Sustainable approaches for algae utilisation in bioenergy production

Rapidly increasing global energy consumption has caused depletion of fossil fuels, leading to the search of alternative energy resources. One of the potential solutions is utilizing algae biomass as the source of bioenergy. To fulfil the high biomass demands for biofuel production, it is of pivotal importance to develop feasible technologies to enable economic, efficient and high density cultivation of algae. Algae can be cultivated in either open or closed systems in the presence of nutrients and light intensity. The maximum yield, growth rate and composition of algae can be optimized according to cultivation conditions, such as temperature, pH, light intensity and nutrient concentration. The potential types of algae in contributing carbohydrate and lipids to produce biofuel such as biodiesel, bioethanol and bio-gas are reviewed. Economic feasibilities of algae based fuel production are discussed based on Life Cycle Analysis. Current challenges and future prospective are also presented to realize the use of algae as a feedstock for commercial and cost effective fuel production.

[1]  C. Banks,et al.  Algal growth response and survival in a range of light and temperature conditions: implications for non-steady-state conditions in waste stabilisation ponds. , 2007, Water science and technology : a journal of the International Association on Water Pollution Research.

[2]  Giuliano Dragone,et al.  Optimization of CO₂ bio-mitigation by Chlorella vulgaris. , 2013, Bioresource technology.

[3]  S. Olsen,et al.  A critical review of biochemical conversion, sustainability and life cycle assessment of algal biofuels , 2011 .

[4]  Q. Hu,et al.  Ultrahigh-cell-density culture of a marine green alga Chlorococcum littorale in a flat-plate photobioreactor , 1998, Applied Microbiology and Biotechnology.

[5]  Patrick J. McGinn,et al.  Screening microalgae strains for their productivity in methane following anaerobic digestion , 2013 .

[6]  C. Field,et al.  Greater Transportation Energy and GHG Offsets from Bioelectricity Than Ethanol , 2009, Science.

[7]  Minhua Zhang,et al.  Transesterification of rapeseed oil for biodiesel production in trickle-bed reactors packed with heterogeneous Ca/Al composite oxide-based alkaline catalyst. , 2013, Bioresource technology.

[8]  Noureen Fatima,et al.  Biodiesel production from green seaweed Ulva fasciata catalyzed by novel waste catalysts from Pakistan Steel Industry , 2016 .

[9]  Chen Guo,et al.  Improved algal oil production from Botryococcus braunii by feeding nitrate and phosphate in an airlift bioreactor , 2012 .

[10]  Tapaswy Muppaneni,et al.  Direct conversion of wet algae to crude biodiesel under supercritical ethanol conditions , 2014 .

[11]  Jose C. Merchuk,et al.  Comparison of photobioreactors for cultivation of the red microalga Porphyridium sp , 2000 .

[12]  R. Rengasamy,et al.  Mass culture of Botryococcus braunii Kutz. under open raceway pond for biofuel production. , 2012, Bioresource technology.

[13]  Md. Azhar Uddin,et al.  Hydrogen production from algal biomass via steam gasification. , 2014, Bioresource technology.

[14]  E. Gnansounou,et al.  Development of a novel sequential pretreatment strategy for the production of bioethanol from sugarcane trash. , 2016, Bioresource technology.

[15]  T. J. Fang,et al.  Antioxidant properties of a new antioxidative peptide from algae protein waste hydrolysate in different oxidation systems. , 2009, Bioresource technology.

[16]  Irini Angelidaki,et al.  Production of bioethanol from wheat straw: An overview on pretreatment, hydrolysis and fermentation. , 2010, Bioresource technology.

[17]  P. Anantharaman,et al.  Biochemical Composition of Seaweeds from Mandapam Coastal Regions along Southeast Coast of India , 2008 .

[18]  Halil Berberoglu,et al.  Reduction of water and energy requirement of algae cultivation using an algae biofilm photobioreactor. , 2012, Bioresource technology.

[19]  K. Fagerstedt,et al.  Macroalgae in biofuel production , 2015 .

