Water adsorption and its impact on the pore structure characteristics of shale clay

Abstract Water is considered ubiquitous within the shale reservoirs and mainly stored in the hydrophilic clay minerals. The water distribution characteristics and its effect on pore structure are important for the gas-in-place of shale systems. In this work, water vapor adsorption on montmorillonite (Mt), kaolinite (Kaol) and illite (Il) were performed to investigate the behaviors of water adsorption on shale clay. Subsequently, the moisture-equilibrated samples were conducted with N2 gas-adsorption techniques to investigate the effect of adsorbed water on pore structure characteristics, such as apparent pore size distribution (APSD), N2 BET specific surface area (N2-BET SSA) and pore volume (PV). The results show that the water uptake isotherms of our samples have the sigmoidal-shaped profiles and GAB model provides a good fit for the adsorption behavior. In addition, The APSD curves under different relative humidity (RH) conditions have validated the condensation effect and indicated that the small pores (approximately smaller than 5 nm) are blocked by the capillary water and will disappear on the APSD curves at RH of 98% while the large nanopores (> 5 nm) are covered with water film, these effects will lead dramatically decrease of N2-BET SSA. Taking Mt and Il samples as the examples, the N2-BET SSA has declined to 33.51% and 33.66% compared with the dry conditions when Sw approaches to 50%. Meanwhile, these effects also indicate that the gas storage for clay minerals is massively overestimating under dry condition, the contribution to methane adsorption might be negligible in the actual shale reservoir.

[1]  Hassan Dehghanpour,et al.  Water sorption behaviour of gas shales: I. Role of clays , 2017 .

[2]  R. Marc Bustin,et al.  Lower Cretaceous gas shales in northeastern British Columbia, Part I: geological controls on methane sorption capacity , 2008 .

[3]  R. Marc Bustin,et al.  The importance of shale composition and pore structure upon gas storage potential of shale gas reservoirs , 2009 .

[4]  Yao Huang,et al.  A Semianalytical Methodology To Diagnose the Locations of Underperforming Hydraulic Fractures Through Pressure-Transient Analysis in Tight Gas Reservoir , 2017 .

[5]  Fengrui Sun,et al.  Apparent permeability model for real gas transport through shale gas reservoirs considering water distribution characteristic , 2017 .

[6]  H. Dehghanpour,et al.  Water sorption behaviour of gas shales: II. Pore size distribution , 2017 .

[7]  C. P. Fernandes,et al.  Characterization of Brazilian tight gas sandstones relating permeability and Angstrom-to micron-scale pore structures , 2015 .

[8]  Dong Liu,et al.  High-pressure adsorption of methane on montmorillonite, kaolinite and illite , 2013 .

[9]  D. Bessieres,et al.  Effect of thermal events on maturation and methane adsorption of Silurian black shales (Checa, Spain) , 2017 .

[10]  Chang Q. Sun,et al.  Density and Phonon-Stiffness Anomalies of Water and Ice in the Full Temperature Range. , 2012, The journal of physical chemistry letters.

[11]  G. Halsey,et al.  Physical Adsorption on Non‐Uniform Surfaces , 1948 .

[12]  M. Bustin,et al.  The effects and distribution of moisture in gas shale reservoir systems , 2010 .

[13]  Stephen C. Ruppel,et al.  Spectrum of pore types and networks in mudrocks and a descriptive classification for matrix-related mudrock pores , 2012 .

[14]  Tongwei Zhang,et al.  Experimental investigation of main controls to methane adsorption in clay-rich rocks , 2012 .

[15]  Daniel M. Jarvie,et al.  Shale Resource Systems for Oil and Gas: Part 1—Shale-gas Resource Systems , 2012 .

[16]  Fengpeng Lai,et al.  Experimental Investigation of Spontaneous Imbibition in a Tight Reservoir with Nuclear Magnetic Resonance Testing , 2016 .

[17]  Tongwei Zhang,et al.  Effect of organic-matter type and thermal maturity on methane adsorption in shale-gas systems , 2012 .

[18]  J. Robert,et al.  Hydration Properties and Interlayer Organization of Water and Ions in Synthetic Na-Smectite with Tetrahedral Layer Charge. Part 1. Results from X-ray Diffraction Profile Modeling , 2010 .

