Experimental investigation on a vertical display cabinet with central air supply

Abstract The frosting and defrosting of air cooler in a display cabinet usually lead to a large temperature fluctuation, thus increase the energy consumption of the display cabinet. In this paper, a vertical display cabinet with central air supply (VDCCAS) is established, experimented and compared with a conventional vertical display cabinet (CVDC). The refrigeration system of the VDCCAS consisting of a compressor, a condenser, a thermostatic expansion valve (TEV) and an evaporator is independent of the cabinet in a VDCCAS, and the cold air cooled by the evaporator is supplied through the air duct to the cabinet to realize refrigeration. Comparing to the CVDC, the VDCCAS can easily control the air curtain velocity, decrease the frost magnitude, increase the defrost cycle from 6 h to 9 h, and reduce the maximum product temperature rise in the defrost cycle from 3.0 °C to 2.0 °C. To reach the lowest temperature distribution in the cabinet, the optimum velocity of the air curtain is 0.7–0.8 m/s and the optimum Reynolds number is 4350–5000. When two cabinets work together, the airflow ratio of the two cabinets should be 1.1–1.2 in order to keep the temperature balance between the two cabinets.

[1]  Morteza Gharib,et al.  The Application of Advanced Methods in Analyzing the Performance of the Air Curtain in a Refrigerated Display Case , 2002 .

[2]  Pradeep Bansal,et al.  MEPR versus EEPR valves in open supermarket refrigerated display cabinets , 2005 .

[3]  R. Faramarzi,et al.  Comparing older and newer refrigerated display cases , 1999 .

[4]  Yunguang Chen,et al.  Simulation of a cavity insulated by a vertical single band cold air curtain , 2005 .

[5]  Judith Evans,et al.  Development of a novel multi-capillary, multi-temperature commercial refrigerator cabinet with common low-pressure receiver , 2008 .

[6]  Brenda S. Henderson,et al.  Jet entrainment rate in air curtain of open refrigerated display cases , 2005 .

[7]  R. W. James,et al.  Analysis of the expansion valves used for controlling refrigerant feed into delicatessen cabinets in supermarkets , 1999 .

[8]  Ramin Faramarzi.  Efficient Display Case Refrigeration , 1999 .

[9]  Guoliang Ding,et al.  Modified two-fluid model for air curtains in open vertical display cabinets , 2008 .

[10]  Kandadai Srinivasan,et al.  Improvement of air distribution in refrigerated vertical open front remote supermarket display cases , 2008 .

[11]  Savvas A. Tassou,et al.  Simulation of the performance of single jet air curtains for vertical refrigerated display cabinets , 2001 .

[12]  M. Manzan,et al.  CFD simulation of refrigerated display cabinets , 2001 .

[13]  Yun-Guang Chen,et al.  Experimental study of the performance of single-band air curtains for a multi-deck refrigerated display cabinet , 2005 .

[14]  Giovanni Cortella,et al.  cfd-aided retail cabinets design , 2002 .

[15]  Brandon S. Field,et al.  Entrainment of refrigerated air curtains down a wall , 2006 .

[16]  Savvas A. Tassou,et al.  Influence of supermarket environmental parameters on the frosting and defrosting of vertical multideck display cabinets , 1999 .

[17]  Guoliang Ding,et al.  Simulation of air curtains for vertical display cases with a two-fluid model , 2007 .