[20]  Seung Gon Wi,et al.  Bioethanol production from the nutrient stress-induced microalga Chlorella vulgaris by enzymatic hydrolysis and immobilized yeast fermentation. , 2014, Bioresource technology.

[21]  B. Wang,et al.  Lewis acid-catalyzed in situ transesterification/esterification of microalgae in supercritical ethanol. , 2014, Bioresource technology.

[22]  Effects of nitrogen supplementation of the culture medium on the growth, total lipid content and fatty acid profiles of three microalgae (Tetraselmis subcordiformis, Nannochloropsis oculata and Pavlova viridis) , 2013, Journal of Applied Phycology.

[23]  P. Ekman,et al.  Effects of altered salinity, darkness and algal nutrient status on floridoside and starch content, α-galactosidase activity and agar yield of cultivated Gracilaria sordida , 1991 .

[24]  G. Qiu,et al.  Biochemical features and bioethanol production of microalgae from coastal waters of Pearl River Delta. , 2013, Bioresource technology.

[25]  Shu-wen Huang,et al.  Bioethanol production using carbohydrate-rich microalgae biomass as feedstock. , 2013, Bioresource technology.

[26]  Luísa Gouveia,et al.  Neochloris oleabundans UTEX #1185: a suitable renewable lipid source for biofuel production , 2009, Journal of Industrial Microbiology & Biotechnology.

[27]  Amy Cha-Tien Sun,et al.  Comparative cost analysis of algal oil production for biofuels , 2011 .

[28]  Y. Jeon,et al.  New candidate for biofuel feedstock beyond terrestrial biomass for thermo-chemical process (pyrolysis/gasification) enhanced by carbon dioxide (CO2). , 2012, Bioresource technology.

[29]  Jo‐Shu Chang,et al.  Effect of light supply and carbon source on cell growth and cellular composition of a newly isolated microalga Chlorella vulgaris ESP‐31 , 2010 .

[30]  Bingwen Yan,et al.  Production of algae-based biodiesel using the continuous catalytic Mcgyan process. , 2011, Bioresource technology.

[31]  J. Qin,et al.  Comparison of growth and lipid content in three Botryococcus braunii strains , 2005, Journal of Applied Phycology.

[32]  Raphael Slade,et al.  Micro-algae cultivation for biofuels: Cost, energy balance, environmental impacts and future prospects , 2013 .

[33]  M. Merzlyak,et al.  Effects of light intensity and nitrogen starvation on growth, total fatty acids and arachidonic acid in the green microalga Parietochloris incisa , 2008, Journal of Applied Phycology.

[34]  Steven Van Passel,et al.  A techno-economic assessment of an algal-based biorefinery , 2016, Clean Technologies and Environmental Policy.

[35]  M. Shariati,et al.  Dunaliella biotechnology: methods and applications , 2009, Journal of applied microbiology.

[36]  N. Trivedi,et al.  Solid state fermentation (SSF)-derived cellulase for saccharification of the green seaweed Ulva for bioethanol production , 2015 .

[37]  N. Bernet,et al.  Experimental study on a coupled process of production and anaerobic digestion of Chlorella vulgaris. , 2011, Bioresource technology.

[38]  Wei Zhang,et al.  Evaluation of filamentous green algae as feedstocks for biofuel production. , 2016, Bioresource technology.

[39]  Govinda R. Timilsina,et al.  Status and barriers of advanced biofuel technologies: A review , 2011 .

[40]  J. Harwood,et al.  The versatility of algae and their lipid metabolism. , 2009, Biochimie.

[41]  H. Oh,et al.  Comparison of several methods for effective lipid extraction from microalgae. , 2010, Bioresource technology.

[42]  Paul T. Williams,et al.  Catalytic hydrothermal gasification of algae for hydrogen production: composition of reaction products and potential for nutrient recycling. , 2013, Bioresource technology.

[43]  M. Lürling,et al.  Comparison of cyanobacterial and green algal growth rates at different temperatures , 2013 .

[44]  Song Xue,et al.  Increased lipid production of the marine oleaginous microalgae Isochrysis zhangjiangensis (Chrysophyta) by nitrogen supplement. , 2011, Bioresource technology.

