Helicopter rotor blade computation in unsteady flows using moving overset grids

An overset grid thin-layer Navier-Stokes code has been extended to include dynamic motion of helicopter rotor blades through relative grid motion. The unsteady flowfield and airloads on an AH-IG rotor in forward flight were computed to verify the methodology and to demonstrate the method's potential usefulness towards comprehensive helicopter codes. In addition, the method uses the blade's first harmonics measured in the flight test to prescribe the blade motion. The solution was impulsively started and became periodic in less than three rotor revolutions. Detailed unsteady numerical flow visualization techniques were applied to the entire unsteady data set of five rotor revolutions and exhibited flowfield features such as blade vortex interaction and wake roll-up. The unsteady blade loads and surface pressures compare well against those from flight measurements. Details of the method, a discussion of the resulting predicted flowfield, and requirements for future work are presented. Overall, given the proper blade dynamics, this method can compute the unsteady flowfield of a general helicopter rotor in forward flight.

[1]  J. Baeder,et al.  Flowfield of a Lifting Rotor in Hover: A Navier-Stokes Simulation , 1992 .

[2]  Jeffrey L. Cross,et al.  Tabulation of data from the tip aerodynamics and acoustics test , 1990 .

[3]  R. Meakin.  Moving body overset grid methods for complete aircraft tiltrotor simulations , 1993 .

[4]  Philip L. Roe,et al.  A comparison of numerical flux formulas for the Euler and Navier-Stokes equations , 1987 .

[5]  J. Baeder,et al.  TURNS - A free-wake Euler/Navier-Stokes numerical method for helicopter rotors , 1993 .

[6]  H. Lomax,et al.  Thin-layer approximation and algebraic model for separated turbulent flows , 1978 .

[7]  Roger Strawn,et al.  The prediction of transonic loading advancing helicopter rotors , 1986 .

[8]  David A. Lane.  UFAT-a particle tracer for time-dependent flow fields , 1994, Proceedings Visualization '94.

[9]  W. Johnson,et al.  CAMRAD - A COMPREHENSIVE ANALYTICAL MODEL OF ROTORCRAFT AERODYNAMICS AND DYNAMICS , 1994 .

[10]  Pieter G. Buning,et al.  User's manual for the HYPGEN hyperbolic grid generator and the HGUI graphical user interface , 1993 .

[11]  Wayne Johnson,et al.  Correlation of airloads on a two-bladed helicopter rotor , 1991 .

[12]  Farid M. L. Amirouche,et al.  Computational Methods in Multibody Dynamics , 1992 .

[13]  Alan Jones,et al.  Correlation of Puma airloads: Evaluation of CFD prediction methods , 1989 .

[14]  F. X. Caradonna,et al.  Free-wake computation of helicopter rotor flowfields in forward flight , 1993 .

[15]  Seokkwan Yoon,et al.  An LU-SSOR scheme for the Euler and Navier-Stokes equations , 1987 .

[16]  Jerry Deese,et al.  An Euler solver for calculating the flowfield of a helicopter rotor in hover and forward flight , 1987 .

[17]  E. Duque,et al.  Numerical simulation of a hovering rotor using embedded grids , 1992 .

[18]  S. Obayashi,et al.  Numerical solutions of forward-flight rotor flow using an upwind method , 1989 .

[19]  J. Ahmad,et al.  Navier-Stokes simulation of rotor-body flowfield in hover using overset grids , 1993 .