Design and Balance-of-Plant of a Demonstration Plant With a Solid Oxide Fuel Cell Fed by Biogas From Waste-Water and Exhaust Carbon Recycling for Algae Growth

The design and balance-of-plant of an integrated anaerobic digestion (AD) biogas solid oxide fuel cell (SOFC) demonstration plant is presented. A notable feature of the plant is the CO2 capture from the SOFC anode exhaust via an oxy-combustion reactor. The captured CO2 is fed to a photobioreactor installation downstream of the SOFC where C is fixed in an algae bio-fuel.The main plant sections are described in detail including the gas cleaning unit, fuel processing, SOFC ‘hot-box’, oxy-combustor, CO2/H2O condensation unit and finally algae bioreactor.The demonstration plant is fed with biogas from AD of the by-product sludge of the greatest waste-water treatment plant in Italy, serving over 2 million population equivalents in the Torino metropolitan area.In this work, the main BoP components and engineering issues concerning the design of the SOFC plant are detailed. The as-produced biogas is firstly treated to remove moisture and then filtered to remove sulfur, halogens and siloxanes. Dry clean biogas (roughly 60–65% CH4, 35–40% CO2) is sent to a steam-reformer. The reformate gas is thus used to feed a 2 kWe SOFC module (operated at ∼ 800 °C). The cathode off-gas is kept separated from the anode and is used to pre-heat inlet fresh air; the anode outlet stream is sent first to an oxy-combustor to yield an almost pure H2O-CO2 mixture that is eventually cooled down to 300–400 °C. Steam is condensed and separated in a dedicated condenser unit. The resulting pure CO2 is thus pressurized (8 bar) and available for sequestration or other uses. Due to the limited size of the demo plant, the choice was to feed it to bioreactors with algae, where the latter are grown with sunlight and CO2 indeed. A tubular photo-bioreactor has been chosen with a productivity of 20 g/day/m2 of dry algae. The outlet stream will be an algae purge that, due to its low mass flow, could be re-sent to the biogas digesters.A system analysis of a scaled-up version of the biogas fed SOFC power plant, with heat integration included, is also carried out with a calculated overall electrical efficiency exceeding 55% (LHV basis).Copyright © 2013 by ASME

[1]  Jan Van herle,et al.  Biogas as a fuel source for SOFC co-generators , 2004 .

[2]  Zacharie Wuillemin,et al.  Experimental and modeling investigations on local performance and local degradation in solid oxide fuel cells , 2009 .

[3]  Roberto Bove,et al.  Analysis of a solid oxide fuel cell system for combined heat and power applications under non-nominal conditions , 2007 .

[4]  Robert J. Braun,et al.  Techno-economic analysis of solid oxide fuel cell-based combined heat and power systems for biogas utilization at wastewater treatment facilities , 2013 .

[5]  Pere Margalef,et al.  Conceptual design and configuration performance analyses of polygenerating high temperature fuel cells , 2011 .

[6]  M. Jamalabadi,et al.  Electrochemical and Exergetic Modeling of a Combined Heat and Power System Using Tubular Solid Oxide Fuel Cell and Mini Gas Turbine , 2013 .

[7]  Pere Margalef,et al.  Efficiency comparison of tri-generating HTFC to conventional hydrogen production technologies , 2012 .

[8]  Thomas Pfeifer,et al.  System design and process layout for a SOFC micro-CHP unit with reduced operating temperatures , 2013 .

[9]  Ricardo Chacartegui,et al.  Potential of molten carbonate fuel cells to enhance the performance of CHP plants in sewage treatment facilities , 2013 .

[10]  Jack Brouwer,et al.  Hybrid Fuel Cell Gas Turbine System Design and Optimization , 2013 .

[11]  Ping Yuan,et al.  Performance Optimization and Selection of Operating Parameters for a Solid Oxide Fuel Cell Stack , 2013 .

[12]  S. Ebbesen,et al.  Co-electrolysis of CO2 and H2O in solid oxide cells: Performance and durability , 2011 .

[13]  Shabbir Ahmed,et al.  Fuel quality issues with biogas energy – An economic analysis for a stationary fuel cell system , 2012 .

[14]  Özgün Selvi,et al.  Design and Thermodynamic Analysis of an SOFC System for Naval Surface Ship Application , 2013 .

[15]  Andrea Lanzini,et al.  Experimental Modeling of Transients in Large SOFC Systems , 2013 .

[16]  François Maréchal,et al.  Energy balance model of a SOFC cogenerator operated with biogas , 2003 .

[17]  François Maréchal,et al.  Process flow model of solid oxide fuel cell system supplied with sewage biogas , 2004 .

[18]  Jianguo Yu,et al.  Numerical Analysis of the Possibility of Carbon Formation in Planar SOFC Fueled With Syngas , 2012 .

[19]  M. Marinšek,et al.  Deactivation of Ni-YSZ Material in Dry Methane and Oxidation of Various Forms of Deposited Carbon , 2012 .

[20]  Pere Margalef,et al.  Efficiency of poly-generating high temperature fuel cells , 2011 .

[21]  Franco Biasioli,et al.  Monitoring of volatile compound emissions during dry anaerobic digestion of the Organic Fraction of Municipal Solid Waste by Proton Transfer Reaction Time-of-Flight Mass Spectrometry. , 2012, Bioresource technology.

[22]  A. Faaij,et al.  Competitiveness of CO2 capture from an industrial solid oxide fuel cell combined heat and power system in the early stage of market introduction , 2011 .