Online health monitoring of a fuel cell using total harmonic distortion analysis

Abstract The present work aims to show the nonlinear behavior of a PEM fuel cell under different mass transport conditions. Understanding this behavior helps in online state-of-health monitoring and control of a fuel cell stack. To analyze the health of an operating stack, a total harmonic distortion analysis (THDA) system requires only the sum of voltages or currents of the stack to be monitored. A low-frequency current or voltage signal is impressed on the fuel cell stack, and the resulting voltage or current signal is measured. To determine any change in harmonics, the measured signal is processed with a harmonic analyzer. The operational states of individual cells of the fuel cell stack may be inferred from at least one change in the harmonic content of the impressed signal. The mass transport problem related to the cathode and anode is distinguished using mixed-frequency signals. The present study found experimentally that hydrogen starvation is dominantly observed in the harmonic analysis only below a frequency of 15 Hz, whereas air starvation showed harmonic changes at frequencies below 100 Hz. Total harmonic distortions were observed to rise to 2–2.5% under both the starvation conditions but with different frequency signals.

[1]  Torsten Berning,et al.  Improving the performance of high-temperature PEM fuel cells based on PBI electrolyte , 2006 .

[2]  R. Hanke-Rauschenbach,et al.  Total harmonic distortion analysis for direct methanol fuel cell anode , 2010 .

[3]  Ronghuan He,et al.  Integration of high temperature PEM fuel cells with a methanol reformer , 2005 .

[4]  H. R. Kunz,et al.  Operation of PEM fuel cells at 120–150 °C to improve CO tolerance , 2006 .

[5]  Ronghuan He,et al.  The CO Poisoning Effect in PEMFCs Operational at Temperatures up to 200°C , 2003 .

[6]  Yun Wang,et al.  A review of polymer electrolyte membrane fuel cells: Technology, applications,and needs on fundamental research , 2011 .

[7]  Ulrike Krewer,et al.  Sensing methanol concentration in direct methanol fuel cell with total harmonic distortion: Theory and application , 2012 .

[8]  Ulrike Krewer,et al.  Total harmonic distortion analysis of oxygen reduction reaction in proton exchange membrane fuel cells , 2013 .

[9]  C. M. Rangel,et al.  High performance PEMFC stack with open-cathode at ambient pressure and temperature conditions , 2007 .

[10]  A. Reis,et al.  Experimental evaluation of CO poisoning on the performance of a high temperature proton exchange membrane fuel cell , 2009 .

[11]  Mina Hoorfar,et al.  Study of proton exchange membrane fuel cells using electrochemical impedance spectroscopy technique – A review , 2013 .

[12]  James Larminie,et al.  Fuel Cell Systems Explained: Larminie/Fuel Cell Systems Explained , 2003 .

[13]  Søren Knudsen Kær,et al.  Modelling and evaluation of heating strategies for high temperature polymer electrolyte membrane fuel cell stacks , 2008 .

[14]  Jesse S. Wainright,et al.  A H2O2 fuel cell using acid doped polybenzimidazole as polymer electrolyte , 1996 .

[15]  Viktor Hacker,et al.  Detection of fuel cell critical status by stack voltage analysis , 2006 .

[16]  Søren Knudsen Kær,et al.  Part two: Control of a novel HTPEM-based micro combined heat and power fuel cell system , 2008 .

[17]  S. Kær,et al.  400 W High Temperature PEM Fuel Cell Stack Test , 2007 .

[18]  Hui Li.  PEM Fuel Cell Diagnostic Tools , 2011 .

[19]  James M. Fenton,et al.  Influence of temperature and relative humidity on performance and CO tolerance of PEM fuel cells with Nafion®–Teflon®–Zr(HPO4)2 higher temperature composite membranes , 2006 .

[20]  Thomas J. Schmidt,et al.  Properties of high-temperature PEFC Celtec®-P 1000 MEAs in start/stop operation mode , 2008 .

[21]  L. Arriaga,et al.  Impedance spectroscopy as a tool in the evaluation of MEA's , 2003 .

[22]  Dirk Riemann,et al.  Low temperature operation and influence parameters on the cold start ability of portable PEMFCs , 2006 .

[23]  Jesse S. Wainright,et al.  Acid-doped polybenzimidazoles : a new polymer electrolyte , 1995 .

[24]  Søren Knudsen Kær,et al.  Experimental characterization and modeling of commercial polybenzimidazole-based MEA performance , 2006 .