chemistry. B.

[50]  G. Kresse,et al.  From ultrasoft pseudopotentials to the projector augmented-wave method , 1999 .

[51]  J J Kas,et al.  Bethe-Salpeter equation calculations of core excitation spectra. , 2010, Physical review. B, Condensed matter and materials physics.

[52]  Blöchl,et al.  Projector augmented-wave method. , 1994, Physical review. B, Condensed matter.

[53]  Thomas E. Mallouk,et al.  Resistance and polarization losses in aqueous buffer–membrane electrolytes for water-splitting photoelectrochemical cells , 2012 .

[54]  Marc T. M. Koper,et al.  In Situ Observation of Active Oxygen Species in Fe-Containing Ni-Based Oxygen Evolution Catalysts: The Effect of pH on Electrochemical Activity. , 2015, Journal of the American Chemical Society.

[55]  Tom Regier,et al.  An advanced Ni-Fe layered double hydroxide electrocatalyst for water oxidation. , 2013, Journal of the American Chemical Society.

[56]  E. Cairns,et al.  Local structure of LiNi0.5Mn0.5O2 cathode material probed by in situ x-ray absorption spectroscopy , 2006 .

[57]  G. Olah,et al.  Recycling of Carbon Dioxide to Methanol and Derived Products — Closing the Loop , 2015 .

[58]  Daniel G. Nocera,et al.  In Situ Formation of an Oxygen-Evolving Catalyst in Neutral Water Containing Phosphate and Co 2 + , 2008 .

[59]  A. Vojvodić,et al.  Homogeneously dispersed multimetal oxygen-evolving catalysts , 2016, Science.

[60]  Jens K Nørskov,et al.  Theoretical investigation of the activity of cobalt oxides for the electrochemical oxidation of water. , 2013, Journal of the American Chemical Society.

[61]  K. Takanabe,et al.  Simultaneous Reduction of CO2 and Splitting of H2O by a Single Immobilized Cobalt Phthalocyanine Electrocatalyst , 2016 .

[62]  J. Gregoire,et al.  An Operando Investigation of (Ni–Fe–Co–Ce)Ox System as Highly Efficient Electrocatalyst for Oxygen Evolution Reaction , 2017 .