[45]  Alper D Ozkan,et al.  Differential effects of nitrogen and sulfur deprivation on growth and biodiesel feedstock production of Chlamydomonas reinhardtii , 2012, Biotechnology and bioengineering.

[46]  Patrick E. Wiley,et al.  Research Spotlight: The future of biofuels: is it in the bag? , 2012 .

[47]  A. N. Boyce,et al.  Biodiesel Fuel Production from Algae as Renewable Energy , 2008 .

[48]  A. Meiser,et al.  A novel horizontal photobioreactor for high-density cultivation of microalgae. , 2015, Bioresource technology.

[49]  Jo‐Shu Chang,et al.  Microalgae-based carbohydrates for biofuel production , 2013 .

[50]  J. Pittman,et al.  The potential of sustainable algal biofuel production using wastewater resources. , 2011, Bioresource technology.

[51]  M. Rajashekhar,et al.  Effect of pH, salinity and temperature on the growth of six species of marine phytoplankton , 2014 .

[52]  T. Weisse,et al.  Effect of pH on growth, cell volume, and production of freshwater ciliates, and implications for their distribution , 2006 .

[53]  M. Borowitzka,et al.  Comparison of growth of Tetraselmis in a tubular photobioreactor (Biocoil) and a raceway pond , 2014, Journal of Applied Phycology.

[54]  Eun Yeol Lee,et al.  Chemo-enzymatic saccharification and bioethanol fermentation of lipid-extracted residual biomass of the microalga, Dunaliella tertiolecta. , 2013, Bioresource technology.

[55]  Allan Johansson,et al.  Can fuel-based energy production meet the challenge of fighting global warming — A chance for biomass and cogeneration? , 1993 .

[56]  Bruno Sialve,et al.  Anaerobic digestion of microalgal biomass: Challenges, opportunities and research needs. , 2015, Bioresource technology.

[57]  O. Kruse,et al.  Microalgae as substrates for fermentative biogas production in a combined biorefinery concept. , 2010, Journal of biotechnology.

[58]  M. Omid,et al.  A review of macroalgae production, with potential applications in biofuels and bioenergy , 2016 .

[59]  M. Demirbas,et al.  IMPORTANCE OF ALGAE OIL AS A SOURCE OF BIODIESEL , 2011 .

[60]  H. Ngo,et al.  A mini review on renewable sources for biofuel. , 2014, Bioresource technology.

[61]  K. Bišová,et al.  Accumulation of energy reserves in algae: From cell cycles to biotechnological applications. , 2015, Biotechnology advances.

[62]  Yan-ling Qiu,et al.  Effect of inoculum/substrate ratio on methane yield and orthophosphate release from anaerobic digestion of Microcystis spp. , 2010, Journal of hazardous materials.

[63]  D. Batten,et al.  Life cycle assessment of biodiesel production from microalgae in ponds. , 2011, Bioresource technology.

[64]  Jae Hwa Lee,et al.  Production of hydrogen from marine macro-algae biomass using anaerobic sewage sludge microflora , 2009 .

[65]  S. Ruangsomboon.  Effect of light, nutrient, cultivation time and salinity on lipid production of newly isolated strain of the green microalga, Botryococcus braunii KMITL 2. , 2012, Bioresource technology.

[66]  K. Yamaberi,et al.  Limited feeding of potassium nitrate for intracellular lipid and triglyceride accumulation of Nannochloris sp. UTEX LB1999 , 2000, Applied Microbiology and Biotechnology.

[67]  S. Chinnasamy,et al.  Microalgae cultivation in a wastewater dominated by carpet mill effluents for biofuel applications. , 2010, Bioresource technology.

[69]  H. Carrère,et al.  French Brittany macroalgae screening: composition and methane potential for potential alternative sources of energy and products. , 2013, Bioresource technology.

[70]  Jun Cheng,et al.  Co-generation of biohydrogen and biomethane through two-stage batch co-fermentation of macro- and micro-algal biomass. , 2016, Bioresource technology.

[71]  L. Rehmann,et al.  Butanol fermentation from microalgae-derived carbohydrates after ionic liquid extraction. , 2016, Bioresource technology.