[19]  Christopher R. Clarkson,et al.  Pore structure characterization of North American shale gas reservoirs using USANS/SANS, gas adsorption, and mercury intrusion , 2013 .

[20]  Yuedong Yao,et al.  The flow and heat transfer characteristics of superheated steam in concentric dual-tubing wells , 2017 .

[21]  Y. Gensterblum,et al.  High-Pressure Methane Sorption Isotherms of Black Shales from The Netherlands , 2012 .

[22]  A. Louis-Joseph,et al.  Dynamics and Wettability of Oil and Water in Oil Shales , 2014 .

[23]  Javier Pérez-Ramírez,et al.  Pore size determination in modified micro- and mesoporous materials. Pitfalls and limitations in gas adsorption data analysis , 2003 .

[24]  C. Johnston,et al.  Infrared Study of Water Sorption on Na-, Li-, Ca-, and Mg-Exchanged (SWy-1 and SAz-1) Montmorillonite , 2000 .

[25]  Shimin Liu,et al.  Pore characterization and its impact on methane adsorption capacity for organic-rich marine shales , 2016 .

[26]  Wang Maozhe.  Pore Characteristics and Methane Adsorption of Clay Minerals in Shale Gas Reservoir , 2015 .

[27]  S. Henderson.  A basic concept of equilibrium moisture , 1952 .

[28]  A. Firoozabadi,et al.  Effect of water on methane and carbon dioxide sorption in clay minerals by Monte Carlo simulations , 2014 .

[29]  Xianfeng Liu,et al.  Effect of pore characteristics on coalbed methane adsorption in middle-high rank coals , 2016, Adsorption.

[30]  Jean-Maurice Cases,et al.  Mechanism of adsorption and desorption of water vapor by homoionic montmorillonite. 1. The sodium-exchanged form , 1992 .

[31]  J. Douillard,et al.  On the cation dependence of interlamellar and interparticular water and swelling in smectite clays. , 2010, Langmuir : the ACS journal of surfaces and colloids.

[32]  D. Do,et al.  Adsorption analysis : equilibria and kinetics , 1998 .

[33]  Keliu Wu,et al.  Thickness and stability of water film confined inside nanoslits and nanocapillaries of shale and clay , 2017 .

[34]  J. Curtis.  Fractured shale-gas systems , 2002 .

[35]  Yanming Zhu,et al.  Micro and nano-size pores of clay minerals in shale reservoirs: Implication for the accumulation of shale gas , 2016 .

[36]  Mian Chen,et al.  Water activity characteristics of deep brittle shale from Southwest China , 2015 .

[37]  Yuedong Yao,et al.  The mass and heat transfer characteristics of superheated steam coupled with non-condensing gases in perforated horizontal wellbores , 2017 .

[38]  R. Littke,et al.  High pressure methane sorption characteristics of lacustrine shales from the Midland Valley Basin, Scotland , 2016 .

[39]  R. Littke,et al.  The role of pre-adsorbed water on methane sorption capacity of Bossier and Haynesville shales , 2015 .

[40]  Jing Li,et al.  Capillary filling under nanoconfinement: The relationship between effective viscosity and water-wall interactions , 2018 .

[41]  Youwei He,et al.  Waterflood Direction and Front Characterization With Four-Step Work Flow: A Case Study in Changqing Oil Field, China , 2017 .

[42]  Q. Lan,et al.  Spontaneous Imbibition of Brine and Oil in Gas Shales: Effect of Water Adsorption and Resulting Microfractures , 2013 .

[43]  S. Gaboreau,et al.  Optimization of pore-network characterization of a compacted clay material by TEM and FIB/SEM imaging , 2015 .

[44]  J. Baltrusaitis,et al.  Water adsorption on clay minerals as a function of relative humidity: application of BET and Freundlich adsorption models. , 2012, Langmuir : the ACS journal of surfaces and colloids.

[45]  D. Mccarty,et al.  Surface area and layer charge of smectite from CEC and EGME/H2O-retention measurements , 2008 .

[46]  J. P. Olivier,et al.  Physisorption of gases, with special reference to the evaluation of surface area and pore size distribution (IUPAC Technical Report) , 2015 .

