Effect of solid particles on gas holdup in flotation columns—II. Investigation of mechanisms of gas holdup reduction in presence of solids

Abstract Part I showed that the presence of solids decreased gas holdup under conditions typical of flotation in columns. Four mechanisms which might explain this effect are evaluated here: bubble coalescence, slurry density and viscosity changes, changes in radial gas holdup and flow profiles, and bubble wake effects. The first two cannot explain the holdup decrease but the second two can. It was shown experimentally that solids do not cause bubbles to coalesce in flotation columns. Using the drift flux model, changes in density and viscosity of the slurry due to the presence of solids could not account for the observed reduction in gas holdup. A drift flux analysis for the gas-slurry system suggested both that the holdup and flow were not distributed uniformly and that the bubbles rose more rapidly in the presence of solids. Two gas holdup and flow profiles were postulated which could account for the lower gas holdup. These profiles had an upward flow in the center of the collumn and an annular downward flow near the wall. The bubble wake mechanism postulates that wake stability is increased in the presence of solids due to increased viscosity. This, in turn, increases the probability of in line bubble-bubble interaction where the wake velocity of the leading bubble increases the rise velocity of the trailing bubble. The resulting higher rise velocity reduces the gas holdup. It is proposed that the effect of solids on reducing gas holdup is a combination of an increase in the rise velocity of bubbles due to stabilization of the bubble wake and a change in the holdup and flow profiles from flat to non-uniform.

[1]  Liang-Shih Fan,et al.  Bubble wake dynamics in liquids and liquid-solid suspensions , 1990 .

[2]  P. Carreau,et al.  Mixing characteristics and gas hold-up of a bubble column , 1986 .

[3]  C. Capes,et al.  Bed expansion and bubble wakes in three-phase fluidization , 1970 .

[4]  Martin E. Weber,et al.  Bubbles in viscous liquids: shapes, wakes and velocities , 1981, Journal of Fluid Mechanics.

[5]  J. Bridgwater,et al.  Bubble coalescence in viscous liquids , 1971 .

[6]  A. D. Young,et al.  An Introduction to Fluid Mechanics , 1968 .

[7]  James A. Finch,et al.  Measurement of gas holdup in a three-phase concurrent downflow column , 1992 .

[8]  Steven Beyerlein,et al.  Prediction of bubble concentration profiles in vertical turbulent two-phase flow , 1985 .

[9]  L. Fan,et al.  Hydrodynamics of a three-phase fluidized bed containing low-density particles , 1989 .

[10]  N. Nevers,et al.  Bubble coalescence in viscous fluids , 1971 .

[11]  James A. Finch,et al.  A conductivity technique for gas and solids holdup determination in three-phase reactors , 1994 .

[12]  M. Bergougnou,et al.  Bubble characteristic in three phase fluidized beds , 1977 .

[13]  L. Fan,et al.  Effect of turbulent wake on bubble—buble interaction in a gas—liquid—solid fluidized bed , 1991 .

[14]  H. Kumazawa,et al.  Influences of suspended fine particles on gas holdup and mass transfer characteristics in a slurry bubble column , 1986 .

[15]  J. J. Janssen,et al.  The influence of suspended solid material on the gas-liquid mass transfer in stirred gas-liquid contactors , 1977 .

[16]  I. Komasawa,et al.  WAKE BEHAVIOR AND ITS EFFECT ON INTERACTION BETWEEN SPHERICAL-CAP BUBBLES , 1980 .

[17]  G. Wallis.  One Dimensional Two-Phase Flow , 1969 .

[18]  R. Roscoe.  The viscosity of suspensions of rigid spheres , 1952 .

[19]  L. Fan,et al.  VISUALIZATION OF BUBBLE-WAKE INTERACTIONS FOR A STREAM OF BUBBLES IN A TWO-DIMENSIONAL LIQUID-SOLID FLUIDIZED BED , 1989 .

[20]  A. Dayan,et al.  Axial dispersion and enterainment of particles in wakes of bubbles , 1982 .

[21]  L. Fan,et al.  Effects of particle properties on bubble rise and wake in a two-dimensional liquid—solid fluidized bed , 1990 .

[22]  Martin E. Weber,et al.  In-line interaction of a pair of bubbles in a viscous liquid , 1980 .

[23]  Y. Kawase,et al.  MORE ON MIXING OF VISCOUS LIQUIDS IN BUBBLE COLUMNS , 1985 .

[24]  R. Worden,et al.  The effects of solids density and void fraction on the bubble rise velocity in a liquid-solid fluidized bed , 1992 .

[25]  S. Ottengraf,et al.  Wake phenomena behind spherical-cap bubbles and solid spherical-cap bodies , 1977 .

[26]  K. Østergaard,et al.  Characteristics of large two-dimensional air bubbles in liquids and in three-phase fluidised beds , 1974 .

[27]  R.I.L. Guthrie,et al.  Spherical capped gas bubbles rising in aqueous media , 1973 .

[28]  D. Geldart,et al.  Gas fluidization technology , 1986 .

[29]  S. Morooka,et al.  RECIRCULATING TURBULENT FLOW OF LIQUID IN GAS-LIQUID-SOLID FLUIDIZED BED , 1982 .

[30]  Donald A. Drew,et al.  Phase Distribution Mechanisms in Turbulent Two-Phase Flow in Channels of Arbitrary Cross Section , 1981 .

[31]  Liang-Shih Fan,et al.  Gas-Liquid-Solid Fluidization Engineering , 1989 .

[32]  James A. Finch,et al.  Measurement of radial gas holdup profiles in a flotation column , 1992 .

[33]  Sang D. Kim,et al.  Bubble characteristics in the radial direction of three-phase fluidized beds , 1988 .

[34]  James A. Finch,et al.  Estimation of Bubble Diameter in Flotation Columns from Drift Flux Analysis , 1988 .

[35]  Harvey W. Blanch,et al.  LIQUID CIRCULATION PATTERNS AND THEIR EFFECT ON GAS HOLD-UP AND AXIAL MIXING IN BUBBLE COLUMNS , 1983 .