[72]  Xuya Yu,et al.  Enhancing lipid productivity by co-cultivation of Chlorella sp. U4341 and Monoraphidium sp. FXY-10. , 2014, Journal of bioscience and bioengineering.

[73]  Y. J. Kim,et al.  Use of Gelidium amansii as a promising resource for bioethanol: a practical approach for continuous dilute-acid hydrolysis and fermentation. , 2012, Bioresource technology.

[74]  Chiun-Hsun Chen,et al.  Lipid accumulation and CO2 utilization of Nannochloropsis oculata in response to CO2 aeration. , 2009, Bioresource technology.

[75]  Rosalam Sarbatly,et al.  Conversion of microalgae to biofuel , 2012 .

[76]  Li-Hua Cheng,et al.  Enhanced lipid production of Chlorella vulgaris by adjustment of cultivation conditions. , 2010, Bioresource technology.

[77]  Chih-Sheng Lin,et al.  The air‐lift photobioreactors with flow patterning for high‐density cultures of microalgae and carbon dioxide removal , 2009 .

[78]  E. Bouwer,et al.  The effects of alternative pretreatment strategies on anaerobic digestion and methane production from different algal strains. , 2014, Bioresource technology.

[79]  Chuanping Feng,et al.  Inhibition of the growth of two blue-green algae species (Microsystis aruginosa and Anabaena spiroides) by acidification treatments using carbon dioxide. , 2011, Bioresource technology.

[80]  Hong-Ying Hu,et al.  Effects of different nitrogen and phosphorus concentrations on the growth, nutrient uptake, and lipid accumulation of a freshwater microalga Scenedesmus sp. , 2010, Bioresource technology.

[81]  Paul Chen,et al.  Characterization of a microalga Chlorella sp. well adapted to highly concentrated municipal wastewater for nutrient removal and biodiesel production. , 2011, Bioresource technology.

[82]  Yujie Feng,et al.  Lipid production of Chlorella vulgaris cultured in artificial wastewater medium. , 2011, Bioresource technology.

[83]  C. D. Miller,et al.  Optimization of wastewater microalgae saccharification using dilute acid hydrolysis for acetone, butanol, and ethanol fermentation. , 2015 .

[84]  S. Sim,et al.  Enzymatic pretreatment of Chlamydomonas reinhardtii biomass for ethanol production. , 2010, Bioresource technology.

[85]  K. Oh,et al.  Ethanol production from Saccharina japonica using an optimized extremely low acid pretreatment followed by simultaneous saccharification and fermentation. , 2013, Bioresource technology.

[86]  Phillip E. Savage,et al.  Biodiesel Production from Wet Algal Biomass through in Situ Lipid Hydrolysis and Supercritical Transesterification , 2010 .

[87]  A. Demirbas,et al.  Biodiesel from waste cooking oil via base-catalytic and supercritical methanol transesterification , 2009 .

[88]  Jo‐Shu Chang,et al.  Bioprocess development on microalgae-based CO2 fixation and bioethanol production using Scenedesmus obliquus CNW-N. , 2013, Bioresource technology.

[89]  R. Song,et al.  Coupling of the hydrogen and polyhydroxyalkanoates (PHA) production through anaerobic digestion from Taihu blue algae. , 2010, Bioresource technology.

[90]  Jo‐Shu Chang,et al.  Nitrogen starvation strategies and photobioreactor design for enhancing lipid content and lipid production of a newly isolated microalga Chlorella vulgaris ESP‐31: Implications for biofuels , 2011, Biotechnology journal.

[91]  Hee-Mock Oh,et al.  Selection of microalgae for lipid production under high levels carbon dioxide. , 2010, Bioresource technology.

[92]  S. Palani,et al.  Biodiesel production using chemical and biological methods – A review of process, catalyst, acyl acceptor, source and process variables , 2014 .

[93]  J. VanderGheynst,et al.  Virus infection of Chlorella variabilis and enzymatic saccharification of algal biomass for bioethanol production. , 2013, Bioresource technology.

