Are soft breakdown and hard breakdown of ultrathin gate oxides actually different failure mechanisms?

By means of a statistical analysis, the soft breakdown and hard breakdown of thin gate SiO/sub 2/ films in MOS devices are shown to have a common physical origin. Being triggered by identical microscopic defects, these breakdown modes can be actually considered to be the same failure mechanism. In particular, it is shown that the soft breakdown conduction path is not precursor of the final hard breakdown event, which generally appears at a different spatial location. The huge differences between the soft and hard post-breakdown current-voltage (I-V) characteristics are attributed to differences in the breakdown spot area and to point contact energy funneling effects.

[1]  R. Deal.  Simulation Modeling and Analysis (2nd Ed.) , 1994 .

[2]  Byung Jin Cho,et al.  Quasi-breakdown of ultrathin gate oxide under high field stress , 1994, Proceedings of 1994 IEEE International Electron Devices Meeting.

[3]  Jordi Suñé,et al.  Soft breakdown conduction in ultrathin (3-5 nm) gate dielectrics , 2000 .

[4]  D. Muller,et al.  The electronic structure at the atomic scale of ultrathin gate oxides , 1999, Nature.

[5]  J. Stathis,et al.  Reliability projection for ultra-thin oxides at low voltage , 1998, International Electron Devices Meeting 1998. Technical Digest (Cat. No.98CH36217).

[6]  Jordi Suñé,et al.  Modeling the breakdown spots in silicon dioxide films as point contacts , 1999 .

[7]  George A. Brown,et al.  Nonuniqueness of time-dependent-dielectric-breakdown distributions , 1997 .

[8]  Kenji Okada,et al.  New Experimental Findings on Stress Induced Leakage Current of Ultra Thin Silicon Dioxides , 1994 .

[9]  Gilles Reimbold,et al.  Light emission microscopy for thin oxide reliability analysis , 1997 .

[10]  Kenji Okada.  Extended TDDB Model Based on Anomalous Gate Area Dependence in Ultra Thin Silicon Dioxides , 1996 .

[11]  Jordi Suñé,et al.  On the breakdown statistics of very thin SiO2 films , 1990 .

[12]  Y. Uraoka,et al.  Evaluation of gate oxide reliability using luminescence method , 1990, Proceedings of the 1991 International Conference on Microelectronic Test Structures.

[13]  Differentiation between electric breakdowns and dielectric breakdown in thin silicon oxides , 1997, Proceedings of the 1997 6th International Symposium on the Physical and Failure Analysis of Integrated Circuits.

[14]  W. Abadeer,et al.  Structural dependence of dielectric breakdown in ultra-thin gate oxides and its relationship to soft breakdown modes and device failure , 1998, International Electron Devices Meeting 1998. Technical Digest (Cat. No.98CH36217).

[15]  J. Stathis,et al.  Ultimate limit for defect generation in ultra-thin silicon dioxide , 1997 .

[16]  Y. Taur,et al.  Quantum-mechanical modeling of electron tunneling current from the inversion layer of ultra-thin-oxide nMOSFET's , 1997, IEEE Electron Device Letters.

[17]  D. Hwang,et al.  Ultra-thin gate dielectrics: they break down, but do they fail? , 1997, International Electron Devices Meeting. IEDM Technical Digest.

[18]  M. Heyns,et al.  Soft Breakdown of Ultra-Thin Gate Oxide Layers , 1995, ESSDERC '95: Proceedings of the 25th European Solid State Device Research Conference.

[19]  Paul A. Solomon,et al.  Breakdown in silicon oxide−A review , 1977 .

[20]  I. Eisele,et al.  Influence of soft breakdown on NMOSFET device characteristics , 1999, 1999 IEEE International Reliability Physics Symposium Proceedings. 37th Annual (Cat. No.99CH36296).

[21]  Y. Uraoka,et al.  Evaluation technology of VLSI reliability using hot carrier luminescence , 1991 .

[22]  Ernest Y. Wu,et al.  Challenges for accurate reliability projections in the ultra-thin oxide regime , 1999, 1999 IEEE International Reliability Physics Symposium Proceedings. 37th Annual (Cat. No.99CH36296).

[23]  R. S. Scott,et al.  A model relating wearout to breakdown in thin oxides , 1994 .

[24]  Guido Groeseneken,et al.  A consistent model for the thickness dependence of intrinsic breakdown in ultra-thin oxides , 1995, Proceedings of International Electron Devices Meeting.

[25]  Jordi Suñé,et al.  Detection and fitting of the soft breakdown failure mode in MOS structures , 1999 .