[47]  The Ice/Water Interface: Density–Temperature Phase Diagram for the SPC/E Model of Liquid Water , 2004 .

[48]  K. Hayes,et al.  X-ray absorption spectroscopy study of Cu(II) coordination in the interlayer of montmorillonite , 2015 .

[49]  J. Chirife,et al.  Equations for fitting water sorption isotherms of foods: Part 1 — a review , 2007 .

[50]  B. Rotenberg,et al.  Hydrodynamics in Clay Nanopores , 2011 .

[51]  Dong Liu,et al.  Effects of microstructure of clay minerals, montmorillonite, kaolinite and halloysite, on their benzene adsorption behaviors , 2017 .

[52]  Zhangxin Chen,et al.  Model for Surface Diffusion of Adsorbed Gas in Nanopores of Shale Gas Reservoirs , 2015 .

[53]  Zhangxin Chen,et al.  A Model for Multiple Transport Mechanisms Through Nanopores of Shale Gas Reservoirs with Real Gas Effect-Adsorption-Mechanic Coupling , 2016 .

[54]  Hassan Dehghanpour,et al.  Liquid Intake of Organic Shales , 2012 .

[55]  Keliu Wu,et al.  Water distribution characteristic and effect on methane adsorption capacity in shale clay , 2016 .

[56]  Joan E. Shields,et al.  Characterization of Porous Solids and Powders: Surface Area, Pore Size and Density , 2006 .

[57]  J. DeBoer.  The Dynamical Character of Adsorption , 1953 .

[58]  L. Michot,et al.  Mechanism of Adsorption and Desorption of Water Vapor by Homoionic Montmorillonite: 3. The Mg2+, Ca2+, Sr2+ and Ba2+ Exchanged Forms , 1997 .

[59]  Jing Li,et al.  Wettability effect on nanoconfined water flow , 2017, Proceedings of the National Academy of Sciences.

[60]  Bernhard M. Krooss,et al.  Geological controls on the methane storage capacity in organic-rich shales , 2014 .

[61]  E. Teller,et al.  ADSORPTION OF GASES IN MULTIMOLECULAR LAYERS , 1938 .

[62]  Xiong Jian,et al.  Investigation of pore structure and fractal characteristics of organic-rich Yanchang formation shale in central China by nitrogen adsorption/desorption analysis , 2015 .

[63]  C. R. Oswin.  The kinetics of package life. III. The isotherm , 1946 .

[64]  Stuart Day,et al.  Supercritical gas sorption on moist coals , 2008 .

[65]  U. Kuila,et al.  Specific surface area and pore‐size distribution in clays and shales , 2013 .

[66]  Jennifer D. Schuttlefield,et al.  An investigation of water uptake on clays minerals using ATR‐FTIR spectroscopy coupled with quartz crystal microbalance measurements , 2007 .

[67]  J. Sghaier,et al.  Water Sorption Isotherms and Thermodynamic Characteristics of Hardened Cement Paste and Mortar , 2016, Transport in Porous Media.

[68]  B. Lanson,et al.  Investigation of smectite hydration properties by modeling experimental X-ray diffraction patterns: Part I. Montmorillonite hydration properties , 2005 .

[69]  E. Barrett,et al.  (CONTRIBUTION FROM THE MULTIPLE FELLOWSHIP OF BAUGH AND SONS COMPANY, MELLOX INSTITUTE) The Determination of Pore Volume and Area Distributions in Porous Substances. I. Computations from Nitrogen Isotherms , 1951 .

[70]  V. Karathanos.  Determination of water content of dried fruits by drying kinetics , 1999 .

[71]  R. M. Barrer,et al.  Sorption and intercalation by methyl-ammonium montmorillonites , 1957 .

[72]  J. H. de Boer,et al.  The dynamical character of adsorption , 1968 .

[73]  Jing Li,et al.  Flow behavior of gas confined in nanoporous shale at high pressure: Real gas effect , 2017 .

[74]  D. Chung,et al.  Adsorption and Desorption of Water Vapor by Cereal Grains and Their Products Part II: Development of the General Isotherm Equation , 1967 .

[75]  P. Gane,et al.  Pore wall rugosity: The role of extended wetting contact line length during spontaneous liquid imbibition in porous media , 2014 .