[94]  Jo‐Shu Chang,et al.  Exploring the potential of using algae in cosmetics. , 2015, Bioresource technology.

[95]  Mark A. White,et al.  Comparison of algae cultivation methods for bioenergy production using a combined life cycle assessment and life cycle costing approach. , 2012, Bioresource technology.

[96]  John J. Milledge,et al.  Macroalgae-Derived Biofuel: A Review of Methods of Energy Extraction from Seaweed Biomass , 2014 .

[97]  Razif Harun,et al.  Exploring alkaline pre-treatment of microalgal biomass for bioethanol production , 2011 .

[98]  Jo‐Shu Chang,et al.  Cultivation, photobioreactor design and harvesting of microalgae for biodiesel production: a critical review. , 2011, Bioresource technology.

[99]  Rishi Gupta,et al.  Bioethanol production from Gracilaria verrucosa, a red alga, in a biorefinery approach. , 2013, Bioresource technology.

[100]  P. Wangikar,et al.  Extremophilic micro-algae and their potential contribution in biotechnology. , 2015, Bioresource technology.

[101]  A. Kiperstok,et al.  Comparative energy life-cycle analyses of microalgal biomass production in open ponds and photobioreactors. , 2010, Bioresource technology.

[102]  Wei Zhang,et al.  Biodiesel production from algae oil high in free fatty acids by two-step catalytic conversion. , 2012, Bioresource technology.

[103]  K. Rosentrater,et al.  Harvesting, oil extraction, and conversion of local filamentous algae growing in wastewater into biodiesel , 2013 .

[104]  A. Shilton,et al.  Wastewater treatment high rate algal ponds for biofuel production. , 2011, Bioresource technology.

[105]  Karseno,et al.  Effect of salt concentration on intracellular accumulation of lipids and triacylglyceride in marine microalgae Dunaliella cells. , 2006, Journal of bioscience and bioengineering.

[106]  M. Rai,et al.  Effect of Salinity, pH, Light Intensity on Growth and Lipid Production of Microalgae for Bioenergy Application , 2015 .

[107]  Shengjun Luo,et al.  Biomass and lipid production of marine microalgae using municipal wastewater and high concentration of CO2 , 2011 .

[108]  Julian N. Rosenberg,et al.  A green light for engineered algae: redirecting metabolism to fuel a biotechnology revolution. , 2008, Current opinion in biotechnology.

[109]  Md. Nurun Nabi,et al.  Improvement of engine emissions with conventional diesel fuel and diesel-biodiesel blends. , 2006, Bioresource technology.

[110]  Bai-cheng Zhou,et al.  Effect of iron on growth and lipid accumulation in Chlorella vulgaris. , 2008, Bioresource technology.

[111]  Willy Verstraete,et al.  Anaerobic digestibility of Scenedesmus obliquus and Phaeodactylum tricornutum under mesophilic and thermophilic conditions , 2012 .

[112]  Ganti S. Murthy,et al.  Effects of Environmental Factors and Nutrient Availability on the Biochemical Composition of Algae for Biofuels Production: A Review , 2013 .

[113]  B. Riaño,et al.  Saccharification of carbohydrates in microalgal biomass by physical, chemical and enzymatic pre-treatments as a previous step for bioethanol production , 2015 .

[114]  R. M. Willis,et al.  Biodiesel production by simultaneous extraction and conversion of total lipids from microalgae, cyanobacteria, and wild mixed-cultures. , 2011, Bioresource technology.

[115]  Song Xue,et al.  Enhancing starch production of a marine green microalga Tetraselmis subcordiformis through nutrient limitation. , 2012, Bioresource technology.

[116]  Gholamhassan Najafi,et al.  Algae as a sustainable energy source for biofuel production in Iran: A case study , 2011 .

[117]  YunJin-Ho,et al.  Freshwater Macroalgae as a Biofuels Feedstock: Mini-Review and Assessment of Their Bioenergy Potential , 2014 .

[118]  Duu-Jong Lee,et al.  Fermentative hydrogen production by Clostridium butyricum CGS5 using carbohydrate-rich microalgal biomass as feedstock , 2012 .

