The pressure fluctuation caused by unsteady flow in runner is one of the main reasons of vibration for a large Francis hydraulic turbine. It directly affects the steady operation of the hydraulic turbine unit. The existing research of the pressure fluctuation in hydraulic turbine mainly focuses on the unsteady flow in draft tube. Accurate distribution of pressure fluctuations inside a runner is not very clear. In this paper, the numerical method for predicting the pressure fluctuations in runner is investigated and the numerical simulation is performed for a large Francis hydraulic turbine. It is proved that the combination of shear-stress transport(SST) k-ω turbulence model and pressure-implicit with splitting of operators(PISO) algorithm could give more reliable prediction of pressure fluctuations in runner. The frequencies of pressure fluctuations in runner are affected by the flow in guide vane and the flow in draft tube. The first dominant frequency is significantly determined by the flow in draft tube, especially at part load condition. This frequency is approximately equal to one-third of the runner rotating frequency. The evident second dominant frequency is exactly equal to the guide vane passing frequency. The peak-to-peak amplitudes of pressure fluctuations in runner at small guide vane open angle are larger than that at large open angle at the same operating head. The amplitudes at points on blade pressure surface are generally greater than that on suction surface. The research results could be used to direct the hydraulic design and operation stability improvement of a large Francis hydraulic turbine.
[1]
Yuliang Zhu,et al.
Numerical Simulation of Pressure Fluctuation in Draft Tube of Large Francis Turbine
,
2007
.
[2]
François Avellan,et al.
Analysis of the Swirling Flow Downstream a Francis Turbine Runner
,
2006
.
[3]
Lingjiu Zhou,et al.
Simulations and Measurements of Pressure Oscillations Caused by Vortex Ropes
,
2006
.
[4]
Liu Shuhong.
Correlation analysis of the internal vortex flow of hydro turbine with the pressure fluctuation inside draft tube
,
2007
.
[5]
B. D. Marjavaara,et al.
Parallel CFD simulations of an original and redesigned hydraulic turbine draft tube
,
2007,
Adv. Eng. Softw..
[6]
Weili Liao.
Unsteady Flow Analysis of Francis Turbine
,
2009
.
[7]
Håkan Nilsson,et al.
Validations of CFD against detailed velocity and pressure measurements in water turbine runner flow
,
2003
.
[8]
Fotis Sotiropoulos,et al.
Numerical Simulation of Swirling Flow in Complex Hydroturbine Draft Tube Using Unsteady Statistical Turbulence Models
,
2005
.
[9]
F. Avellan,et al.
Analysis of the Cavitating Draft Tube Vortex in a Francis Turbine Using Particle Image Velocimetry Measurements in Two-Phase Flow
,
2008
.
[10]
Fujun Wang,et al.
Experimental Investigation of Characteristic Frequency in Unsteady Hydraulic Behaviour of a Large Hydraulic Turbine
,
2009
.
[11]
Yuliang Zhu,et al.
Experimental Investigation of Pressure Fluctuation and Vibration in a Large Francis Turbine
,
2007
.