Quantitative Viscosity Mapping Using Fluorescence Lifetime Measurements

Lubricant viscosity is a key driver in both the tribological performance and energy efficiency of a lubricated contact. Elastohydrodynamic (EHD) lubrication produces very high pressures and shear rates, conditions hard to replicate using conventional rheometry. In situ rheological measurements within a typical contact are therefore important to investigate how a fluid behaves under such conditions. Molecular rotors provide such an opportunity to extract the local viscosity of a fluid under EHD lubrication. The validity of such an application is shown by comparing local viscosity measurements obtained using molecular rotors and fluorescence lifetime measurements, in a model EHD lubricant, with reference measurements using conventional rheometry techniques. The appropriateness of standard methods used in tribology for high-pressure rheometry (combining friction and film thickness measurements) has been verified when the flow of EHD lubricant is homogeneous and linear. A simple procedure for calibrating the fluorescence lifetime of molecular rotors at elevated pressure for viscosity measurements is proposed.

[1]  Hugh Spikes,et al.  The Development of a Spacer Layer Imaging Method (SLIM) for Mapping Elastohydrodynamic Contacts , 1996 .

[2]  J. Bluet,et al.  Temperature and Viscosity Effects on the Photoluminescence Properties of Alkyl-Capped Silicon Nanoparticles Dispersed in Nonpolar Liquids , 2015 .

[3]  V. Uversky,et al.  High Fluorescence Anisotropy of Thioflavin T in Aqueous Solution Resulting from Its Molecular Rotor Nature. , 2016, Analytical chemistry.

[4]  Philippe Vergne,et al.  In-situ Pressure Measurements Using Raman Microspectroscopy in a Rolling Elastohydrodynamic Contact , 2002 .

[5]  K. Johnson,et al.  The Rheological Properties of Elastohydrodynamic Lubricants , 1986 .

[6]  Lowrie B. Sargent,et al.  Pressure-Viscosity Coefficients of Liquid Lubricants , 1983 .

[7]  T. Ban,et al.  Direct Observation of Amyloid Fibril Growth Monitored by Thioflavin T Fluorescence* 210 , 2003, The Journal of Biological Chemistry.

[8]  Hugh Spikes,et al.  Measurement of Sub-Nanometer Lubricant Films Using Ultra-Thin Film Interferometry , 2003 .

[9]  N. Amdursky,et al.  Pressure effect on the nonradiative process of thioflavin-T. , 2011, The journal of physical chemistry. A.

[10]  A. Ponjavic,et al.  Through-Thickness Velocity Profile Measurements in an Elastohydrodynamic Contact , 2013, Tribology Letters.

[11]  Hugh Spikes,et al.  History, Origins and Prediction of Elastohydrodynamic Friction , 2014, Tribology Letters.

[12]  A. Cameron,et al.  Optical Analysis of Ball Bearing Starvation , 1971 .

[13]  Scott Bair,et al.  “Recent Developments in High-Pressure Rheology of Lubricants” , 1995 .

[14]  R. Dwyer-Joyce,et al.  Viscosity Measurement in a Lubricant Film Using an Ultrasonically Resonating Matching Layer , 2015, Tribology Letters.

[15]  Ken Jacobson,et al.  Methods to measure the lateral diffusion of membrane lipids and proteins. , 2006, Methods.

[16]  S. Bair,et al.  An improved Yasutomi correlation for viscosity at high pressure , 2013 .

[17]  T. Charitat,et al.  A new tribological experimental setup to study confined and sheared monolayers. , 2016, The Review of scientific instruments.

[18]  J. Fareleira,et al.  Tris (2-Ethylhexyl) trimellitate (TOTM) a potential reference fluid for high viscosity. Part II: Density measurements at temperatures from (293 to 373)K and pressures up to 68MPa , 2014 .

[19]  D. Dowson,et al.  Isothermal Elastohydrodynamic Lubrication of Point Contacts: Part III—Fully Flooded Results , 1976 .

[20]  V. Uversky,et al.  Thioflavin T as a molecular rotor: fluorescent properties of thioflavin T in solvents with different viscosity. , 2008, The journal of physical chemistry. B.

[21]  M. Kuimova.  Mapping viscosity in cells using molecular rotors. , 2012, Physical chemistry chemical physics : PCCP.

[22]  A. Ponjavic,et al.  In situ viscosity measurement of confined liquids , 2015 .

[23]  S. Bair.  The high pressure rheology of some simple model hydrocarbons , 2002 .

[24]  W. Akers,et al.  A molecular rotor as viscosity sensor in aqueous colloid solutions. , 2004, Journal of biomechanical engineering.

[25]  Mark A. Haidekker,et al.  Dyes with Segmental Mobility: Molecular Rotors , 2010 .

[26]  M. Kuimova,et al.  Molecular rotor measures viscosity of live cells via fluorescence lifetime imaging. , 2008, Journal of the American Chemical Society.

[27]  N. Amdursky,et al.  Modeling the nonradiative decay rate of electronically excited thioflavin T. , 2011, The journal of physical chemistry. A.

[28]  Salmiah Kasolang,et al.  Viscosity measurement in thin lubricant films using shear ultrasonic reflection , 2008 .

[29]  N. Amdursky,et al.  Temperature dependence of the fluorescence properties of thioflavin-T in propanol, a glass-forming liquid. , 2011, The journal of physical chemistry. A.

[30]  J. Fareleira,et al.  Tris(2-ethylhexyl) trimellitate (TOTM) a potential reference fluid for high viscosity. Part I: Viscosity measurements at temperatures from (303 to 373) K and pressures up to 65MPa, using a novel vibrating-wire instrument , 2014 .

[31]  A. Ponjavic,et al.  Flow measurements of a polyphenyl ether oil in an elastohydrodynamic contact , 2016, Journal of physics. Condensed matter : an Institute of Physics journal.

[32]  J. Siegel,et al.  Application of the stretched exponential function to fluorescence lifetime imaging. , 2001, Biophysical journal.

[33]  Nabil Ahmed,et al.  Measurement of solution viscosity by atomic force microscopy , 2001 .

[34]  Farrukh Qureshi,et al.  The high pressure rheology of polymer-oil solutions , 2003 .