[119]  P. Biller,et al.  Potential yields and properties of oil from the hydrothermal liquefaction of microalgae with different biochemical content. , 2011, Bioresource technology.

[120]  Thomas H. Bradley,et al.  Microalgae to biofuels: life cycle impacts of methane production of anaerobically digested lipid extracted algae. , 2014, Bioresource technology.

[121]  C. Lan,et al.  Effects of nitrogen sources on cell growth and lipid accumulation of green alga Neochloris oleoabundans , 2008, Applied Microbiology and Biotechnology.

[122]  Jean-Philippe Steyer,et al.  Impact of microalgae characteristics on their conversion to biofuel. Part II: Focus on biomethane production , 2012 .

[123]  A. Converti,et al.  EFFECT OF TEMPERATURE AND NITROGEN CONCENTRATION ON THE GROWTH AND LIPID CONTENT OF NANNOCHLOROPSIS OCULATA AND CHLORELLA VULGARIS FOR BIODIESEL PRODUCTION , 2009 .

[124]  E. Fakhry,et al.  Lipid content and fatty acid composition of Mediterranean macro-algae as dynamic factors for biodiesel production , 2015 .

[125]  Reza Ranjbar,et al.  Large-scale biodiesel production using microalgae biomass of Nannochloropsis. , 2012 .

[126]  S. Okada,et al.  Culture of the hydrocarbon producing microalga Botryococcus braunii strain Showa: optimal CO2, salinity, temperature, and irradiance conditions. , 2013, Bioresource technology.

[127]  Ho Nam Chang,et al.  Ethanol production from marine algal hydrolysates using Escherichia coli KO11. , 2011, Bioresource technology.

[128]  Jo-Shu Chang,et al.  Biohydrogen production by a novel integration of dark fermentation and mixotrophic microalgae cultivation , 2013 .

[129]  Jo-Shu Chang,et al.  Effect of light intensity and nitrogen starvation on CO2 fixation and lipid/carbohydrate production of an indigenous microalga Scenedesmus obliquus CNW-N. , 2012, Bioresource technology.

[130]  Chih-Sheng Lin,et al.  Reduction of CO2 by a high-density culture of Chlorella sp. in a semicontinuous photobioreactor. , 2008, Bioresource technology.

[131]  Wenying Shi,et al.  Biodiesel production from soybean oil by quaternized polysulfone alkali-catalyzed membrane. , 2016, Bioresource technology.

[132]  P. Schenk,et al.  High Lipid Induction in Microalgae for Biodiesel Production , 2012 .

[133]  M. R. Suseela,et al.  Physico-Chemical Characterization of Algal oil: a Potential Biofuel , 2011 .

[134]  Baoming Li,et al.  Conversion efficiency and oil quality of low-lipid high-protein and high-lipid low-protein microalgae via hydrothermal liquefaction. , 2014, Bioresource technology.

[135]  Hu Hong-Ying,et al.  Growth and lipid accumulation properties of a freshwater microalga Scenedesmus sp. under different cultivation temperature. , 2011 .

[136]  T. Schaub,et al.  pH effects on growth and lipid accumulation of the biofuel microalgae Nannochloropsis salina and invading organisms , 2013, Journal of Applied Phycology.

[137]  G. Wikfors,et al.  Photoperiod and light intensity effects on growth and utilization of nutrients by the aquaculture feed microalga, Tetraselmis chui (PLY429) , 2005 .

[138]  M. G. Dastidar,et al.  Production and characterization of biodiesel from algae , 2014 .

[139]  Wei Zhang,et al.  The growth, lipid and hydrocarbon production of Botryococcus braunii with attached cultivation. , 2013, Bioresource technology.

[140]  Khanh-Quang Tran,et al.  Fast hydrothermal liquefaction for production of chemicals and biofuels from wet biomass - The need to develop a plug-flow reactor. , 2016, Bioresource technology.

[141]  Jong-In Han,et al.  Current status, issues and developments in microalgae derived biodiesel production , 2014 .

[142]  R. Sen,et al.  Raceway pond cultivation of a marine microalga of Indian origin for biomass and lipid production: A case study , 2014 .